PRODUCT
IRONATE-A is a non-metallic, non-carresive, anti-
Static, non-magnetic, inert floor topping hardener
(dry shake on type) with high density aggregates
and active powder. It is available as a compo-
nent which mixes easily with Ordinary Portland
cement of all grades, and also as a Ready-to-use
Floor hardener,
On proper application it preduces a tough, abra-
sion resistant, non-skid, near to impervious, long-
wearing surface that is static-dispersing and spark
resistant. It improves the resistance of the floor
to oil, grease, mild acids & alkalies, improves
impact reistance and greatly reduces dusting of
the floor.
USES
Light to heavy duty Industrial Floors.
* Warehouses
Godowns
* O.M, Plants
Parking area
Loading Bays
* Machine shops
Workshops
* Decks, Ramps.
Breweries & Laboratories floor
Desalination plants
* Ideal substitute to Normal LP.S. floor
Timing of application is very important. Application
of mix (or ready-to-use IRONATE-A) should begin
as soon as the surface water has disappeared
but the concrete surface is still wet. Excess surface
water will result in lower strength while insufficient
moisture will show crazy cracks, pitting and flaking
of the surface.
Sprinkle the material evenly on the levelled surface
starting from the panelbay edges. The first shake
should consist of half to two-thirds of the total te
be applied. Allow the first shake to absorb moisture
and float the surface. Immediately after floating,
shake on the rest of the material evenly and trowel
it to a smooth finish. If a power trowel is used,
ensure that the surface is sufficiently hardened to
prevent sinking and damage to the surface. Use
ofa bridge to shake on the material, is recommended
in case of large/end panels.
ADVANTAGES
Economical
Eliminates screedigranolithic topping
Anti-static
Oil, grease reistant floor
Inert, Non Toxic
* Hard wearing surface
Reduces dusting
* Non-magnetic
* Increase Impact resistance
* — Non-corrosive
APPLICATION GUIDELINES
Surtace preparation : Surface should be free
from dirt, cil, laitance, grease, loose particles ete.
When applying on old concrete: ensure that the
sub-basae is sound and surface properly cleaned
Cracks, joints, loose scales etc, should be prop-
erly repaired before application, Minimum 50mm
thinckness is recommended in such cases. |
The base concrete should have minimum com.
pressive strength of 160 kg per sq. cm. inorder
to take full advantage af the properties of Iranate-
A, it is essential to control the water : cement
ratio of the concrete mix (maximum 0.48). Use
CEMWET WRA-1 to achieve good workability &
high strength at controlled wis ratio.
Application : When IRONATE-A compound
is to be used, dry mix 2 parts IRONATE- and 1
part O.P.C. by weight until a uniform colour mix is
obtained. Ready-to-use IRONATE-A is to be applied
direct
CURING : Begin curing as soon as possible
after finishing but without marring the surface.
Alternatively apply cure well, resin based curring
compound. Incase of conventional curing, atleast
14 days curing is recommended.
CONSUMPTION : 2 kg to 7 kg per sq. m.
depending on the use of the floor.
STORAGE : Store in a cool, dry place
PACKING : 50 Kg bags.
GRADES AVAILABLE : Grade A (250%
strength of Normal Concrete), Grade 8 (150%
strength of Normal Concrete)