Plunger Sensor .
Flowco Production Solutions
IMPORTANT SAFETY INSTRUCTIONS
SAVE THESE INSTRUCTIONS
PROTECTION MAY BE IMPAIRED IF THIS
DEVICE IS USED IN AN APPLICATION OR
MANNER NOT SPECIFIED IN THE MANUAL
‘This manual contains important instructions that
shall be followed during installation and
maintenance of the 1950-243 Tri-Coil Sensor.
‘The manufacturer, distributor, and retailers are not
responsible for improper installation or damage
caused by the installer. Improper installation can.
cause the warranty to be voided, and may create
safety hazards.
Because of the varying types of installations, some
of these instructions may need to be modified to
match the particular installation being done. Always
use common sense and safety precautions, and
always follow all local codes for proper installation.
In the absence of local codes, follow the Nations
Electrical Code (ANSUNFPA 70) in the USA, or the
Canadian Electrical Code in Canada.
WARNING! DO NOT CONNECT OR DISCONNECT
WIRING IN A HAZARDOUS ENVIRONMENT
| Intended Use
“This product is intended to be installed on a lubricator to
sense plunger arival as part of a plunger-lift gas well.
| | WARNING! DO NOT CONNECT OR DISCONNECT
WIRING IN A HAZARDOUS ENVIRONMENT _
| Install sensor on pipe or lubricator using che iteprated
} hose clamp. Install with sensitivity adjustment pot and
Wiring facing down. Connect wiring as described inthis
‘Use a small sorewdriver to adjust the sensitivity pot
necessary. Adjust clockwise for higher sensitivity,
counter-clockwise for lower,
a
| [Wire | Desripton cirical |
| Tned__ Power
| Black Power- Gro! 7
|Green | Active low open drain ‘Open drain, with:
| ouput; pull up with ‘S0mA rated
Satvednor,10kOhm reseable ise
to 100kOhm
| Specifications
PanNumber 1950243
“Tnput Voltage 30,VOC 7
Curent Usage less than 1O0uA typical
Operating Temp. 2000 60°C
Environmental Urethane Encapsulated