TESTING AND ADJUSTING TORQUE CONVERTER,
‘TESTING AND ADJUSTING TRANSMISSION OIL PRESSURE
TESTING AND ADJUSTING
TORQUE CONVERTER,
TRANSMISSION OIL
PRESSURE
Testing
Coolant temperature: Within operating range
Torque converter oll temperature: 60 80°
A Set the bottom of the bucket horizontal, lower
the bucket completely to the ground, apply the
parking breke, and put blocks securely under
the tres.
1. Measuring torque converter charge pump oil
Pressure (clutch main regulator oil pressure)
1) Remove the cover at the left of the trans.
mission.
2) Remove oil pressure measurement plug
(PT1/8) (1) from the transmission control
valve, then install nipple C2 and connect oil
pressure gauge C1 (5.9 MPa {60 kgicm*).
3) Start the engine and measure the oil pres-
sure with the engine at low idling and high
iting.
2. Measuring clutch inlet port oil pressure
1) Remove the cover at the left of the trans-
mission,
2) Remove oil pressure measurement plug
(PT1/8) (2) from the transmission control
valve, then install nipple C2 and connect oil
Pressure gauge C1 (5.9 MPa {60 kgicm*))
3) Start the engine.
4) Measure the 1st, 2nd, 3rd, and 4th clutch oil
pressure with the engine at low idling and
high idling under the following conditions,
i) Place the directional lever at neutral.
ii) Place the speed lever at the speed range
to be measured.
5) Measure the FORWARD and REVERSE clutch
oil pressure with the engine at low idling
and high idling under the following condi-
tions.
i) Turn the transmission cut-off selector
switch OFF.
ii) Depress the brake.
iil) Place the speed lever at 2nd.
iv) Place the directional lever at F and R.
20-116
o
usi903Cus1903¢
TESTING AND ADJUSTING
|. Measuring pilot oil pressure
1) Remove the cover at the left of the transmis.
sion.
2) Remove oil pressure measurement plug
(PT1/8) (3) from the transmission control
valve, then install nipple C2 and connect oil
pressure gauge C1 (2.5 MPa {25 kg/cm’)
3) Start the engine and measure the oil pres-
sure with the engine at high idling.
4. Measuring torque converter outlet port oil pres-
sure
1) Open the cover at the left of the engine, and
peel back cover (4)
TESTING AND ADJUSTING TORQUE CONVERTER,
"TRANSMISSION OIL PRESSURETESTING AND ADJUSTING
2) Remove oil pressure measurement plug
(PT1/8) (5) from the transmission control
valve, then install nipple €2 and connect oil
pressure gauge C1 (2.5 MPa {25 kg/cm’).
3) Start the engine and measure the oil pres-
sure with the engine at low idling and high
idling.
TESTING AND ADJUSTING TORQUE CONVERTER,
TRANSMISSION OIL. PRESSURE
‘aevoou8t
claten
cae
ow01513
usig03c