Professional Documents
Culture Documents
#'s)
27
terms
Maximum allowed corrosion rate when using on-‐stream in lieu of internal (in ipy)
0.005 ipy
Ratio of endurance limit stress to ultimate tensile stress for carbon steel
0.4 - 0.5
Static head factor (psig per height of water in feet)
0.433 psig/ft
Design -‐ joint efficiency when using full RT on a type 1 joint
1.0
FFS
-‐
joint
efficiency
when
evaluating
corroded
area
away
from
a
weld
by
greater
of:
1"
or
2T
1.0
NDE -‐ the # of additional RTs required when a spot RT has a defect
NDE -‐ the # of additional RTs required when a spot RT has a defect
Weld
qualification
-‐
number
of
Bend
tests
to
qualify
a
welder
or
welding
operator
and
welding
positions
in
1G-‐4G
NDE
-‐
minimum
#
of
exposures
to
RT
360°
of
a
weld
using
a
double-‐wall
technique,
double-‐wall
view
(elliptical
shot)
2
NDE
-‐
RT
film
density
range
-‐
allowed
for
the
weld
&
IQI
when
using
a
gamma
ray
source
2.0 - 4.0
NDE-‐
minimum
#
of
exposures
to
RT
360°
of
a
weld
using
a
double-‐wall
technique,
single-‐wall
view
Impact test -‐ number of test bars required in each set of impact test specimens
NDE
-‐
when
using
a
shim
under
a
hole-‐type
IQI,
the
number
of
sides
of
the
IQI
that
must
be
seen
in
the
RT
image
3.5
4.0
Weld qualification -‐ number of bend tests to qualify a WPS
Weld
qualification
-‐
number
of
bend
tests
to
qualify
a
welder
or
welding
operator
in
welding
positions
5G
&
6G
5 ohms
NDE -‐ weight used to check magnetic strength of an AC yoke
10 lb
25 ohms
NDE
-‐
minimum
angle
of
eye-‐to-‐part
to
count
as
a
visual
exam
30 degrees
NDE
-‐
weight
used
to
check
magnetic
strength
of
a
DC
yoke
or
permanent
magnetic
yoke
40 lb
Testing
-‐
maximum
chloride
content
in
hydrotest
water
when
testing
300
series
SS
(ppm)
50 ppm
NDE -‐ minimum light intensity when performing non-‐fluorescent MT or PT exams
100 foot-candles
100 foot-candles
NDE -‐ minimum black light intensity when performing MT or PT fluorescent exams
1000 mW/cm2
Weld qualification -‐ number of tension tests to qualify a WPS