Settler's of Catan
Land Hexes Box Lid
1 Heavywieght Double Sided Matte Photo paper works best
Practice with scratch paper i recommended,
2. Double sick apo is recommended for constuction.
8. Printn landscape mod,
4. Note tat the colored artwork is very slighty larger than the
Upper fla in four places. The artows show tose places.
isvary importante cut correct at these places. Ths
Sight sizadfference allows for snug ft whout wines.
'5, Cutout al four pices cretuly folowing advice in step 4
6. Crease all he taps on the two sido pieces. Fold the upper
Tap also This fap wil lem th inside of th box sides.
Make sure to fold and creas the ees where tha hex
cers are afte folding down te inside ap. Thee are no
fold marks onthe flap so there wont be any visible on the
Frishod box: Don't skp is sep or stop 8 wil be
impossible.
7. Unio side peoes. Apply double stick tape to back ofthe
section withthe artwork and the side lap af both poo.
Da not put ape onthe unper fap or the lower aps.
8. Atach these plecas together by the two sie aps to
form ang wit he artwork onthe outside.
9. This the tliest part. Now. vor cael old te upper
Tap over the niga of tho ving and smooth out. ls,
make sure the ceases at tha cornars are sharp.
“10. Apply double sti tape to the
‘outsde edges of back ofthe box
top (he ono wih th artwor
11, Carefully attach the box top tthe
‘side of ox one edge at a tie,
12 thdosied put tape on edges of
PRINTED side ofthe second hx
“Tus is usualy not needed
19. Place hs hx wth the printed side
NOT showing inside to box and
press down This way mpertoct,
{utng where somo black nes can
be soon wl rot show This gives the
inside a inshod ook, stay, and
overs any remaining tape.
‘Questions and Comments
Hoton Hotzrae tolerate)Settler's of Catan
Land Hexes Box Bottom
4. Gonstrut his box bottom exacty the same way asthe
box i
(Questions ane Comments:
Hoon Holzgrate (nlzpate)Seberang
Sy ioe
Oats
Eyencwe
ass
4
Settler's of Catan
Ocean Hexes Box Lid
1 Heawywioght Dove Sided Mate Photo paper works best
Practice wih scratch paper is recommended.
Double st tape is recommended for construction.
nt in landscape mode.
"Note that the colored artwork is very sgh larger than the
upper flap in four places. The artows show these places.
is very impocant io out corecty at these places. THs
Sight size aerenoe allows fora srg without wrnkes
{Cutout a four pieces cartuly folowing advice in stop 4
Coase all th aps onthe two sido pieces. Fold tho upper
lap also. This ap wil fom the inside ofthe box sides.
‘Make sxe to fold and crease he sides where the nex
comers are afte felcing down the inde ap. Thor are no
fold marks onthe fap so tore wont be any visible on the
finished box Don't skp this stop or stop 8 wile
Impossiie.
Uniold se pieces. Apply double stick tape to back af the
section withthe artwork an tha side apo bath pieces
(Dp not put ape onthe upper flap or he tower aps.
‘8, tach the side pleces together bythe two ie laps to
form ang wi to artwork onthe outside,
19, Thi the reiet part Now very earful fol the upper
flap over the inside ofthe rng and smooth out. ls.
make sue the cases at he corners ae sharp.
10. Apoty double sick tape tothe
outside edges of back ofthe box
top (he one wits the artwork.
1, Carefully stiach the box top to the
‘si of box one edgo at time
12, desire, put tape on edges of
PRINTED side ofthe second hax
‘This usually not needed
18, Pace tis hex with the printed side
[NOT showing inside the box and
press dawn. This way imperfoct,
Sting where some back ines can
bo soon wi ot show This gives the
inside a fried look tai, and
covers any remaining tape,
‘Questions and Comment to
Holon Holzgrae (olzgrate)Settler's of Catan
Ocean Hexes Box Bottom
4. Construct his box bottom exacty the same way asthe
ox i
(Questions ane Comments:
Hoon Holzgrate (olzpate)