QRPme SMT RF Probe Assembled PCB
Tin pin and ——Exiraholes for Connect meter wire
Assembly 2x pads first and optional wiring to these 3 holes
Note: May be postion at end
Header Pin or P B "
{eader Pino 41 Meg 1% f 91 cap end
Mogi
CUD Inch a pO Bc, ONCHL ater I
=a tn TB} place,
Diode Bano
Shif.01 foward Pdaiion ode between
end of pad and
pads so that leads touch
Alligator Clip ‘nen solder Both pads then solder
Kit Parts pcb, diode (black carrer, cap (plain), 412K (purple) 4.12M (red) & header pn (remove the plastic)
Note: Scaling resistor canbe Scaling Resister: For 10 Meg metor = 4.14
mace more precise iheltar Meg. For 11 Meg meter = 4.55 Meg
accuracy is desired. Example
23.9%meg and 220k can be «Measure actual meter Z using voltage
selected to provide4.1+ Meg __ divider metnod: scale accordingly
‘and bricged across the pads,
Ine gcatirg res9:0" equal te the meter z x
ALQRP power levels, shielding is nol B 1 .* Get 8 fora | Meg moter RA 14a (The
requiremont. If holding the probe by the Ss Harbor Freight meters are 1 Meg.)
leads is net acceptable, aplastic bing nF youmeasure your meter Suggestec Application
‘enelocute oF cloar chr siooving will ‘Sibe Semetring omer than te
4 the job quite nicely megahms, you zan adjust the
scaling resisiors as needed to
sheer ier sberhel
‘measurement accuracy
‘Some sizes of ballpoint pens
‘make nioo oneleaures. The
PCB cen be termed close to
‘the pads 6 couple of mm iF
nocdled. Tho strain roof ane!
can be trimmed off at the 3
‘optional holes for meter leads