Professional Documents
Culture Documents
1. Environmental Conditions
protection requirements .
2. Installation Requirements
experienced people.
3. Dimension
589mm
1198mm
1498mm
4. Retrofit Instructions
Schematic Wiring Diagram
G13 Base
G13 Base
Electronic Ballast
L Ballast
Fluorescent Tube
L Fluorescent Tube
S
N Starter
N
LED Tube
LED Tube
2. Turn fluorescent tube and starter to the anti-clockwise position and pull it out.
3. Remove ballast and starter or electronic ballast where applicable, and the
corresponding wires including branch circuit wires and ballast wires. If existing Non-Shunted
lampholder terminals are shortened by a jumper (as in instant start circuit), then remove
the jumper.
Put L, N into the sockets (attention:put the side with laser printing in).
Multiple-set Installation
1. According to the Multiple-set Installation Graphic , it is the same as the one set
INSTALLATION CODE BY A PERSON FAMILIAR WITH THE CONSTRUCTION AND OPERATION OF THE
1. Risk of fire or electric shock. The electrical rating of these products are 120~277V . The installer must
2. Risk of fire or electric shock. Luminaires wiring, ballasts, or other electrical parts may be damaged
when installing the reflector kit hardware. Check the enclosed wiring and components.
3. Risk of fire or electric shock. Reflector kit installation requires knowledge of fluorescent lighting luminaires
electrical systems. If you are not qualified, do not attempt installation, contact a qualified electrician instead.
4. Risk of fire or electric shock. Install this kit only in the luminaires that have the construction features
5. To prevent wiring damage or abrasion, do not expose the wiring to edges of sheet metal or other sharp
objects.
6. Do not make new holes or enlarge existing ones in your fixture when installing the kit.
WARNING - Risk of fire or electric shock. Install this kit only in the luminaires that have the
WARNING: To avoid potential fire or shock hazard, do not use this retrofit kit in luminaires employing