Young Idaho Tansy Essential Oil an
:
Page 1 of 4
MATERIAL SAFETY DATA SHEET February 18, 2010
4. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Name: Idaho Tansy Essential
CAS Number: 8016-87-3
‘Company Name: Young Living Website: www younaliving.com
3125 West Executive Parkway, Lehi, UT 84043 (801) 418-8900 (product info)
{800} 424-9300 or (202) 483-1
7816 (CHEMTREC: for emergencies) REVISION #:
COMPOSITION / INFORMATION ON INGREDIENTS
Ingredient: Idaho Tansy EO (Tanacetum vulgare)
‘CAS Number: 8016-87-3
ACGIH TLV: NOT ESTABLISHED
HAZARDS IDENTIFICA’
HEALTH HAZARD DATA
SignsiSymptoms of Overexposure: Do not use if pregnant. Do not use if you have kidney disease. May
‘cause mid skin and eye irittion. Do not use for children some sources say oral toxin - nat proven.
PRIMARY ROUTES OF EXPOSURE
‘SKIN CONTACT: Yes
INHALATION: Yes
EYE CONTACT: Yes
‘SKIN ABSORBTION: Yes
INGESTION: Yes
CARCINOGENICITY — OSHA:No_IARC:No-—NTP:No ACGIH: No
MEDICAL CONDITIONS AGGRAVATED BY OVEREXPOSURE: None known to TGSC.
EFFECTS OF OVEREXPOSURE: May be irritating to skin and eyes,
EYE CONTACT EFFECTS: May be irritating to eyes.
SKIN CONTACT EFFECTS: May be irritating to skin.
INHALATION EFFECTS: May be irritating if inhaled,
INGESTION EFFECTS: May be harmful if swallowed.
4. EMERGENC
AND FIRST AID PROCEDURES
EYE CONTACT: Flush immediately with clean water for at least 15 minutes. Contact a physician
immediately,
[SKIN CONTACT: Remove any contaminated clothing or shoes. Wash affected areas thoroughly with soap
‘and water for at least 15 minutes. Contact a physician as necessary.
INHALATION: Remove from the exposure to fresh air. If breathing has stopped, administer artificial
respiration and oxygen if available. Contact a physician as necessary.
INGESTION: Give water to dilute. Contact « physician or local poison control center immediately,
‘Young Living ‘wow youngliving.comYoung? Idaho Tansy Essential Oil
ic
Page 2 of 4
MATERIAL SAFETY DATA SHEET. February 18, 2010
IRE AND EXPLOSION HAZARD DATA
Flash Point: 150.3°F = 65.7°C
Lower Explosive Limit: UNKNOWN
Upper Explosive Limit: UNKNOWN
Extinguishing Media: DRY POWDER
‘Special Fire Fighting Procedures: NONE
Unusual Fire and Explosion Hazards: NOT ESTABLISHED
ACCIDENTAL RELEASE MEASURES
Eliminate all sources of ignition. Ventilate area. Cover with inert, absorbent material and remove to disposal
‘container. Spill area may be slippery. Flush with plenty of water.
‘SPILLS PROCEDURE: Wash to Waste treatment system with water. Or for large spills absorb spill with inert
‘material (dry sand), then place in a chemical waste container
HANDLING AND STORAGE
STEPS IF MATERIAL IS RELEASEDISPILL: Absorb using sand or cat liter and recover it into a container.
‘Wash area with hot soapy water.
WASTE DISPOSAL METHOD: Dispose of as normal solids in accordance with local, state and federal
regulations,
PRECAUTIONS-HANDLINGISTORING: Keep container closed. Maintain standard hygiene for food
chemical handing
EXPOSURE CONTROLS / PERSONAL PROTECTION
ENGINEERING CONTROLS: Under normal use conditions, with adequate ventilation, no special handling
equipment is required.
EYE PROTECTION REQUIREMENTS: Wear protective glasses to minimize eye contact
EYE / FACE / RESPIRATORY PROTECTION REQUIREMENTS: Not required in normal use.
‘SKIN PROTECTION REQUIREMENTS: Wear protective gloves to minimize skin contamination.
PHYSICAL/CHEMICAL CHARACTERISTICS
Appearance and Odor: Pale yellow to yellow liquid with warm, sharp, herbaceous aroma:
Vapor Pressure (MM Hg/70°F): Unknown
Vapor Density (Air=1):
Specific Gravi
Bulk Density (LB/Gal) : N/A
Evaporation Rate: N/A
Solubllity in Water: None
Percent Volatiles by Volume: 100%
Young Living wwew.younglving.comYoung? , Idaho Tansy Essential Oil
ING"
Page 3 of 4
MATERIAL SAFETY DATA SHEET February 18, 2010
'Y AND REACTIVITY
(Stability): N/A
IXIDIZING ACIDS (i.e. Sulfuric Acid, Nitric Acid)
Can Hazardous Polymerization Occur: No
Presents no significant hazards concerning stabiity. Is not pyrophoric or reactive with water. Does not
Undergo explosive decomposition, and is stable to shock
44, To:
OLOGICAL INFORMATION
Js generally non-toxic. May be iritating to skin and eyes, especially to sensitive skin. Avoid during
pregnancy.
12, ECOLOGICAL INFORMATION
No environmental hazards are known. Avold pollution to soll, water in accordance with ocal, provincial and
federal regulations.
13, DISPOSAL DATA
Not regulated 2s a RCRA Hazardous waste by the Federai EPA, but may be reguisted in certain states,
“This is a food grade product for industrial and professional use.
14, TRANSPORTATION DATA
yT (49CFR 172) - Domestic Ground Transs
DOT Shipping Name. Consumer Commodity (not more than 4- liters)
Hazard Class: ORM-D
UNID Number: Nene
Marine Pollutant: None
\TA — International Transport
Proper Shipping Name: Consumer Commodity (not more than 4-lters)
Cass or Division: Ciass °
LUNINA Number: UN-8000
Bulk Shipments
Domestic (Land, 0.0.1,
Proper Shipping Name: Essential Oil
Hazard Class: 3
UNINA: UN‘1268
Packing Group: It
Information reported for productsize: 360L8 +
‘Young Living www youngliving.comYoung? Idaho Tansy Essential Oi!
JVING
Page 4 of 4
MATERIAL SAFETY DATA SHEET Fobruary 18, 2010
International (Water, LM.0.)
Proper Shipping Name: Essential Oil
Hazard Class: 3
UNINA: UN1268
Packing Group: It
IATA Class(AIR): 3
IMDG Class(water): 3.2
Information reported for product/size: 350LB +
15. REGULATORY INFORMATION
HMIS (U.S.A)
Health Hazard: 2 Fire Hazard: 1 Reactivity: 0 Personal Protectior
National Fire Protection Association (U.S.A.):
Hoalth: 2 Flammabiti Reactivity: 0 Specific Hazard: None
WHMIS (Canada): Not controlled under WHMIS (Canada).
Protective Equipment: Gloves, lab coat, splash goggles and vapor respirator. Be sure to use an
approvedicertfied respirator or equivalent.
OTHER INFORMATION
PREPARED BY: Donato Polignone PRD NUMBER: USS (Official Copy)
APPROVAL DATE: February 18, 2010 SUPERCEDES DATE: New
ABBREVIATIONS
OSHA ‘Occupational Sefety and Health Administration
TW ‘Threshold Limit Vaive
PEL Permissible Exposure Limit
TWA ‘Time Weighted Average
STEL Short Term Exposure Limit
IMPORTANT: WHILE THE DESCRIPTIONS, DATA AND INFORMATION CONTAINED HEREIN ARE PRESENTED IN GOOD
PATI AND BELIEVED TO BE ACCURATE. THEY ARE PROVIDED FOR YOUR GUIDANCE ONLY. BECAUSE MANY
FACTORS. MAY AFFECT PROCESSING OR APPLICATIONUSE, WE RECOVMEND THAT YOU PERFORM AN
ZESESSIMENT TO DETERMINE THE SUITABILITY OF & PRODUCT FOR YOUR PARTICULAR PURPOSE PRIOR TO USE.
NO WARRANTIES. OF ANY KIND, EITHER EXPRESSED OR IMPLIED, INCLUDING FITNESS FOR A PARTICULAR
PURPOSE, ARE MADE REGARDING PRODUCTS DESCRIBED, DATA OR INFORMATION SET FORTH. IN NO CASE SHALL
THE DESCRIPTIONS, INFORMATION, OR DATA PROVIDED BE CONSIDERED A PART OF OUR TERMS AND CONDITIONS
OE SALE FURTHER, THE DESCRIPTIONS, DATA AND INFORMATION FURNISHED HERE ARE GIVEN GRATIS, NO
OBLIGATIONS OF LIABILITIES FOR THE DESCRIPTION, DATA AND INFORMATION GIVEN ARE ASSUMED. ALL SUCH
BEING GIVEN AND ACCEPTED AT YOUR RISK.
End of MSDS.
Young Living ‘ww youngliving.com