[wae] 7
22.2 Stop Valve
The stop valves are used in pipe lines when quick control or sudden shutting off of the flow
of the fluid is desired. The stop valves of several designs are in use, of which the most common type
of the stop valve used in water and steam pipe lines is dealt here.
The stop valve shown in Fig. 22.1 is assembled from the parts shown in Fig, 22.2-1 of 2 and
2 of 2. The body—Part No.1 has
two parallel flanges to facilitate its
‘mounting in the pipe line. A valve
seat—Part No.6 is fitted in the flow
passage of the valve body. A lift
type of valve —Part No.4 is con-
nected to the lower end of the
spindle—Part No. 7 by a collar —
Part No.8 and a taper pin—Part
No.17. The cover —Part No.2
which is secured to the body of the
valve by studs—Part No.10 and
nuts Part No.14. A gland—Part
No.5 ismountedon the coversoas
to retain the fibre packing—Part
No. 16 stuffed into the stuffing box
provided in the cover by two
studs—Part No.11 and nuts —Part
No.15. Thespindleis screwed into
a bridge —Part No.3 supported at
its ends by two collar studs Part a>
No.9 which are mounted on the
cover. A hand wheel—Part No. 12
isfitedat the top end ofthe spindle
and secured to it by a nut —Part
No.14.
Exercise
Fig. 22,21 of 2 and 2 of 2
shows the details of a STOP
VALVE.Draw the following views
of the assembly to 1:2 scale.
1. Front view in section,
2. Top view.
@ stop vawe (11)
3. Right view. Fig22sMACHINE DRAWING.
en dois & Jo 86190
JAWA aOls 40 STVLIO
joey
3UOTrONYE a
368‘ vas]
1