ea
SWITLIK
Name/Company/Unit:
‘Switlik Parachute Company, Inc.
1325 East State Street
Trenton, NJ 08609 Quantity a
(609) 687-3300 Customer Order Info - Use Chart Below
(609) 586-6647 FAX Suit Size:
WWW switk.com Neck Size":
(for optional Neoprene Neck Seal)
Protecting Aviators Since 1920 * Sitting Inseam
Shoe Size*:
(‘in Men's Flight Boot Size in Whole Numbers)
To Find Your Size Use the Chart Below
Sitting Inseam
ORDERSIZE| Chest Hip Range _| Sleeve | Weight
xs. Less than 33° 29 to 38" 32" _| 100-125 Ib,
Ss 33.38" 29 to 38" 33°__| 115-150 Ib.
M 38-42" 29 to 38" 34" | 140-175 Ib.
L 42-46" 30-1204" | 36" | 165-2001b. | 5 6"-6'1
XL 46-50" | 42-48"| 30-1/2t040" | 37" _| 190-225 1b. | 5. 7"-6'3
x 50-54" | 46-52" | 30-1/21040" | 38" | 215-2601. | 5 9-65"
4) Circle each measurement on the chart
2) Choose size (XS-XXL) by LARGEST of Chest or Hip size
3) If ordering a suit with an optional Neoprene Foam neck seal, see page 3 for available sizes.
4) After identifying size, complete order form above noting Size, Sitting Inseam and Flight Boot Size for a semi-
custom fit,
How to Measure:
The U-Zip-It Suit is designed to be worn with fleece undergarments (Long Johns). All
measurements should be made while wearing all clothing that will be worn under the suit.
Chest/ Bust For chest, measure just under arms and across
shoulder blades holding the tape firmly and level. For bust, measure
at the fullest point of the bust.
Hip Measure around the
fullest point of the seat
while standing,Sitting Inseam While seated, measure from the crotch to the middle of the inside of the knee (note
measurement). Then measure from middle of the inside of the knee to the floor (note measurement),
Measurement should be made without shoes. Add both measurements for complete “Sitting Inseam.
Measurement".
Sleeve Length With arm relaxed at side
and slightly bent, measure from the center
back neck, over point of shoulder, down
outside of arm to wrist,es
SWITLIK
Neck Size: The standard U-Zip-It suit comes with a latex neck seal which is cut to fit by the wearer.
Instructions are included in the Owner's Manual shipped with the U-Zip-It Suit.
An optional neoprene foam neck seal is available. Use the table below to determine your size (all
measurements in inches).
‘Size | Fits minimum neck size* | Fits maximum neck size™
1 2 13-178
2 13-14 14-318
3 14-112 15-5/8
4 15-314 16-718
5 7 18-112
* This measurement is not a shirt size!
The neck measurement must be taken at the
most narrow area of your neck, directly on
your skin.
Wrist Seals are cut to fit by wearer. Instructions are included in the Owner’s Manual shipped with the
U-Zip-tt Suit.