Professional Documents
Culture Documents
XT100
XT100
REGULATION
Set point Set
Set point1 Set1
Set point2 Set2
Differential 1 Hy1
Differential 2 Hy2
Regulation Type (ON/OFF, PDI) Ft
Dead band db
Minimum set point1 LS1
Minimum set point2 LS2
Maximum set point1 US1
Maximum set point2 US2
Output configuration ouc
Action type output 1 S1C
Action type output 2 S2C
Anti-short cycle delay Ac
Minimum time a stage stays switched ON on
Minimum time between 2 following switching ON of the same load ono
ALARMS AND SAFETY
Alarm configuration ALC
Minumum alarm (ALC=rE) (ALC=Ab) ALL
Maximum alarm (ALC=rE) (ALC=Ab) ALU
Alarm recovery differential ALH
Alarm delay ALd
Alarm delay at start up dAO
Alarm relay disabling tbA
Alarm relay polarity AS
Out1 status with faulty pr. So1
Out2 status with faulty pr. So2
P.I.D. ACTION
Proportional Band Pb
Integral time int
Derivative Time dEt
Derivative sampling rate Sr
Proportional band reset rS
Integral band limit Ar
Cycle time cyt
Soft start restart band drb
Increment of dynamic Set point dSi
Interval of dynamic Set point increment dSt
OTHER
Start scale with current or voltage input LCI
End scale with current or voltage input UCI
Probe calibration Opb
Resolution rES
Measurement unit (temp.) (current/voltage) UdM
Kind of probe PbC
3rd wire presence P3F
Energy saving differential HES
Digital input configuration i1F
Digital input polarity i1P
Alarm delay for dig. input did
Serial address Adr
oFF function enabling OnF
Parameter table Ptb
Software release rEL
To access the Pr2 Pr2
present present and factory pre-set