Hand Tools
Name Date
1. The two basic measuring tools most often used by the carpenter
are the __and_.
A. folding wood rule
B. long tape
C. marking gauge
D.
E.
E
plumb bob
. flexible measuring tape
try square
2. In the illustration below, the measuring tool being used to mark
a rafter is called a(n)
3. In the illustration below are three basic types of handsaws used
by the carpenter. Correctly identify each saw.
Copyright by Goodheare ox Co, In.
Score
»
020 Modem Carpentry Workbook
4. The tooth size of a handsaw is specified by listing the points per 4.
inch. How many teeth per inch are found on an 8-point saw?
5. Ajack plane is commonly selected for general purpose work. 5.
The bed of this plane is _long.
A. 8"to9”
B. 10”
G 12
D. 14"
6. Carpenters often use a small hand plane that has a blade 6
mounted at a low angle with the bevel of the cutter turned
upward. The name of this plane is__.
x
mm 9 OM Db
7. Identify the parts of the standard claw hammer shown below:
8. What type of striking tool is pictured below? 8
a
9. Nail sets are about 4” long, Size is determined by the diameter of 9.
the tip. Sizes vary in_ increments.
A. 1/64"
B. 1/32"
Cc. 1/16"
D. 1/8"
Copyright Gases Wilcox Co, InChapter4 Hand Tools 21
Name
(10. Standard screwdriver size is determined by the length of the 10.
blade measured from the tip to the.
A. ferrule
B. handle
C. head
D. sleeve
11. Identify the three types of screwdrivers shown below. Wa.
12. Astandard clamping tool with wooden jaws is correctly calleda 12.
A. hand screw
B. joiner’s clamp
be CC. frame clamp
D. C-clamp
13, ‘The drawing below shows an edge view ofa standard plane 13. A.
iron. Give the recommended angles for honing and grinding. .
® honing
| “4 isa saw sharpening operation in which the points of the 14.
teeth are filed to equal height.
| A. Leveling
B. Striking
C. Setting
D. Jointing
Copyright Goodhear Woo, Ine22, Modem Carpentry Workbook
15. Look at the illustration below and describe the tool maintenance
being done.
15.
(Copyright Gocdbeart Wills Co, Ine