OPERATOR MANUAL MVT 660 T
ELECTRICAL SYSTEM |
STARTER
The starter is mounted on the lett side of the engine, and no maintenance is required other than to
ensure that the terminals are kept clean and secure, Should the starter not function correctly , contact
your dealer,
ALTERNATOR
The alternator is mounted on the left side of the engine . The alternator and integral regulator are
designed to operate in a system which is polarized in one direction only, therefore it is necessary to
take the folllowing precautions when working on the battery charging circuit, otherwise serious damage
may be caused to the electrical equipment.
= Do not operate the alternator with an open circuit, always ensure the connections are secure.
- Itis important that the cable terminals at the rear of the alternator are tight when the engine is running
otherwise damage will be caused to the alternator.
- When installing a battery , ensure that the connections are correcity polarized. It is essential that the
cable marked (+) is connected to the positive (+) terminal of the battery, and that the cable marked (-) is
connected to the negative (-) terminal on the battery and to earth.
- When using a second battery to assist engine starting, always connect terminals of similar polarity
(voir fig.A). Any battery used in this way must be of the same voltage as that fitted to the truck. |
- When using an external battery charger, always connect the charger positive (+) lead to the positive
(+) terminal of the battery, and the negative lead (-) to the negative (-) terminal, and disconnect the
battery earth lead.
- Never short circuit or connect the alternator terminals to earth.
- Never reverse the connections to the alternator terminals.
= Do not remove or replace any electrical system connections
while engine is running,
- When carrying out electrical welding operations on the truck,
connect the negative lead from the welding equipment to the
part being welded so that high tension current does not pass
through the alternator , and disconnect the battery.
LIGHTING
Ablown bulb must be changed immediately .
Do not handle a new bulb with bare or ditty fingers, because any traces of grease , oll or sweat, evapo-
rate when the bulb is hot and then stain the reflector.
Nover touch or attempt to polish the reflector. Only open the headlamp when changing the bulb.
BATTERY
The efficiency of the battery is progressively reduced as the ambient temperature falls and ceases to
function as of - 40° C (-40° F).
Do not attempt to use the starter if the battery has been exposed to temperatures in the order of - 29°
C (-20° F) the battery should be warmed betore attempting this by immersing it in warm water up to 5
om below the cell caps,
If the temperature is very low , remove the battery from the truck and store in a warm environment until
the battery is required for use. \opana
‘OR MANUAL
LEGEND
ELECTRICAL EQUIPEMENT ( SYSTEM)
Al ~ Electric horn back-up alarm (tab.2)
A2 ~ Electric horn (tab.3)
Bl ~ Battery 12 Volt (tab.!)
cl - Cab connection (tab.2)
ce ~ Back-up alarm dashboard connection (tab.3)
3 - Connection (steering wheel control) (tab.3)
ca - White connection 21 poles (tab.4)
os - Green connection 21 poles (tab.5)
ce - Flashing connection (tab.5)
i) - Electrovalve (forward gear) (tab.2)
E2 - Electrovalve (reverse gear) (tab.2)
E3 - Electrovalve stop engine (tab 2)
£4 - Electrovalve safety device (tab. 3)
al - Alternator (tab. !)
0 - Switch (parking brake) (tab.2)
l2 ~ Reversing gear (tab.2)
13 = Intermittence back-up alarm (tab.2)
‘4 ~ Stop switch (stop light) (tab.2)
5 + Tilting switch (tab.3)
Ig - Pressure switch (air cleaner) (tab.5)
7 - Pressure switch (low pressure oil engine) (tab.6)
ut - Side light switch (tab.4)
Mi - Starter motor (tab. 1 )
PI ~ Left rear stop light (tab.2)
p2 = Right rear stop light (tab.2)
P3 ~ Left front turn indicator (tab.3)
P4 ~ Left rear turn indicator (tab.3)
PS ~ Right front tum indicator (tab.3)
PS ~ Right rear turn indicator (tab.3)
P7 - Left headlight (driving beam) (tab.4)
Pa ~ Right headlight (driving beam) (tab.4)
Po ~ Left headlight (lower beam) (tab.4)
P10 - Right headlight (ower beam) (tab.4)
PIL + Left side light (tab.4)
Pi2 + Left tail light (tab.4)
P13 + Right side light (tab.4)
P14 ~ Right tail light (tab.4)
PIS - Pivotable headlight (tab.5)
RA + Starting relay (tab. !)
1 - Water temperature indicator (tab.5)
12 - Fuel gauge (tab.5)
TR + Starter (lab.1)
KEY - Starting switch (tab.1)
MVT 660 T
COLOUR
A: Azur
B: White
C: Orange
G: Yellow
H: Grey
L:Blue
M: Brown
N: Black
R: Red
S: Pink
V: Green
Z: Violet
Le |OPZRAVOR MANUAL
MVT 660 T
RA
A
us
ba
seve BETRED
: i
I
sae 9
2
waar 6
eo
of
3
8
——i}
UI fel a
slflé
[la] 8
Wt
128
FejmanitaaDusan | BOOS
MVT 660 T
OPRRATOR MANUALMVT 660
OPRRATOR MANUAL
7 er | aT ow Ga] Sa RATS] Fase Loin | _EMORE
sites REG Wee! SaRRRS| aT ol BSS LAW» Gavaw/aeorn
ae or a aha irs a BOSE
I see Ge eee ecco
on 7 ow
a
wv Joa QQ sa va QDea site a
Sy ro . : by “ Wd SUTOd tN
BOOe-H NOLLIINNOD
ic Cea mt
ea ‘es ihe
z Ll leo
yoru 2az0uL
Bid SATO 5.N
NOLDINNOD
na] fro
‘st
ety
iy EB
3in
sin “S5TRr
ne a
ein 3 +MVT 660 T
OPERATOR MANVAR
az T Tse aa] STS Saaee aT
see |otos| MOJINVIA sonfeer’ Mauna ee Geta
aN Te J Tso A RO) ag
[= STOO TOE TOE OEE OEE ELE EL
one + t 1 Ton
Ques n
Thy
7 ain
$i
a ow
Te an
T5F aun
Fae on
en
B-
MANITOU,MVT 660 T
PERATOR WANUAL
v
7 T yo arto ae Ta He] SO TO TiRawe Loa ROLE
a SES was peEROG] aR Wms Das LAW Svan MOSS
I = zs z = z ear ps . . Ss
+ 7 ow
| "
Qera om
a rere
| siete
ald SHTOd 928
Lo NOLWLDANNOD
[SIELISNEWOO aAWaSTE
NOLLISOesTeRRaé - i
BOLYDIGN TOULEO |
I T B oy
B— cu
we ay
[ex] en 2
wyesfee] Tell [st Tels