Professional Documents
Culture Documents
BOCK - JOHO - ... - Trends in Ins Syst. For Gen HV-Windings - ARTICLE PDF
BOCK - JOHO - ... - Trends in Ins Syst. For Gen HV-Windings - ARTICLE PDF
by
(Switzerland)
1. INTRODUCTION
Today's established high voltage insulation systems
basically consist of either mica-glass fabric tapes with
resin impregnation by vacuum pressure impregnation
(VPI), or pre-impregnated resin-rich mica-glass fabric
tapes (RR). Both systems use epoxy resins, cured at
elevated temperatures. A conductive anti-corona coating
is applied to the outer insulated surface in the slot
region, and a field-dependent corona protection in the
end-windings.
In both insulation systems the electrical partial
discharge activity inside the insulation is kept at a low
level, which in combination with the inherently partial
discharge-resistant mica, results in an excellent high-
voltage performance.
The design field strength for both systems is at
approximately 2.5kV/mm (referred to the flat sides of
Fig. 1: Stator slot with indirectly-cooled bars, copper
the main insulation) using standard design, and extends
heat removal through insulation
________________________________________________________________________________________________
* Alstom (Schweiz) AG, Dept. SGDH, CH-5242 Birr, E-Mail: albrecht.bock@power.alstom.com
2. PRINCIPLE WAYS FOR IMPROVEMENT