Appendix A
Control Layouts and Basic Setup Procedures
OSCILLOSCOPE
O1 02 03 040506 o7 08 O9
\ \ \ | }
024 023 022 021620019 018 O17
Meguro MO-1251 or Brunelle 2988 Oscilloscope Controls Layout
ADGNDDGIGHS) or
ciao rn 2s
Gupe che ois
‘SQUPUNGISYNE Ge
Ig on
1cUs or
HOR 7oNrAL PoSITION OS
LEVEL Ge
NooE ore
Pah sxMae, 6s
SLOPE
SOURCE oa
TMF rare
VERTICAL FOSIT GN(CH-A) O19
VERTICAL FOSITCN{CH-B} O12
VOLTSOIvECHA!
voLTson
vou:
VOLISUIV YERNERICHE} O19
operate
023
INTENSITY
ThvesN
HORIZONTAL POSITION
(eet
SLOPE
COUPLINGS ING
Si
WOLTSCv{ck-B)
VOLTSON VERNIER:CHE}
AGENDIGCH-AD
GOITSON VERN ERICH)
Clava cht
PowelBASIC SET UP
Set POWER (024) to OFF.
Plug the Cscilloscone in and turn POWER (024) ON.
Pull LEVEL (06) OUT (AUTO). Level sot
‘automatically ‘rigger on any valtage level
the trigger vatago level end AUTO means the scope will
SLOPE (07) is +. Slope selects trigger slope (+ upwards; - downwards}.
COUPLINGISYNC (08} is AC. Coupling’Syne selects trigger mode. AC for AC signals - no filtering
SOURCE (09)is INT. Source selects ‘rigger source. INT- Channel 1 or Irtemal; CH2 - Channel 2; or LINE -
8) Hz (line frequency).
Rotate maVOLTSIDIV VERNIER (022; 015) and nd TIMEJDIV VERNIER(O3)fully CWuntilthe “lick (CAL
‘oF “detent} position. This means voltage and time divisions are set to known increments or calibrated
‘Switch CH-A(CH1) AC-GND-DC (021) and CH-B(CH2) AC-GND-DC {017} to DC (DC: Directly coupled - no
Iiterirg: AG: Atematively coupled - titer DC: trom signal).
MODE (018) selecis channel(s) 0 display. CH-A(CH1) = Ghannel A CH-B(CH2) = Channel B, oF DUAL
Both Charnels, Normal selting is CH-A(CH1) or DUAL.
Adjusi FOCUS (01) andINTENSITY (02) o- aclezr, sharp display. Nakesure ines are brignt enough to be
‘early visible, Too bright ines ean damage or burn Inta the screen (.e. would always be visible),
PULL 5X MAG (05) is pushes IN (OFF).
Turn POSITION (010; 012; 08) controls to approxmate mid-pesitions. The trace(s) should appearin the
‘canto’ of tho sereon.
Adjust VERTICAL POSITION (010) to move CH-A(CHI) to the X-axis ora horizontal graticule
Hf MODE (019) is DUAL, acjust VERTICAL POSITION (012) to move CH-B(CH2) to a bettom horizontal
graticale
COMP TEST (019) is OUT OFF)
PULL INVERT (012) is pushed IN (OFF).
exrkt200 operate & Rov 2