Professional Documents
Culture Documents
Pages
Source Old HMS-TD2~8, Committee
General tolerance of canned product complia Report No. 2215, Production
nce Division Standards
Items Contents
Processing tolerance
of right-angled bend
(Committee Report
2215)
0 to 3.2
Special
1.5 times of products are
From 3.2 to 6.0
tolerance of m taken the value
From 6 to 9 of its 50%.
From 9 to 12
Note: In this case, m is considered as 300mm or less.
General tolerance of
angle bends Table 24.8 General tolerance of angle Unit
More than1600
Processing tolerance Radius of inner surface when the cylindrical bending is processed and
of cylindrical bending the dimensional tolerance of straightness in longitudinal direction are
(Committee Report mentioned in Table 24.9.
2215)
Note: As for sign, the changes as per 1m in the maximum value are considered as 2mm.
History
Design manual
Pages
Items Contents
Scope of General tolerance of canned product is specified in this chapter. Moreover, the general tolerance is the
application permissible dimensional difference when dimensional difference is not specified in the drawing.
Class wise display When class wise display of each general tolerance is required, it depends on table 24.1
method
Table 24.1
Application Display method
class
Applicable product
2nd class Does not specified anything General product
Illegible
Special goods
st 1st class general tolerance
1 class st
Can 1 class general tolerance is required
From 1600 to
3200
Illegible
Not possible
Not possible