Professional Documents
Culture Documents
: :,
,:::::::: ::` ::: :::
,:::::::: ::` ::: :::
.,,:::,,, ::`.:, ... .. .:, .:. ..`... ..` .. .:, .. :: .::, .:,`
,:: ::::::: ::, :::::::
`:::::::.,:: ::: ::: .:::::: ::::: :::::: .::::::
,:: :::::::: ::, :::::::: ::::::::.,:: ::: ::: :::,:::, ::::: ::::::, ::::::
::
,:: ::: ::: ::, ::: :::`::. :::.,:: ::,`::`::: ::: :::
`::,` ::: :::
,:: ::. ::: ::, ::` :::.:: ::.,:: :::::: :::::::::
::` :::::: :::::::::
,:: ::. ::: ::, ::` :::.:: ::.,:: .::::: :::::::::
::` :::::::::::::::
,:: ::. ::: ::, ::` ::: ::: `:::.,:: :::: :::` ,,,
::` .:: :::.::. ,,,
,:: ::. ::: ::, ::` ::: ::::::::.,:: :::: :::::::`
::` ::::::: :::::::.
,:: ::. ::: ::, ::` ::: :::::::`,:: ::. :::::`
::` :::::: :::::.
::, ,:: ``
::::::::
::::::
`,,`
http://www.thingiverse.com/thing:1447214
Cyclone Dust Collector (Remix) by PcTronics is licensed under the Creative Commons
- Attribution - Share Alike license.
http://creativecommons.org/licenses/by-sa/3.0/
# Summary
The holes from the base are now same and i make 2 adapters to fit in.
At the bottom i change the hole so i can screw a bottle of coca cola.
Not yet tested but i guess it will work, i will inform you if not :).
<h3>28/03/2016 Update</h3>
A video of testing it
<p>This is an <a href="https://www.youtube.com/watch?
v=FEvztl8UPPk&feature=youtu.be/">
video testing it</a>.</p>
It works really good.
<h3>20/01/2017 Update</h3>
An 57mm OD Adaptor after request, not printed but should fit and work.
<h3>25/02/2017 Update</h3>
After request a assembled cyclone with height 187.7mm, not printed but should work.
# Print Settings
Printer: SmartRapCore
Rafts: Doesn't Matter
Supports: No
Resolution: 0.25
Infill: 60
Notes:
3 Perimeter layers
Support no need but maybe is little messy at the base holes, nothing important but
you will need to clean it a little.