- 2 x Capacitor 16v 100µF, 1 x 16v 470µF, 1 x 50v 1µF
- 1 x IC TDA2003 and radiators - 1 resistor 2,2Ω , 1 x 220Ω 1/4w
- 1 x resistor 1Ω - 1/2W
- 1 x Adapter 12v 1A, Or Accu 12v, 12v DC jack or Connect kf301 2p
- 1 x Capacitor Mica 2A104J
- 1 x Diode 1N4001 1A
- 1 x ceramic capacitors 101, 1 x ceramic capacitors 473
- 2 x header connector 2p
- Copper clad board, FeCl3, Sandpaper, Speaker, Paper print, Paper A4
- Circuit Broad print 3,8 x 4,1CM
- Circuit boards PCB, Circuit principles
Make a design using Fritzing then print the circuit broad print 2 x 2 in, Circuit principles and circuit board. Cut the PCB in 2x2in then put the design. Layer-up and use steam iron to bond the design in to the PCB. After ironing the design it will transfer to the PCB. Rub the paper off the board. Saw the excess board with a metal saw. Next you need to sand the edges to smoothen the board with sanding paper, kindly use the finer so you will have a finner finish. There are different variety of etching solution but the most common is Ferric Chloride. Get a plastic container, never use any kind of metal container. Pour the etching solution on your plastic container. Leave the PCB board for about 30-45 minutes in the container. After for about 30-45 minutes remove it from the container, leaving it for a long time will etch the ink protected area so please remove it when it's done. Drill the board with a mini drill a dremel tool will do. After drilling it rinse it again with water. Be sure to drill it on the copper side, since the copper layout will be your guide where to drill. Use soldering iron to melt solder and apply it to metals that are to be joined. This is the finish product.