Flat Angular Workpieces
°
fh
254
"
—
'd = thickness
of thick
unbroken line
[1]
. Dimensions are entered in milimetres without measures. Any
deviating dimensions must be specified in their corresponding
measures.
In the line group 0,5 the dimension arrows are 2,5 mm long and
blackened.
|. Dimension lines must have a distance of about 10 mm from the
object edge and 7 mm from parallel dimension lines. The dimen-
sions are to placed above the dimension lines and should be
staggered.
Dimension lines may only be broken if short of space in order to
enter dimensions.
The extension lines project 1 to 2 mm beyond the dimension lines.
|. Dimensions must be either read from below or from the right. For
‘small dimensions, e.g. under 10 mm, the arrows are placed outsi-
de. Should the space for dimensions between the extension lines
or the object edge be insufficient, dimensions are entered above
the dimension arrows.
. The dimensioning starts at the reference edges. The smallest
dimension is nearest to the workpiece. Obvious dimensions are not
entered.
. Symmetrical workpieces are dimensioned symmetrical to the
center line which extends 2-3 mm beyond the object edge.
Flat workpieces are presented in one elevation. The workpiece
thickness may be specified within the area or next to it
Example: t = 2 mm
Dimension lines may not be drawn from (a) object edges, used
as (b) extension lines and shall not be (c) crossed by other
dimension lines.
Dimension figures may not be divided by lines.
Center lines are to be broken
oH