Professional Documents
Culture Documents
Thermodynamic Properties of Supercritical Steam PDF
Thermodynamic Properties of Supercritical Steam PDF
Supercritical Steam
Ashok Malhotra
Copyright 2006 by Ashok Malhotra.
Published by SteamCenter.com
82, Third Avenue
G Defence Colony
Jaipur 302 021
In association with
Lulu.com
3131 RDU Center, Suite 235,
Morrisville, North Carolina 27560
www.Lulu.com
Introduction
T* = (P*) F
1
Pranav Kumar and Ashok Malhotra, The Pseudocritical temperature of steam,
Unpublished report, Department of Mechanical Engineering, IIT Delhi,
December 2000
where,
T* = tsc/tc
P* = p/pc
and
Industrial Formulations
2
International Formulation Committee of the 6th International Conference on
the properties of steam 1967, The 1967 IFC Formulation for Industrial Use,
Verin Deuscher Ingenieure, Dusseldorf. 1967
3
W. Wagner et al, The IAPWS Industrial Fomulation 1997 for the
Thermodynamic Properties of Water and Steam, Transactions of the ASME,
p150, vol. 122, January 2000
the range of interest for steam power calculations and primarily the range
of the present steam tables. Extensions for higher temperatures are
available4 (See also5) but these were not in preparing the present tables.
4
A. Malhotra and D.M.R. Panda, Thermodynamic Properties of superheated and
supercritical steam, Applied Energy, p 387, Vol 68, 2001
5
M. Yamazaki and T. Muto, Extrapolation of IAPWS Industrial Formulation to
high temperature above 800 0C, The 14th International Conference on the
Properties of Water and Steam (14th ICPWS), "Water, Steam and Aqueous
Solutions for Electric Power - Advances in Science and Technology -” Kyoto,
Japan, August, 2004.
6
On the Rational selection of Reheat Pressure Ratios in Supercritical Steam
Cycles, A. Malhotra and R. Satyakam, ECOS 2000, University of Twente, the
Netherlands, July 5-7, 2000
7
Influence of Climatic Parameters on Optimal Design of Supercritical Power
Plants, R. Satyakam and A. Malhotra, Paper No. 2000-2987, AIAA, 35th
Intersociety Energy Conversion Engineering Conference, Las Vegas, 24-28
July, 2000
Need for Supercritical SteamTables
Units
p t v u h s