The document outlines the steps for performing an online upgrade of a 3Par storage system. It lists tasks to complete before the upgrade such as stopping processes, checking health and load, and verifying readiness. It then describes post-upgrade steps like restarting tasks, checking versions, and verifying host connectivity.
The document outlines the steps for performing an online upgrade of a 3Par storage system. It lists tasks to complete before the upgrade such as stopping processes, checking health and load, and verifying readiness. It then describes post-upgrade steps like restarting tasks, checking versions, and verifying host connectivity.
The document outlines the steps for performing an online upgrade of a 3Par storage system. It lists tasks to complete before the upgrade such as stopping processes, checking health and load, and verifying readiness. It then describes post-upgrade steps like restarting tasks, checking versions, and verifying host connectivity.
Run statcpu and statport and check utilisation is below 50% If possible suspended tasks that would cause a heavy load eg backups Stop AO, DO, and RC tasks before the upgrade. Plus stop anything else that interacts with the system such as scripts
Stop system reporter. Stop windows service – 3Par System Reporter
Sampler Service Showtask – and check for any DO activity Stop any software that directly interact with the SAN e.g. Recovery Manager, scripts etc. Stop RC Check no one is logged in showuserconn Checkhealth again. checkhealth -svc detail performs a full health check on the system checkupgrade to verify if the system is ready to undergo an online upgrade. Check current connectivity status of the hosts showhost -pathsum All upgrades until after 3.1.3 are performed by HP, so next HP should install the update for you. 2. POST UPGRADE
Check version is as expected showversion –a -b
Verify connectivity of hosts showhost –pathsum, plus check
monitoring software attached hosts etc. for any potential issues Restart suspended tasks setsched -resume_all . Check schedules running again showsched Change Windows 2008 and 2012 to host persona 15 sethost – persona 15 servername Remove default CPG. removecpg Restart system reporter windows service (3Par System Reporter Sampler Service) plus any other software you stopped such as Recovery Manager Resume backups and any other systems you suspended to reduce the load on the SAN Check for new CLI and management console from FTP supplied by HP or software depot. Check compatibility in SPOCK Plus if you use any other 3Par software such as Recovery manager VSS provider etc check in the release notes for the latest version and then download via supplied FTP link from HP or from the software depot