NEOPRENE BRIDGE BEARINGS
ELEVATION VIEW
evel Sle Pte
DETAIL “A”
‘Beveled Sle Pte
ve ma Asm Aon
ier Stes
ge Cov Masony Pate
Som a ra
NEOPRENE IN COMPRESSION
Compressive Stess/Srain of Stool Reinfrcod Neoprene Bearings.
heck Shepage: Beam rove!
‘bearing can abso) =
‘oto sip
‘COMPRESSIVE SET
Zaha, 217F ma %
{ppm ones involame
seta iort sr odhew
‘mounting procedure DBI8, Procedie A
‘AOMESION
Bood made dering vlceniaton
i perimch
‘LOW TEMPERATURE
Britinass st -40
tweleve
{8 (bearing tngenx nth]
Description: Neoprene Bearing Pads are molded o ut rom
a molded sheet of high-grade, new neoprene synthetic
rubber compounds.
Use: As economical efficient bearing pats for pre-cast, pre-
stressed concrete or stl beams in bridges and buildings.
Nooprene Pads permit smooth and uniform transfer ofioad
from the beam to the substructure and allow beam rotation
atthe bearing duo to deflection of te beam under load. They
further allow lateral and longitudinal maverent ofthe beam
caused by thermal forces. Neoprene Pads have no movable
parts and thermal expansion and contraction are absorbed
by the pad’s ability to give and take in shear. There is no sliding
mation between pad and beam or btwoen pd and abutment.
Materials: The material specication forthe elastomeric
‘bearing shall meet the requirements of the current AASHTO M
21 (Standard specications fr laminated elastomer bridge
bearings) a listed under subsection "Materials" and “Test”
Fabrication: Elastomeric bearings shall be composed of
multiple laminates of elastomeric material separated by
steel reinforcing, Bearings have steel plates as the
reinforcement shall be cast as a unt in @ mold under
pressure and heat and the steel plates separating the
elastomeric layers shall be completely bonded by
vulcanization tothe elastomeric material on all surfaces,
An external load bearing steel plate(s) shall be factory
vulcanized tothe elastomeric bearings during the primary
molding process.
DESIGN RECOMMENDATIONS
ean wt
dat oa uate
das ms, ;
elena mera) Yenoe
‘+ = Yur personal psychologic
Bearing Thickness, n= 012) beam long) or = No ess than 172 in
Bearing Hardness: Compress Stress
Shape Factor:
‘deed i ons.
(wearing length xan)
7 oeninn nat x with a}
2 bearing length + mit earn ches, in)
Recommended shape acts for design shoul be minimum ft maximum of 12
19 lowest amp. is 20
"i lowest temp. 80°
vBtlowest tom. s-20
‘Noi hardness is 0
10d hardness BD
Asi hardness i 0
Beam avo that wl occur n= (0.0008) (temp. range" (beem length ft)
8
NoCracks
Nofoiure