FACTORY ACTIVATED
POWERSPORTS BATTERY
OWNER’S MANUAL
*
GETTING STARTED
INSTALLATION
CHARGING
SAFETY
GETTING STARTED
Thank you for choosing this premium quality
factory activated AGM powersports battery
Included along with the battery is a
instalation harcivare kt with several varieties
of nats and botts that may be required for
proper Installation n your vehicle.
FACTORY ACTIVATED ADVANTAGE,
Your now factory activated powersports
battery is filed, charged and ready 10
bo install
AGM TECHNOLOGY
‘This AGM powersports battery is
rhonspillaol, maintenance fee and
resistant to damage trom vibration.
MAINTENANCE FREE
“There is no need to ever add water
‘The baltery should remain sealed
Nover pry off the battery sealing plugs.
ening the sealing plug sir voids
e warranty.
Keep battery charged by running the vehicle
fr by using an autornatio charger/maintainer.
Keep terminal connections clean and dry.
“shmop hy tatty era
INSTALLATION
(1) Betore you remove your old battery
mark which cable is connected to the
POSITIVE [4 terminal and which is
‘connected to the NEGATIVE [terminal
(2) Remove old battery.
(@) Clean the cable terminals with a wire
brush to remove any corrosive oxidation.
(4) Place naw battery on tray,
(6) Connect POSITIVE (+) cable fst
then connect NEGATIVE () cable.
‘CONNECT TERMINALS.
Poste red cable rom
Ignition to Positive Post
"Nogative black cable tom
Engine or Chassis to Negative Post
OFF SEASON CARE AND STORAGE
Belore storing your vehicle check the battery
voltage. If the voltage is below 12.5V charge
your battery and follow a maintenance
‘schedule that includes charging a minimum
fof once every 3 months, Keep fully charged
battery stored in dry, cool area away from
ran, sunlight, fumace or heat source.
DO NOT EXCEED
CHARGING GUIDELINES!
(CHARGE VOLTAGE SHOULD NOT EXCEED
15.0 VOLTS. Overcharging can effect
battery life end voio warranty,
Do not leave battery unattended unless you
have an automatic charger/maintainer.
Ifusing a trickle charger that is not automatic,
careful monitoring is required
using an automatic battery charger and it
shuts off before time listed on the chart, do
ot charge te battery any longer.
‘Ate charging let battery stand for atleast
minimum stand time (30 or 60 minutes
depending on battery - see charging chart,
then check voltage reading,
‘A12 volt battery should read at least 12.70V,
Charging your battery at arate over 2 amps
‘on any Datery charger will shorten the Ife of
your battery
Tea
TSI
Tea a
‘CAUTION
Batteries wil ose power in storage, and
may need to be recharged every $ months.
“The charge vot
during usage, otherwise t would cause
19 water and infiuonce the charactor.
The battery shouldbe full charged after
a discharge. should not be kept uncer
the discharging stato
‘The battery connector contact points
should be kept clean to avoid short circuit
“The battery should be kept away from fre
‘Never lean over battery when testing
or charging
Exercise caution when working with metal
tools or conductors to prevent short circuits
and sparks,
PROPOSITION 65 WARNING.
eo, O|
INSTRUCTIONS.
pp
OAs Leh
Es
| on
DONOT PLLED: SPREAD BAKING SODA,
OPEN (OVER SPILL, THEN OLUTE WITH
BATTERY! LARGE AMGUNTS OF WATER,
SSS on NUL |
* DANGER/POISON dh
1. susunc
WE owse
Shanks
+ FLAMES
SMOKING |
IF SWALLOWED: DRINK AS MUCH
WATER OR WILK AS POSSE
GET MEDICAL HELP FAST.
CAUTION: FOR Si
INSTRUCTIONS IN VEHICLE’S OW”
OR IF NOT AVAILABLE. SEEK SERVICE ASSISTANCE.
Pout | eG) FLusit EES
OF THE IMMEDIATELY
REACH OF 1TH WATER
CHILDAEN. | GET MEDICAL
P FAST.
JUMP STARTING, FOLLOW
‘S MANUAL