3. What is the command to view the active vg? 4. How do u add a new disk in VG? 5. What are the Attributes of LVM? 6. Describe about LVM Adva/Dis.Adv? 7. How do u find the fix is installed? 8. How to u extend the FS? 9. Attributes of FS? 10. List the entire LV in system? 11. How do u find the PP size of the VG? 12. How do u create the pp size of 32 MB in VG? 13. What is the Limitation of VG? 14. How do u disable the paging space? 15. What is LPAR? 16. Why is the . not included in the path? 17. How will you mirror a volume and how will you find if a volume is mirrored ? lsvg –l (vol gp name) 18. A system is echoing the ping but not able to login via telnet why ? Etc /services etc/inetd.conf 19. what is the migration path from 4.3 to 5.1 ? (or any versions) 20. A system is able to ping within the network but not outside why ? 21. What are the components of a HACMP ? (did you use serial interface) 22. What are the resource groups in HACMP? 23. What are the apar install if so for what ? 24. How will you log in or start the system in what mode if you don’t know the root password? 25. What is ip address and subnet means ? 26. what types of san or nas devices were used ? 27. Were the storage on the hard drive or any tape used ? 28. how will you check the if a system is paging excessively ? 29. There is too much of processor utilization what could be possible reason? 30. How is paging space is allocated? 31. How will you configure sendmail ? 32. How will you assign superuser privilege to an ordinary user temporarily (sudo) 33. Based on what one will choose to use shell or perl scripting ? 34. Difference between telnet or ssh . 35. How will you truncate a log file ? 36. What is a sticky bit what is the effect on file and directory ?