Professional Documents
Culture Documents
Structural Engineering
Design
Civil Engineering
Easily target and deliver messages to the right people with our pre-built and custom
segments.
Start Now
1 Answer
As Bob Bennett says, there is no single point. Where might it fail? Why? How can this
be prevented?
It might be a simple beam, supported at each end. How would the beam fail? Will it
be bending or shear? Will its supports fail?
Suppose it is more complex, that the beam is on a bend, is subject to shear, bending
in the vertical and horizontal planes, and subject to torsion? What then?
Suppose the beam is only restrained on its base at the supports and is free to twist?
Under what conditions might the critical point be at a support, at midspan, or at
some other point?
Continue Reading
Related Questions
How do I calculate point of contraflexure and point of zero shear in an overhanging
and simply supported beam respectively?
Where does the point of contraflexure occur in a loaded beam?
How rcc design is calculated for beams and columns (structures)?
How can I design the transfer beam?
How can I design a grade beam?
How can I calculate the breaking point of a beam?
What are the changes of structural design in secondary beams if the span of main
beam is reduced?
What should be the design of a beam for a span of 12m?
How can I design the transfer beams?
Why we design deep beams only for bending moment?
How I design shelving beam?
What is the difference between the point of inflection and the point of contraflexure
in beams?
What are the basics of beam design?
How do I design an overhanging beam?
How do we design cantilever beam?
Related Questions
How can I design a grade beam?
How can I calculate the breaking point of a beam?