Professional Documents
Culture Documents
MP 0018
MP 0018
A. Test nut
B. Test plug
C. Inspection ring
D. Lock plug
18. To change the direction of a single piping line from vertical to horizontal, uses a __.
A. 45o Double tee
B. 90o Elbow
C. Clean out
D. Tee and clean out
19. Part on a boiler that permits emptying or discharging of sediment.
A. Boiler blowoff
B. Boiler cleanout
C. Relief drain
D. Discharge valve
20. It is the unobstructed open edge of a fixture.
A. Trim
B. Edge
C. Ring
D. Frame
21. For driven pipes, the drive pipe should be ____ larger than the pipe to be held.
A. One size
B. Two size
C. Three size
D. Same size
22. What do you call the space between the pipe and the pipe sleeve?
A. Pipe space
B. Pipe gap
C. Annular space
D. Annular gap
23. Waster from what fixture may discharge directly to the building drainage system.
A. Food grinder
B. Restaurant sink
C. Hotel kitchen sink
D. None of the above
24. Where can you find a bubbler?
A. Drinking fountain
B. Water closet
C. Lavatory
D. Cistern
25. If offset on the stack between floors is present, no fixtures or horizontal branches connected ___
above or below the offset.
A. 30 cm
B. 90 cm
C. 60 cm
D. 120 cm
26. For a vertical drain pipe what is the ideal airspace?
A. 1/3 of the cross-sectional area
B. 2/3 of the cross-sectional area
C. ½ of the cross-sectional area
D. ¼ of the cross-sectional area
27. Identify the figure shown. It is use in lieu of traditional plumbing vent systems that penetrate roofs
of buildings.
A. Air admittance vent
B. Pressure vent
C. Mechanical vent
D. Movable vent
28. Also called as the traditional vent piping system.
A. Open pipe vent system
B. Durham system
C. Sovent system
D. Single line vent system
29. Generally considered standard weight pipe.
A. Schedule 20
B. Schedule 40
C. Schedule 60
D. Schedule 80
30. For plastic pipes, what does SDR rating stands for?
A. Standard Diameter Rating
B. Standard Dimensional Ratio
C. Static Dimensional Ratio
D. Static Diameter Rating
31. What does the abbreviation PEX or sometimes XLPE stands for?
A. Extra-lined polyethylene
B. Extra-looped polyethylene
C. Cross-network polyethylene
D. Cross-linked polyethylene
32. It is the common code for standard cast iron pipe.
A. SU
B. SW
C. SV
D. SX
33. It is the common code for extra heavy cast-iron pipe.
A. XH
B. EH
C. EX
D. XHC
34. The meaning of RCP.
A. Reserved Concrete Pipe
B. Reserved Ceramic Pipe
C. Reinforced Concrete Pipe
D. Reinforced Ceramic Pipe
35. Where is a bell hole present.
A. Trenches
B. Fixtures
C. Pipes
D. Cistern