Professional Documents
Culture Documents
xvfdgdg
High early strength, high range water reducing/superplasticising, admixture for precast concrete
DESCRIPTION PROPERTIES
DUCONMIX WR SP 300 is an admixture of a new DUCONMIX WR SP 300 has a different chemical
generation based on second-generation structure from the traditional PCE polymer
polycarboxylic ether polymer with high early based superplasticisers. The base PCE molecule
strength gains. DUCONMIX WR SP 300 is free of used to formulate DUCONMIX WR SP 300 was
chloride & low alkali. It’s compatible with all custom made using nanotechnology to enable
kinds of cements. effective dispersion with minimum hindrance to
hydration process. It consists of a carboxylic
RECOMMENDED USE ether polymer with long side chains and short
DUCONMIX WR SP 300 is suitable for main chains. At the beginning of the mixing
making precast concrete elements at all process it initiates the same electrostatic
workabilities including Rheoplastic or dispersion mechanism as the traditional
Super Workable Concrete having fluid Hyperplasticisers, but the short main chains
consistency, no segregation, a low water facilitate quick start of hydration process. Rapid
binder ratio and consequently high early adsorption of the molecule onto the cement
and ultimate strengths. particles, combined with an efficient dispersion
As a component of Zero Energy System. effect maintains workability yet exposes
Concreting in cold weather. increased surface of the cement grains to react
FEATURES AND BENIFITS with water. As a result of this effect, it is possible
Achieve high early strengths. to obtain earlier development of the heat of
hydration, rapid strength development of the
Eliminate heat curing.
hydration products and as a consequence,
Improve surface appearance.
higher strengths at a very early age.
Produces Rheoplastic and Rheodynamic
concretes having a low water binder TEST CERTIFICATION/APPROVALS
ratio. ASTM C494 Type F
Optimize curing cycles by reducing EN 934-2 T3.1/3.2
curing time or curing temperatures. IS 9103: 1999
Eliminate the energy required for
placing, compacting & curing DOSAGE
Increase productivity/ reduction in cycle Optimum dosage of DUCONMIX WR SP 300
time. should be determined in trial mixes. As a guide,
Produce durable precast concrete a dosage range of 500mg to 1200mg per 100kg
elements. of cementitious material is normally
recommended. Due to variations in concrete
Improved engineering properties,
materials, job site conditions, and/or
compared to traditional superplasticiser
applications, dosages outside of the
such as early and ultimate compressive
recommended range may be required.
and flexural strengths, reduced
shrinkage and low permeability. Over dose effects:
CORROSIVITY (NON CLORIDE, NON-CORROSIVE) Care should be taken during use and storage to
DUCONMIX WR SP 300 admixture will neither avoid contact with eyes, mouth, skin and
initiate nor promote corrosion of reinforcing foodstuffs (which can also be tainted with vapor
steel embedded in concrete, prestressed until product fully cured or dried). Treat splashes
concrete or concrete placed on galvanized steel to eyes and skin immediately. If accidentally
floor and roof systems. Neither calcium chloride ingested, seek immediate medical attention.
nor any calcium chloride-based ingredients are Keep away from children and animals.
used in the manufacture of DUCONMIX WR SP
300 admixture. In all concrete application, this
admixture will conform to the most stringent or
minimum chloride ion limits currently suggested
by construction industry standards and
practices.