Professional Documents
Culture Documents
Ko Ltetimervaluesanddescriptions 180417154902 PDF
Ko Ltetimervaluesanddescriptions 180417154902 PDF
>>Stops at the Receipt of RRC connection setup or reject message OR at the cell
reselection time OR upon abortion of connection establishment by Higher layers (L2/L3).
Enum {ms100, ms200, ms300, ms400, ms600, ms1000, ms1500, ms2000} This parameter is
settable by the operator
Interval between subsequent transmission
RRC Connection Reestablishment Request
Enum {ms100, ms200, ms300, ms400, ms600, ms1000, ms1500, ms2000} This parameter is
settable by the operator
Time to wait for cell reselection or
RRC Connection Setup after RRC Connection Reject
Enum {ms100, ms200, ms300, ms400, ms600, ms1000, ms1500, ms2000} This parameter is
settable by the operator
>>Starts when access is barred while performing RRC CONNECTION ESTABLISHMENT for
MO(Mobile Originating) calls
.
HO failure timer. Maps to t304 defined within IE Mobility Control Info in 36.331 and has
the set of values as defined in IE Mobility Control Info
>>Starts at the Receipt of RRC CONNECTION RECONFIGURATION message along with Mobility
Control Info OR at the receipt of mobility from EUTRA command message including CELL
CHANGE ORDER
>>Stops at the successful completion of HANDOVER to EUTRA or CELL CHANGE ORDER is met
1. In the case of CELL CHANGE ORDER from E-UTRA OR intra E-UTRA handover, initiate the
RRC connection re-establishment procedure.
Ericsson Internal | 2015-05-11 | Page 6
.
2. In case of HANDOVER to E-UTRA, perform the actions defined as per the specifications
applicable for the source RAT.
ENUMERATED {ms50, ms100, ms150, ms200, ms500, ms1000, ms2000, spare1}, This parameter is
settable by the operator.
HO failure timer. Maps to t304 defined within IE CellChangeOrder in 36.331 and has the
set of values as defined in IE CellChangeOrder
ENUMERATED {ms50, ms100, ms150, ms200, ms500, ms1000, ms2000, spare1}, This parameter is
settable by the operator.
>>Starts when UE detects PHY layer related problems (when it receives N310
consecutive out-of-sync INDs from lower layers)
>>Stops 1. When UE receives N311 consecutive in-sync INDs from lower layers/
>> At expiry, if security is not activated it goes to RRC IDLE else it initiates the CONNECTION
RE-ESTABLISHMENT Procedure
Ericsson Internal | 2015-05-11 | Page 8
Enum ms0, ms50, ms100, ms200, ms500, ms1000, ms2000} This parameter is settable by the
operator.
RLF recovery timer.
Enum {ms1000, ms3000, ms5000, ms10000, ms15000, ms20000, ms30000} This parameter is
settable by the operator