Professional Documents
Culture Documents
Control system. In Display Results for Clearing Analysis & Upgrade Change Impact Analysis, for Remote
Comparison, the same RFC name SHOULD BE specified (as specified in the Control System) from
Analysis to Statistics System. Consider the below picture as an example.
In the picture above it is assumed that the target system and the statistic system are the same which is
the normal use case of the CTS analysis. If the target system is NOT the Prod System, then both RFC
destinations point to different systems!
Note:
1. Assign to all mentioned dialog users basis authorizations (e.g. at least for transactions ST05, ST12,
SE30, SM37, SE38, SE80, ST03N, SCI, SM50, SM51, SM66, SP01, execution of “Z_CLONEFINDER” in
background) in remote systems. This will allow the user to performing a deep analysis of customer code.
2. In Clearing Analysis (CA), to carry out a where-used-list or check the report/table definition for an
object, User MUST be of Dialog while accessing the Statistics System