Professional Documents
Culture Documents
Ordering Information
AP 1118 X XX X X
Typical Circuit
5V
C1
100uF
Vin
EN
Vout 3.3V/1A
Tab is Vout
NC
C2
GND 100uF
This datasheet contains new product information. Anachip Corp. reserves the rights to modify the product specification without notice. No liability is assumed as a result of the use of
this product. No rights under any patent accompany the sale of the product.
Rev. 1.1 Feb. 15, 2005
1/10
Connection Diagram
5 PIN TO220 5 PIN TO252/TO263
( Top View )
5 Vin
5 Vin
4 EN
4 EN
3 Vout 3 Vout
2 NC 2 NC
1 GND
1 GND
SOP-8L
( Top View )
Vout 5 4 Vin
Vout 6 3 EN
Vout 7 2 Vout
Vout 8 1 GND
Pin Descriptions
NAME FUNCTION
GND Ground.
The output of the regulator. A minimum of 10uF capacitor must be connected from this pin
Vout
to ground to insure stability.
The input pin of regulator. Typically a large storage capacitor is connected from this pin to
ground to insure that the input voltage does not sag below the minimum dropout voltage
Vin
during the load transient response. This pin must always be 1.3V higher than Vout in order
for the device to regulate properly.
The input pin of regulator. TTL/CMOS compatible input Logic high = disable output, Logic
EN
Low or open = output enable. (internal pull-down resistor~100 K).
NC No connection.
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
2/10
AP1118
1A Positive Low Dropout Fixed-Mode Regulator With EN Function
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
3/10
AP1118
1A Positive Low Dropout Fixed-Mode Regulator With EN Function
SOP-8L 25
θ JC Thermal Resistance TO-252-5L 15 O
: Control Circuitry/Power Transistor C/W
Junction-to-Case TO-220-5L 0.65/2.7
TO263-5L 3.5
Note1: See thermal regulation specifications for changes in output voltage due to heating effects. Line and load regulation are
measured at a constant junction temperature by low duty cycle pulse testing. Load regulation is measured at the output lead =
1/18” from the package.
Note2: Line and load regulation are guaranteed up to the maximum power dissipation of 15W. Power dissipation is determined by the
input/output differential and the output current. Guaranteed maximum power dissipation will not be available over the full
input/output range.
Note3: Quiescent current is defined as the minimum output current required to maintain regulation. At 12V input/output differential the
device is guaranteed to regulate if the output current is greater than 10mA.
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
4/10
AP1118
1A Positive Low Dropout Fixed-Mode Regulator With EN Function
1. 8
1. 2 Tj = 25 oC -0.20
1. 0
0. 8 -0.40
Tj = 125 oC
0. 6
0. 4 -0.80
0. 2
0 -1 25 50 75 100 125
0 250 500 750 1000 -25 0
Output Current (mA) Temperature ( oC)
Dropout Voltage vs Output Current Load Regulation vs Temperature
2 1
1.5
0.8
1
Output Voltage Change (%)
0. 5
0.6
0
-0.5 0.4
-1
0.2
-1.5
-2 0
-50 -25 0 25 50 75 100 125 150 2 4 6 8 10 12
Temperature ( oC) Input Voltage (V)
Percent Change in Output Voltage vs Temperature Line Regulation
7.5 30
Output Voltage Deviation (mV) Input Voltage (V)
Cin=1uF C in = 1uF
Cout=10uF Tantalum 20 C out = 10 uF Tantalum
6.5 Preload = 100mA
10
5.5
0
40
-10
20 -20
2
0
1
-20
0
-40
0 20 40 60 80 100 120 140 160 180 200 -1
0 10 20 30 40 50 60 70 80 90 100
TIME (us) TIME (us)
Line Transient Response Load Transient Response
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
5/10
AP1118
1A Positive Low Dropout Fixed-Mode Regulator With EN Function
Marking Information
(1) TO220-5L
( Top view )
1118-XX: Voltage
1118-15: 1.5V
1118-18: 1.8V Logo
1118-25: 2.5V Blank: normal
1118-33: 3.3V 1118-XX
L: Lead Free Package
1118-50: 5.0V XX XX X X
ID code
1118-90: 9.0V Xth week: 01~52
1118-12: 12V Year: "01" = 2001
"02" = 2002
~
(2) TO252/TO263-5L
(Top view)
1118-XX: Voltage
Logo
1118-15: 1.5V
1118-18: 1.8V 1118- XX Blank: normal
L: Lead Free Package
1118-25: 2.5V XXXX XX
1118-33: 3.3V ID Code
Xth Week: 01~52
1118-50: 5.0V Year: "01" = 2001
1118-90: 9.0V "02" = 2002
1118-12: 12V
~
(3) SOP-8L
(Top view)
Logo
1118-XX: Voltage
1118-15: 1.5V
1118-18: 1.8V 1118 -XX Blank: normal
XX XX X X L: Lead Free Package
1118-25: 2.5V
1118-33: 3.3V ID Code
1118-50: 5.0V Xth week: 01~52
1118-50: 9.0V Year: "1" = 2001
"2" = 2002
1118-12: 12V
~
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
6/10
AP1118
1A Positive Low Dropout Fixed-Mode Regulator With EN Function
Package Dimension
(1) TO220-5
E
A
ΦP F
Q
H1
D
L
b C
e J1
e1
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
7/10
AP1118
1A Positive Low Dropout Fixed-Mode Regulator With EN Function
(2) TO252-5
A 5.6
B
5.6
C
11.0
M
7.2
2.0
D
0.6
1.27
P(TYP.) G Land Pattern Recommendation (Unit: mm)
S
K
H
J
L
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
8/10
AP1118
1A Positive Low Dropout Fixed-Mode Regulator With EN Function
(3) TO263-5
E
10.9
L2
9.1
15.7
D
L
2.5
1.0
1.7
e B Land Pattern Recommendation (Unit: mm)
A
C
C2
L1
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
9/10
AP1118
1A Positive Low Dropout Fixed-Mode Regulator With EN Function
(4) SOP-8
H
E
L
VIEW "A"
D
0.015x45
7 (4X) 7 (4X)
A2
e B
A1
VIEW "A"
y
Anachip Corp.
www.anachip.com.tw Rev.1.1 Feb. 15, 2005
10/10