TECHNICAL DATA SHEET
AQUAPLUG Hydraulic Cement
EM
ALLGEMEINE BAU - CHEMIE PHIL. INC.
‘Address: OIF Asian Star Building, 2404 Asean Drive,
Filinvest City, Alabang, Muntinlupa City 1781 Philippines
‘Tot: (+63 2) 8426891 m Fax: (+83 2) 8427148 w info@abe-ph m www.ade-ph
En
AQUAPLUG Hydraulic Cement
Ee
[AQUAPLUG isa coment based, rapid salting hydraulic compound. Iis specially
formulated to instantly stop the flow of running water under pressure, Holes,
cracks & faults, which may cause loakage & seepage through concrate walls,
slabs & uncer floors are securely plugged. Aquaplug willalso slop leaks around
insets such as pipes & sleeves for general masonry works. is also applicable
for architectural or non-structural concrete & masonry repair works on mines,
Sewers, tanks, tunnel reservoirs and pits. Suitable for interior and exterior
concrete surfaces, as wellas under water applications.
Ye
&, watrrot @)
Rapid Setting YY
Non-corrsive
Volume Stable
Fast & Easy
@O
‘CLASSIFICATION STANDARD
& CIN 18555 (48) German insttuto for Standardization
RO
1kg = H10 x W2.5 x D2.5cm Volume
sie: Coverage ie dependent on lomporature, warknansip and se condone]
RS
‘The surface must be clean and fr
loose material, oil & chemicals. Use a wire brush or any suitable tool to clean
the surface,
fom contaminants such as dct, dust,
For gaps with width and depth smaller than 18mm, chisel the hole to make the
largest part ofthe opening and going narrower as it connects to the hole. It
hole or crack isnot leaking during the time of repair, soak area with water
before applying Aquaplug
Co
1 xing
Mic Aquaplg with loan water tor
{hast apernatayth ame ohape
aeine nals orcrack tbe puggee| 3 parts
Aaueplugmustoeaplesimmedatsy
before the mass harden (1 minute
or acang loon wate), Acca |
Ceri
1 part
ey
2.Application
4. Push and force a mass of Aquaplug firmly with your palm, atrowel ora
block of wood into the opening and hold for 2 minutes. To seal wall to
{loor joints, press Aquaplug with a round tool & smoothen as it sets on
the applied area. Note: Aquaplug noods 2-3 minutes fo resist water
prossuro. Constant exposure to water will harden Aqueplug allowing it
tosetonthe application area,
b. Use aknifeortrowelto remove excess product. Keep the area dampforat
least 15 minutes,
SpecialApplications:
To stop streams of running water from flowing through concrete walls ot
pipes, apply successive small rolls of Aquaplug by pushing them firmly
starting at the highest point of the crack. When the application area is,
where water pressure is greatest, hold Aquaplug in your hand or use a
trowel untila slightly warmth or drying starts.Exert pressure overAquaplug
fora few minutes, oruntilmaterial setsandactivewaterstops flowing,
3.Finishing
Wait 24 hours or untitAquaplug has completely cured before any fishing
applicationcanbedone
COO
concrete water tanks
under floors
EET
basement
1.25kg and Skg tin can
Soe
\Whon stored ina cool dry place & ints orginal unopened packaging, Aquaplug
Hydraulic Comentwilremain usable one year from date of manufacture.
MI
Due to variety of applications, diferent working methods and the various
properties of bases, we cannot assume responsibiliy or labilty with rogard
to the application of our products. Our guarantee and liability are restricted
to the qualty of our products at the ime of acceptance of the customer of
Such products. In no case shall our lablty extend beyond replacement of
defective products f any, found atthe time of acceptance. For alldeliveries
and services, our General Sales Condition including warranties stipulated
for each case are valid
MN ene en i