Professional Documents
Culture Documents
V3.1
LALALOOPSY DOLL
AMIGURUMI PATTERN
By epickawaii.etsy.com
epickawaii.etsy.com
Page 1 of 8
Lalaloopsy Doll Amigurumi Pattern
V3.1
This pattern makes a doll about 12 inches (30 cm) tall. It has the
same dimensions as a real Lalaloopsy doll.
• This pattern is for personal use only. The pattern and the doll
created from this pattern may not be used for retail or
commercial purposes.
epickawaii.etsy.com
Page 2 of 8
Lalaloopsy Doll Amigurumi Pattern
V3.1
epickawaii.etsy.com
Page 3 of 8
Lalaloopsy Doll Amigurumi Pattern
V3.1
epickawaii.etsy.com
Page 4 of 8
Lalaloopsy Doll Amigurumi Pattern
V3.1
epickawaii.etsy.com
Page 5 of 8
Lalaloopsy Doll Amigurumi Pattern
V3.1
HAIR
Cut 11 inch/28 cm strands of the super bulky yarn.
Starting at the top of her head, sew strands of yarn to her head
down the middle towards the nape of her neck. These strands
will be pulled into piggy tails on both sides of her head.
Starting at the top of her head, glue strands of yarn across her
head down towards her forehead (about round 38). Trim the
ends of the yarn so that the ends will be hidden under the hair
that will form the piggy tails.
Tie the piggy tails to the head with some hot pink thread and
some ribbon. Trim the piggy tails to desired length.
epickawaii.etsy.com
Page 6 of 8
Lalaloopsy Doll Amigurumi Pattern
V3.1
FACE
Cut a pair of eyelashes from the black felt. Glue the eyelashes to
the large black buttons. Sew the holes of the buttons in a cross
stitch pattern. Glue the eyes to the head (center of eyes at about
round 34 and about 7 stitches apart).
For her cheeks, cut two circles from the pink felt and glue to the
head. (I used the black buttons as a template for the cheeks.)
Sew a mouth using black thread (about 5 stitches wide and 2
rounds high – about rounds 28 and 29) and pull the ends of the
thread inside the head.
epickawaii.etsy.com
Page 7 of 8
Lalaloopsy Doll Amigurumi Pattern
V3.1
THE END
epickawaii.etsy.com
Page 8 of 8