Professional Documents
Culture Documents
Diablo3d PDF
Diablo3d PDF
4mm carbon fiber tube. Cut a channel (per plan) on the bottom of the
wing only and CA or RC-56 in place.
Landing Gear
Wing
All parts are cut from 6mm Depron unless stated otherwise NOTE: landing gear shown is not functional
but is recommended for improved flight
performance
Aileron Servo
Dashed line repre-
sents alternitive cut
line if 6mm side plate
xBrace is used Servo Servo
cutout cutout
DIABLO-3 D PARK FLYER SPECS FLIGHT SYSTEM RECOMMENDATIONS MATERIALS LIST HINGE DETAIL PUSHROD DETAIL BUILD & FINISHING DETIALS
* GWS 12x6 Slow Flyer * 4-E-flite Micro Control Horns No. EFLA200
* APC 12x3.8 electric slow flyer OR...4 Du-Bro Micro Control Horns No. 848 .040 Solid Carbon Rod push rods
2 * 4 Du-Bro Micro E/Z Links No. 849
* .032 wire control arms
Inch Scale reference, * 1/2” Nylon Filament Strapping (3M brand)
check after printing. * Zagi tape for trim scheme (optional)
* Straight edge razor-blades
3 * No. 11 Xacto knife Heat shrink tubing
* Metal yardstick
* 3M Photomount Spray Adhesive
(for plan transfer to Depron)
® Copyright 2005 3Dbatix.com. All rights reserved. Thick CA works fine for mounting the light ply motor Not speed control and Rx locations. Battery is on the Colored Zagi tape works great for trim. It’s best to trim
mount. opposite side. each part before assembly.
4
3 2 1 0