APPLICATIONS:
lgulatin of not pressure to gas compressors and contol
supply or estilo system pressures where the pressure to
‘he tegdater varies more than 2:1 ana regulated pressuxe must
‘be Kept to Tess han 2 pig change,
PRESSURE RANGE:
‘Upstream: 10 peg to 300 poly
Dounstteam: 3 pag 1 280 nig
NOTE:
For uvstream pressure le than 10 poly use outside source
cf supply to eperate Motor Valve Diaphragm.
CAPACITY:
‘Rater Table of Canis.
lassen
eer Vite Sem Assonby
Ounad
(ats see
vvueiracom
PRESSURE REGULATOR
PRESSURE REDUCING BALANCED
OPERATION:
Tho Pilot Assombly and Motor Valve Stom Assemoly
{(Crosshalched) are the only moving units inthe regulator
“The PLOT PLUG eonslste of two stainless alls rio con
ineclee lagother. Lssiteam Preaaute (Res) Ie he steal pres
Sure to the pllot an is also in constant communication wath the
{op sie ofthe MOTOR VALVE DIAPHRAGM. The area of the
MOTOR VALVE DIAPHRAGM Is twico the area of tho moter
vale seal, asting a posive shutof
‘The iswer seal for the PLOT PLUG 1 the Molar vaWe
Diashragm Pressure Inlet eso Yellow}, The upoer seat for te
PILOT PLUG is tho pressure vent (Yollow to Almosphore). The
PILOT SPRING loacs the upper sii ofthe Plat Assembly anc
Is apjesed cn tha undemoath se by the centrale Dawnaiream
Prossure (Bue).
‘Assume the PILOT SPRING Is compressed with the
DUSTING SCREW for a desired Downstream Pressure sae
ling. Wah Dovwrstieam Pressute (luo) 120 lou, the PILOT
SPRING forces the Pilot Assembly dounvar to close the unper
seat (Yellow to Almosphora) ane open the lower seat (Roe to
Yell
"THIS lots fu_Lipsteaam Pressure (Red) ad the uneomeatt
ie ofthe MOTOR VALVE DIAPHRAGM to talanee the pres
sure on th top slo, Upstream Pressuro (Rod) acting under the
motor yalve seat, opens the valve. As Downstoam Pressure
(Phe) inetoases tothe sel pressute the Pils Assembly assumes
‘2 pasion in sehen bath seats ofthe PILOT PLUG are dosed,
‘Should Downstream Pressure (Blue) rise above tho sot pees:
ure, the Pilot Assombiy moves upward against the PILOT
SPRING to open the pressure vert (Yella te Almesphse)
Motor Vaive Diaahvagms Presstze (Yellow) ceereases to repost
onthe Meiot Vale Stem acer
The intermiten bleed pill, thico-way valve action of the
PILOT PLUG agahst is seat acusis the Motor Value Daphragn
Pressure (Yell, reposting the Kletor valve Stem ASSeMe}y
{o ancommadale any rale of flew. The rapid bul sa6Ie
repostloning produoes a tie throng acon
The Motor Valve Disphiacim Prossure (Yellow) is
‘communicate tothe Bonnet area, his pressure acts on
the BALANEING DIAPHRAGKT ta ecunleradl th equa
tne opposite pressure onthe MODULATING
DIAPHFAGM, Ths talarcing acon recuces the etc of
variation Io Upsteam Pressure (Res) onthe contol or
Dounstteam Pressure (Blue) resting in constant
Downstream Pressure Blue} when 10:1 variations occur
'b Unstoam Pressure (ec.
aaa
Issued 3106car.
NO,
aKa
All
aa
fk
aL
am
aun
AP
a
x I MRAY PRESSURE REGULATOR
Quality Since 1948 PRESSURE REDUCING BALANCED
DUCTILE IRON
4298856," aqueg Sere 30% a :
sng ma 6 Song Pa, Bhat HEEL oo
eae" *pocting soot 4942 — Bonnet $55 br ge
ce ig me 7/ Pivot cron $483,
Sing WEDS 7 Boone
Seren these 25,
feet 63, 26"
Nee
. os
opi, 2
noosa, 2Rea' 2
Pater
‘38, shea”
CL. 368, ahaa 2
Suen 307, toRea 3"
Serene de
2aziomeg
ar wousing 1639, 3°,
*Diepnrogm 1640, 3° trae
ane 4019556,/"
~ 1638,2.
Tobing 1826, 3",
Bee
ears
‘Bieptrogm Pate 320136
1358,"
398, 2
Bade"
cower 198 0199 /
Steet ee eles
/ eae eee
de ; en i HEEL ge
rg smi ow SE sahara
aan Be eee
Bi
etn
feat Beetaaie
Yanan SE on ngs Earth
So
230SGTPRB-D 300 RAM pair ke
SnScreneo Sco Sco Fay, enmendaseeanpott sorte eeecn
S18FGTPRED 250 RAN TE -
a
vwieazcom Iesvod 408or
KIMRAY
rgd
PEPER EVES ¢E
GAS CAPACITY CHARTS
200, 275, 300 & 500 Ibs. Maximum W.P. Valves
Gas capacties are based on pressure taken immacately
Lpsiteam and downstream from the regulator in a wide open
pesiton
‘Ciical flow exists across a valve or office whan the dawn-
‘steam absolute pressixe is approximately half of te upstream
‘absolute pressure. Ary decrease in downstream pressure val
not increasa the flaw through tha valve, Ceical Naw eondséons
fn the charts are represented by the MAXIMUM CAPACITY
Une:
HOW TO USE CHARTS: Locate UPSTREAM PRESSURE at
left of char, Follow horizontally across to PRESSURE DROP
(Upstream minus downsveam pressure). Read VOLUME drect
ly below Ifthe horzontal projaction ofthe upstream pressure
{oes not intersect the given pressure dop, flow is cecal. n his
face project UPSTREAM PRESSURE horizontally to tw MAX!
MUM CAPACITY LINE and raed VOLUME directly love
‘iagatsmetneteyareomsie ty VE
A409
Issued 3108GAS CAPACITY CHARTS
220, 275, & 300 Ibs. Maximum W.P. Valves
Gas capacites are based on pressure taken immediatly
upstream and downstream fom the regulator in a wide open
Psion.
Citic Now exists across a valve or aifice when the down
siream absolut pressure is aporoximately half of te upstream
Aacolute pressure. Any docroace In downetvaam proscure wl
hat increase the fow through the valve. Criea flow eandltions|
fn the chants are represertac by the MAXIMUM CAPCITY
UNE:
Atos
faved 3106
or
KIMRAY
eras
GAS CAPACITY CHART
140 70 315
ABSOLUTE PSI. PRESSURE
‘Sin. "6" SERIES
HOW TO USE CHARTS: Locate UPSTREAM PRESSURE at
lett of char. Follow horizorally across to PRESSURE DROP
(Upstream minus dovmeteam prosaure). Read VOLUME direct:
ly balow. i the norizantal projection of the upsteam pressure
‘does not intersect the given pressure drop, flow is crtcal inthis
‘cage project UPSTREAM PRESSURE horizontally to the MAX!
MUM CAPACITY LINE and read VOLUME crecty below.
ahora VE
‘we nsyearKIMRAY
rgd
Gas capacties are based on pressure taken immacately
Lpsiteam and downstream from the regulator in a wide open
pesiton
‘Ciical flow exists across a valve or office whan the dawn-
‘steam absolute pressixe is approximately half of te upstream
‘absolute pressure. Ary cocrease in downaveam pressure val
rot increase tha fow through the valve, Criteal flow eoncséons
fn the chats are represented by the MAXIMUM CAPACITY
Une:
GAS CAPACITY CHARTS
220, 275, & 300 Ibs. Maximum W.P. Valves
GAS CAPACITY CHART
180 70 318
ABSOLUTE PS1, PRESSURE
4 in. 6" SERIES
HOW TO USE CHARTS: Locate UPSTREAM PRESSURE
1s left of chart, Follow horizontally across io PRESSURE DROP
(Upstream minus downstoam pressure). Road VOLUME direct
ly below Ifthe horizontal projaction of the upstream pressure
oes not intersect the given pressure drop, flow i ical. In is
ttace project UPSTREAM PRESSURE horizontal Yo the MAX!
MUM CAPACITY LINE and raed VOLUME directly lowe
“roy carci may save apacien ty VE
shi Sega spete pvt os
anos
Issued 3108GAS CAPACITY CHARTS
220, 275 & 300 Ihs. Maximum W.P. Valves
or
KIMRAY
eras
(GAS CAPACITY CHART
14070515
ABSOUMTE PSI. PRESSURE
6 in "6" SERES
Gas capacties are based on pressure tavan immachately
Upstream and downstream fiom te regulator in a wide open
positon,
CCitca flow exists across a valve or erie when the doa
steam absolute pressure is approximately hal of the upstream
fbsolute pressure. Any decrease In downetroam prossure Wl
hat increase the flow tough the valve Criteal flow eandltons
fon the charts are represented by the MAXIMUM CAPACITY
UNE
A406
{saved 3/06 we
HOW TO USE CHARTS: Locate UPSTREAM PRESSURE at
lett of char. Follow horizorally across to PRESSURE DROP
(Upstream minus dovmeteam prosaure). Read VOLUME direct:
ly balow. i the norizantal projection of the upsteam pressure
‘does not intersect the given pressure drop, flow is crtcal inthis
‘cage project UPSTREAM PRESSURE horizontally to the MAX!
MUM CAPACITY LINE and read VOLUME crectly below
eeskortepyeee VE
aycomor
KIMRAY
rgd
LIQUID CAPACITY CHARTS
300 Ibs. Maximum W.P. Valves
CAPACITY-Bbls, Water/Day, Steady Flow
PRESSURE] VALVE SIZE - INCHES
Mela oe
Bue
1 745| 1,760| 3,350] 7,800
2 | 1060] 2500| 4,900] 11,000
3 | 1,300] 3,050] 6100] 13,500
4 | 1500] 3,500[ 7,000] 15,600
5 | 1,700] 3,900| 7,800] 17,500
io | 2300] 5,600] 11,000] 24,700
15 | 2,900] 6,800] 13,500] 30,200
20 | 3,300| 7,900] 15,600| 34,900
30 | 4,100| 9,600] 19,200] 42,700
40 _| 4,700] 11,100] 22,100] 49,300
50 | 5,300[ 12,400] 24,800| 55,200
60 _| 5,800] 13,600] 27,100| 60,500
70 | 6,200[ 14,700] 29,300] 65,400
80 _| 6,700] 15,700 | 31,300| 69,800
100 [7,500] 17,600] 33,500| 78,200
125 | 8,400| 19,700 | 39,200 | 87,500
150 [9,300] 21,500] 40,750 93,000
200 | 10,750| 25,000 | 47,000 | 108,000
250 | 12,100] 28,000 | 52,000 | 120,000
300 | 13,300] 30,900 | 57,250 | 130,000
Far eoviyconocon mul te sbove fees bry
‘Where “G"is the specific gravity of the flowing | ave
ano7
Issued 3108or
GAS SERIES REGULATOR idly / (RAY
DIMENSIONS
Lasliy Sico 1948
FOR: BACK PRESSURE PRESSURE DIFFERENTIAL
UPSTREAM DIFFERENTIAL PRESSURE PRESSURE REDUCING
PRESSURE REDUCING-BALANCED BACK PRESSURE VACUUM
PRESSURE REDUCING VACUUM LIQUID BACK PRESSURE
= ce
foe gh
250 S/FGT-BP-S
CAST IRON OR DUCTILE
FOR: LOW PRESSURE BACK PRESSURE
‘OUNCES BACK PRESSURE TO VACUUM
‘OUNCES PRESSURE REDUCING
OUNCES PRESSURE REDUCING VACUUM
VACUUM BACK PRESSURE TO VACUUM,
a
mE
1
2" aw Te | ae
a
250 TO
scr TOF
a we [aw
3
aw [is we | ew neve | 15
save | ame | ow
4
we wns [wow [ise | ww [ee
6 aie sew Toe Toe [ow Tew
FLANGE DIMENSIONS ARE ANSI 125/150 STANDARD. “Adi 7/8” to PRB and USDP Regulators for ths denension.
A408 +$Conguration of Back Prassure Valve isa tademark of Kira, no
{saved 8/06 ‘wersyeor