Professional Documents
Culture Documents
STAND-ALONE CONVERTER
USER'S MANUAL
NANKAI District
TIANJIN, CHINA
Tel:+86-22-87881024 87894033
Fax:+86-22-8789-0344
Web address:www.looptech.cn
2008 TIANJIN LOOP ELECTRON TECH. CO. All rights reserved.
Version 3.0 23 Mar 2008.
Loop-E is a trade mark of Loop Telecommunication International, Inc.
Table of Contents
List of Figures
FIGURE 3- 1 FRONT PANEL OF E1/V35 CONVERTER .......................................................................................... 4
FIGURE 3- 2 220V BACK PANEL OF E1/V35 CONVERTER .................................................................................. 4
FIGURE 3- 3 48V BACK PANEL OF E1/V35 CONVERTER .................................................................................... 4
FIGURE 3- 4 FRONT PANEL OF E1 OPTICAL CONNECTOR ................................................................................... 5
FIGURE 3- 5 220V BACK PANEL OF E1 OPTICAL CONNECTOR ............................................................................ 6
FIGURE 3- 6 48V BACK PANEL OF E1 OPTICAL CONNECTOR .............................................................................. 6
FIGURE 3- 7 FRONT PANEL OF V35 OPTICAL CONNECTOR ................................................................................. 7
FIGURE 3- 8 220V BACK PANEL OF V35 OPTICAL CONNECTOR .......................................................................... 7
FIGURE 3- 9 48V BACK PANEL OF V35 OPTICAL CONNECTOR ............................................................................ 8
i
List of Tables
TABLE 2- 1 V.35/M34 DTE PORT PIN DEFINITION ............................................................................................. 2
TABLE 2- 2 LED TABLE ................................................................................................................................... 3
ii
D Bitte führen Sie das Gerät am Ende seinerLewbensdauer den zue Verfügung
stehended Rückgabeund Sammelsystemen zu.
GB At the end of the product’s useful life, please dispose of it at appropriate collection
points provided in your country
F Une fois le produit en fin devie, veuillez le pparen dans un point de recyclage
approprié.
ES Para pparent el medio ambiente, al final dela vida útil de su producto, depositelo
en los laguares destinado aello de acuerdo con la legislación vigente.
I Onde tutelare l’ambiente, non buttate l’apparecchio trai i normali rifiuti al termine della
sua vita utile, ma portatelo presso i punti do taccolta specifici per questi rifiuti previsti
dalla pparent vigente.
NL Wij raden u aan het pparent aan het einde van zijn nuttige levensduur, niet bij hey
gewone huisafval te deponeren, maar op de dearvoor bestemde adressen.
N Ved slutten av produktets levetid bør det avhendes på en kommunal miljøstasjon eller
leveres til en elektroforhandler.
PL Gdy produkt nie nadaje sie juz do dalszego uzytku, nalezy zostawic go w jednym ze
specjalnych punktów zajmujacych sie zbiórka zuzytych producktów w wybranych
miejscach na terenie kraju.
SLO Ko se izdelku izteče življenska doba, ga odnesite na ustrezno zbirno mesto oziroma
ga odvrzite v skladu z veljavnimi predpisi.
PRC 當產品使用壽命結束,請在你的國家所提供的適當地點做好回收處理
iii
Chapter 1 Product Description
1 PRODUCT DESCRIPTION
The Loop-E1590 converter provides an economic solution to E1 network access costs. It supports
conversion from fiber to E1, and fiber to V.35. All E1 interfaces support two modes---frame or unframed.
The Loop-E 1590-OE can connect with Loop-E 1590-OV to allow direct E1 transport to the remote V.35 via
fiber. It supports either single fiber or dual fiber transmission.
Parameters and loopbacks are accessible via DIP switches on the rear panel of the unit.
1
Chapter 2 Specifications
2 SPECIFICATIONS
2
Chapter 2 Specifications
2.4 Physical/Electrical
Dimensions 20x14x4.2cm
Power AC: 100-240V DC: -48V
Temperature 0-50℃
Humidity 0-95% RH (NON-CONDENSING)
3
Chapter 3 Operation
3 OPERATION
3.1.1 Specification
LOOP-E 1590-EV can provide interface changing from E1 port to V.35 port.
4
Chapter 3 Operation
on on V35 Clock
OFF(N/A) ON
TS_MASK Use Local Clock Line Clock
V35_RC_INV Receive Clock Invert
V35_TC_INV Transmit Clock Invert
ITEMS OFF ON
DIP 1 LOCAL LB No Loopback E1 Port
3.2.1 Specification
5
Chapter 3 Operation
OFF(N/A) ON
TS_MASK Use Local Clock Line Clock
6
Chapter 3 Operation
3.3.1 Specifications
7
Chapter 3 Operation
on off Unavailable
on on V.35 Clock
OFF(N/A) ON
TS_MASK Use Local Clock Line Clock
V35_RC_INV Receive Clock Invert
V35_TC_INV Transmit Clock Invert
ITEMS OFF ON
LOCAL LB No Loopback Optical Port
DIP 2 DIAG LB No Loopback V.35 Optical Port
DIP 3 REMOTE LB No Loopback Remote Optical Port
DIP 4 PATT Transmit Testing Code
8
Chapter 3 Operation
To enable the unframing mode, turns TS0---TS31 to “on”, it is default setting. Turns TS0 to “off” and it will
work as Frame mode. The timeslot is “on” when TS1 to TS31 is enabled, the timeslot is “off” when TS1 and
TS31 is not in use.