Professional Documents
Culture Documents
22 1 oz
22.1 oz.
18.6 oz.
38.5 oz. 1/16" wire wheel axel/steering arm
20.6 oz. (Bend 90 deg. at the top to form
27.7 oz. a control arm. Use clamp on ball
7 oz.
oz. link to attach to rudder control horn)
z.
.
.
oz.
2.8 oz. Mount Battery Pack
with 1" Velcro strap.
20.5 oz. Also use adhesive
18.5 oz. Velcro on the side of
ps 26.4 oz. fuselage and back of
mps 25.2 oz.
ps 17.8 oz. pack to secure in
amps 29.3 oz. place.
mps 32.2 oz.
2 amps 38.1 oz.
Turbo Raven 3D
Turbo Raven 3D
Weight 10.5-15.5 oz.
Power 24-39 oz.
Radio 4-5 Chanel
Area 295.4 in2
Loading 5.4-7.3 oz/ft2
WWW.3DFOAMY.COM
oamy
Copyright © 2004 3DFoamy.com
All rights reserved.
Designed and Drawn by Levi Jordan
Updated: 03/4/04.
om 1/32"
e can lid.
Pull
4mm Carbon Spar
Canopy drawings for details only.
HS-56HB
racle
6mm De
10-12# fish
Push/Pull
Pull
Motor stick instilation
Motor stick instilation.
ock You will need to adjust the position of
d. the Carbon rod and motor mount for
nt your motor/gearbox combination. The
the carbon rod may be in a diferent
me location, that is OK.
LiPo Battery
2100(3s2p)
HS-56HB
Or
Aileron Servo (1 Each side)
plates
Suggested CG Starting Point
ten
Molded Carbon Fiber Gear Mount us
1/64" ply doublers on both
M
sides of fuselage (see side view)
Vacuum Formed
vator Joiner
Wheel Pants
6
1.75" DIA
Cut a "V" groove
in foam for
spars. Pull spar
onsider leaving through groove
ong enough, but to make round
e sure to use
ain parts...5 min
will crack under
3/8"x3/8" Hardwood motor bl
GWS 12-6 Slowflyer Prop Groove block to fit carbon ro
If using GWS 350 Drive, moun
block on Carbon rod so that t
prop/drive shaft is in the sam
location as shown on plans.
3/16" zipties
5
5
1
1 2 3 4 5 6