MANIPAL UNT'
‘SCHOOL OF ELECTRICAL, ELECTRONICS
‘Department of Electronics & Cor
\V Semester, B. Tech End Semester Ex:
Jog and Digits
(Open Book Exem
Deration: 3 hour,
Taseructions [Answer any FIVE full question
aon data if any ean be suitably assumed
‘Numbers in [] indicates marks
Daly one book and one handwritten Bown
VERSITY JAIPUR
'& COMMUNICATION (SEEC)
smumunication Engineer
+) ENGINEERING
s
amination - December, 2017
fal Communication
pination) Max, Marks: 80
otcbook is allowed. Photocopy not alowed
ded me
jradiates 725kW [8]
Twin An raromiter ries SAW power whe there sno me
aaton index
power. Find the most
‘coresponding to 40% modulation is transmitted s
ge signal. For sinusoidal message signal
Jmultaneously, then calculate total
Now, if another sinusoidal signal
radiated power +
Bouse shea desien a DSBSC messy generate a modulated a modulated sina 4m(0 cos(2A0R3° e). Where 18]
yp sgl ited ode Figure Below shows PSBSC ‘modulators available 10 YOU.
m0) FILTER [->{AMPLIFIER
Cos*(2n(300x107 1)
ring coo fequencies of the fter and gain ofthe amplifier, Draw the sPESEU of the signal atthe input ofthe fier.
2 ag foros FM miter a camer of SOM: Evers and § Volt amplitde is modulate by a cosine wave of Feiss is)
fon PM Fanpitue 1Vol. The fequency deviation i | Sillz Now, ifthe amp et and frequency of the modulating
ee now changed io 3Volt and 2ktz respectively Obtain the expression of 06 modulated waveform
faa mesage signal (7) = 2¢0S1001 + 18c0s 2000215 —=° <1 50. Waite eSPrEALOD of FM and PM signal (81
considering A, = 10,02, =10°,ky = 1000z,k, =I. Also estimate the bandwidth of FM and PM signal
A gf ou Cran Sebi ertogonalizaton procedure to find a set of orthonormal basis functions corresponding to the signals (81
shown below
suo S30 2x0
‘exes s(t) sand (0) in erms of rthonarma ass functions computed in par (2) above and pls the labelled signal {8}
constellation diagram for this set of signals.
18)
4. a) Given a sample value of 420 mV for @
io
tem,
peak to peak amplitude of
soltages pertaining to the u285 compander to achieve (Vin
A sinusoidal message signal is transmitted through a PCM sys
{tat maximum quantization eror should beat most 0.6% of the
tg bit draon, bitrate, and bandwidth
5. 3y/oveanalog waveform x1) i
be seat by TDM over a PAM system. Determine the minimum sampling
commutator and decommutator to accommodate these signals.
Three message signals each bandlimited to 4 KHz are multiple
band of 04 KHz. Find signal bandwadth if modulation schemes
with neatly labelled spectrum plots.
afd oessage signa of 40s 4 10000 is given to # PCM system
onber ef qumtzatin levels are 1024 Te reskin digital
Pos bt rac and bandwidth ofthe heme
»
4
o
cos 22 10%. If the input at the coherent BPSK receiver is cos 4x’
1225 PCM encoder capable of encodit
4 of the compander. Also, determine an appropriate value of &
bandlimited to 4kHz and another x2(t) is bandlimited to 16 kHz. These two signals are to
In a coberent BPSK system, the pair of signals u
[BPSK system, the pair of signals used to represent binary 1 & 0 are related as si(t) = -Isx(t). Where si(t) = 4
ing a maximum level of 4V. Determine the
A" of an A-law compander corresponding to the
2)" (1/4),
Find the minimum possible bivsample required such
f message signal. Also, determine
18)
frequency for each signal and design 1 TDM
ced using frequency division multiplexing Assume guard {8}
used are DSB and SSB respectively. Suppor your answer
18)
for transmission with sampling rate equal to Nyquist rate
gna! is transmitied through free space using ASK, scheme.
{8},
10%. Determine which binary symbol was transmuted.