Professional Documents
Culture Documents
GHS Classification
Short-term (acute) aquatic : Category 2
hazard
Precautionary statements :
Prevention:
P273 Avoid release to the environment.
Response:
P312 Call a POISON CENTER/doctor if you feel unwell.
Disposal:
P501 Dispose of contents/ container to an approved waste
disposal plant.
Components
Chemical name CAS-No. Concentration (% w/w)
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16- 1591782-99-8 >= 50 -< 70
1 / 15
SAFETY DATA SHEET
In case of skin contact : In case of contact, immediately flush skin with soap and plenty
of water.
In case of eye contact : In the case of contact with eyes, rinse immediately with plenty
of water and seek medical advice.
Specific hazards during : In case of fires, hazardous combustion gases are formed:
firefighting Carbon monoxide (CO)
Carbon dioxide (CO2)
Nitrogen oxides (NOx)
2 / 15
SAFETY DATA SHEET
Environmental precautions : The product should not be allowed to enter drains, water
courses or the soil.
Methods and materials for : Soak up with inert absorbent material (e.g. sand, silica gel,
containment and cleaning up acid binder, universal binder, sawdust).
Treat recovered material as described in the section "Disposal
considerations".
Advice on protection against : Observe the general rules of industrial fire protection
fire and explosion
Advice on safe handling : When used and handled appropriately no special measures
are needed
Hand protection
Break through time : 480 min
Glove thickness : 0,7 mm
Remarks : Long-term exposure Impervious butyl rubber gloves
3 / 15
SAFETY DATA SHEET
Eye protection : Depending on the risk, wear sufficient eye protection (safety
glasses with side protection or goggles, and if necessary,
face shield.)
Hygiene measures : Wash hands before breaks and at the end of workday.
Use protective skin cream before handling the product.
Take off immediately all contaminated clothing and wash it
before reuse.
Appearance : Liquid
Colour : amber
Odour : characteristic
pH : approx. 8
4 / 15
SAFETY DATA SHEET
Solubility(ies)
Water solubility : soluble
Viscosity
Viscosity, dynamic : ca. 800 mPa.s ( 25 °C)
5 / 15
SAFETY DATA SHEET
Acute toxicity
Product:
Acute oral toxicity : Acute toxicity estimate: > 5.000 mg/kg
Method: Calculation method
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Acute oral toxicity : LD50 (Rat, female): 5.000 mg/kg
Method: OECD Test Guideline 423
GLP: yes
Acute dermal toxicity : LD50 (Rat, male and female): > 2.000 mg/kg
Method: OECD Test Guideline 402
GLP: yes
Skin corrosion/irritation
Product:
Remarks : no data available
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Species : reconstructed human epidermis (RhE)
Exposure time : 15 min
Method : OECD Test Guideline 439
Result : No skin irritation
GLP : yes
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Species : Bovine cornea
Result : slight irritation
Exposure time : 4h
Assessment : No eye irritation
Method : OECD Test Guideline 437
6 / 15
SAFETY DATA SHEET
GLP : yes
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Test Type : Maximisation Test
Exposure routes : Dermal
Species : Guinea pig
Method : OECD Test Guideline 406
Result : Not a skin sensitizer.
GLP : yes
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Genotoxicity in vitro : Test Type: Ames test
Test system: Salmonella typhimurium
Metabolic activation: with and without metabolic activation
Method: OECD Test Guideline 471
Result: negative
GLP: yes
7 / 15
SAFETY DATA SHEET
Germ cell mutagenicity - : In vitro tests did not show mutagenic effects, In vivo tests did
Assessment not show mutagenic effects
Carcinogenicity
Product:
Carcinogenicity - : No information available.
Assessment
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Carcinogenicity - : No information available.
Assessment
Reproductive toxicity
Product:
Reproductive toxicity - : No information available.
Assessment No information available.
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Effects on fertility : Species: Rat, male and female
Strain: wistar
Application Route: oral (gavage)
General Toxicity - Parent: NOAEL: >= 650 mg/kg body weight
General Toxicity F1: NOAEL: >= 650 mg/kg body weight
Method: OECD Test Guideline 421
GLP: yes
8 / 15
SAFETY DATA SHEET
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Assessment : The substance or mixture is not classified as specific target
organ toxicant, single exposure.
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Assessment : The substance or mixture is not classified as specific target
organ toxicant, repeated exposure.
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Species : Rat, male and female
NOAEL : >= 650 mg/kg bw/day
Application Route : oral (gavage)
Exposure time : 28 d
Number of exposures : daily
Dose : 0, 125, 300 and 650 mg/kg bw
Group : yes
Method : OECD Test Guideline 407
GLP : yes
Remarks : By analogy with a product of similar composition
Aspiration toxicity
Product:
no data available
9 / 15
SAFETY DATA SHEET
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
no data available
Further information
Product:
Remarks : The product has not been tested. The information is derived
from the properties of the individual components.
Ecotoxicity
Product:
Toxicity to fish : LC50: 10 - 100 mg/l
Remarks: The data refer to the solvent
Toxicity to algae/aquatic :
plants Remarks: no data available
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Toxicity to fish : LC50 (Danio rerio (zebra fish)): 2,51 mg/l
End point: mortality
Exposure time: 96 h
Test Type: semi-static test
Method: OECD Test Guideline 203
GLP: yes
Toxicity to daphnia and other : EC50 (Daphnia magna (Water flea)): 1,04 mg/l
aquatic invertebrates Exposure time: 48 h
Test Type: Immobilization
Method: OECD Test Guideline 202
10 / 15
SAFETY DATA SHEET
Toxicity to fish (Chronic : NOEC (Danio rerio (zebra fish)): 0,36 mg/l
toxicity) Exposure time: 9 d
Test Type: semi-static test
Method: OECD Test Guideline 212
GLP: yes
Toxicity to daphnia and other : NOEC (Daphnia magna (Water flea)): 0,25 mg/l
aquatic invertebrates End point: Reproduction rate
(Chronic toxicity) Exposure time: 21 d
Test Type: semi-static test
Method: OECD Test Guideline 211
GLP: yes
11 / 15
SAFETY DATA SHEET
Ecotoxicology Assessment
Chronic aquatic toxicity : Harmful to aquatic life with long lasting effects.
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Biodegradability : aerobic
Inoculum: activated sludge
Concentration: 17 mg/l
Carbon dioxide (CO2)
Result: Readily biodegradable.
Biodegradation: 63 %
Exposure time: 28 d
Method: OECD Test Guideline 301B
GLP: yes
aerobic
Inoculum: activated sludge
Concentration: 895 kBq/L
Carbon dioxide (CO2)
Result: Readily biodegradable.
Biodegradation: 99 %
Exposure time: 28 d
Method: OECD Test Guideline 303A
GLP: yes
Bioaccumulative potential
Product:
Bioaccumulation : Remarks: no data available
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Partition coefficient: n- : log Pow: 3,8 (23 °C)
octanol/water pH: 5,76
Method: Regulation (EC) No. 440/2008, Annex, A.8
GLP: no
Mobility in soil
Product:
Distribution among : Remarks: no data available
environmental compartments
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
12 / 15
SAFETY DATA SHEET
Components:
D-Glucitol, 1-deoxy-1-(methylamino)-, N-(C16-18 and C18-unsatd. acyl) derivs.:
Results of PBT and vPvB : The substance is not identified as a PBT or as a vPvB
assessment substance.
Disposal methods
Waste from residues : Product should be taken to a suitable and authorized waste
disposal site in accordance with relevant regulations and if
necessary after consultation with the waste disposal operator
and/or the competent Authorities
13 / 15
SAFETY DATA SHEET
International Regulations
Further information
Other information : Observe national and local legal requirements
AICS - Australian Inventory of Chemical Substances; ANTT - National Agency for Transport by
Land of Brazil; ASTM - American Society for the Testing of Materials; bw - Body weight; CMR -
Carcinogen, Mutagen or Reproductive Toxicant; CPR - Controlled Products Regulations; DIN -
Standard of the German Institute for Standardisation; DSL - Domestic Substances List (Canada);
ECx - Concentration associated with x% response; ELx - Loading rate associated with x%
response; EmS - Emergency Schedule; ENCS - Existing and New Chemical Substances (Japan);
ErCx - Concentration associated with x% growth rate response; ERG - Emergency Response
Guide; GHS - Globally Harmonized System; GLP - Good Laboratory Practice; IARC -
International Agency for Research on Cancer; IATA - International Air Transport Association; IBC
- International Code for the Construction and Equipment of Ships carrying Dangerous Chemicals
in Bulk; IC50 - Half maximal inhibitory concentration; ICAO - International Civil Aviation
Organization; IECSC - Inventory of Existing Chemical Substances in China; IMDG - International
Maritime Dangerous Goods; IMO - International Maritime Organization; ISHL - Industrial Safety
and Health Law (Japan); ISO - International Organisation for Standardization; KECI - Korea
Existing Chemicals Inventory; LC50 - Lethal Concentration to 50 % of a test population; LD50 -
Lethal Dose to 50% of a test population (Median Lethal Dose); MARPOL - International
Convention for the Prevention of Pollution from Ships; n.o.s. - Not Otherwise Specified; Nch -
Chilean Norm; NO(A)EC - No Observed (Adverse) Effect Concentration; NO(A)EL - No Observed
(Adverse) Effect Level; NOELR - No Observable Effect Loading Rate; NOM - Official Mexican
Norm; NTP - National Toxicology Program; NZIoC - New Zealand Inventory of Chemicals; OECD
- Organization for Economic Co-operation and Development; OPPTS - Office of Chemical Safety
and Pollution Prevention; PBT - Persistent, Bioaccumulative and Toxic substance; PICCS -
Philippines Inventory of Chemicals and Chemical Substances; (Q)SAR - (Quantitative) Structure
Activity Relationship; REACH - Regulation (EC) No 1907/2006 of the European Parliament and of
the Council concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals;
SADT - Self-Accelerating Decomposition Temperature; SDS - Safety Data Sheet; TCSI - Taiwan
Chemical Substance Inventory; TDG - Transportation of Dangerous Goods; TSCA - Toxic
Substances Control Act (United States); UN - United Nations; UNRTDG - United Nations
Recommendations on the Transport of Dangerous Goods; vPvB - Very Persistent and Very
Bioaccumulative; WHMIS - Workplace Hazardous Materials Information System
This information corresponds to the present state of our knowledge and is intended as a general
description of our products and their possible applications. Clariant makes no warranties, express
or implied, as to the information's accuracy, adequacy, sufficiency or freedom from defect and
assumes no liability in connection with any use of this information. Any user of this product is
responsible for determining the suitability of Clariant's products for its particular application.
Nothing included in this information waives any of Clariant's General Terms and Conditions of
Sale, which control unless it agrees otherwise in writing. Any existing intellectual/industrial
property rights must be observed. Due to possible changes in our products and applicable
national and international regulations and laws, the status of our products could change. Material
Safety Data Sheets providing safety precautions, that should be observed when handling or
storing Clariant products, are available upon request and are provided in compliance with
applicable law. You should obtain and review the applicable Material Safety Data Sheet
14 / 15
SAFETY DATA SHEET
information before handling any of these products. For additional information, please contact
Clariant.
AR / EN
15 / 15