Professional Documents
Culture Documents
This project you will be using Imagine & Shape, Assembly, Part Design, and Sketch Tracer Workbench Go
to Save management, save the product as LastName_RaceCar. Save the CATpart, LastName_RaceCar.
It’s ok, if yours doesn’t become rounded in the front and end as long as it is covered up.
Add transparency to the LastName_RaceCar. (Right click> Properties> Graphic Tab)
Wheel
Use the sketch command and sketch shown below, once complete use the shaft command.
Draw the second sketch shown below and use the pocket all the way through.
Use circular pattern and apply material “black”
The wheel should be 2mm away from the body of the car
When assembled it should look like this.