Professional Documents
Culture Documents
TO :
Model : HSD150SX84
Note : 1. The information contained herein is preliminary and may be changed without prior notices.
2. Please contact HannStar Display Corp. before designing your product based on this module
specification.
3. The information contained herein is presented merely to indicate the characteristics and performance
of our products. No responsibility is assumed by HannStar for any intellectual property claims or other
problems that may result from application based on the module described herein.
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 2 / 35
Record of Revisions
1.0 --- Oct. 04,2002 Formal specification for HSD150SX84 was first issued.
2.0 --- Nov. 29,2002 Modify the module front view and back view drawing
3.0 --- Apr.07,2003 1. To sep up the screw torque in the formal specification(Page5)
2. To Modify the front and back view of the module drawing.
(Page26, 27)
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 3 / 35
Contents
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 4 / 35
1.1 Introduction
HannStar Display model HSD150SX84 is a color active matrix thin film transistor
(TFT) liquid crystal display (LCD) that uses amorphous silicon TFT as a switching device.
This model is composed of a TFT LCD panel, the voltage reference, common voltage,
DC-DC converter, column, and row driver circuit. This TFT LCD has a 15-inch diagonally
measured active display area with XGA resolution (768 vertical by 1024 horizontal pixel
array).
1.2 Features
■ 15” XGA TFT LCD panel
■ 2 CCFLs Backlight system
■ Supported XGA (V:768 lines, H:1024 pixels) resolution
■ Supported to 75Hz refresh rate
■ Without LCD Timing Controller
1.4 Applications
■ Desktop monitors
■ Display terminals for AV applications
■ Monitors for industrial applications
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 5 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 6 / 35
Humidity (%)
100
90
80
60 Operating Range
40
Storage Range
20
10
0
-40 -20 0 20 40 50 60 65
Temperature (oC)
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 7 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 8 / 35
ΦH
12’ o’clock
ΦH=90o
ΘL ΘR
ΘL=90o ΘR=90o
ΦL
6’ o’clock
ΦL=90o
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 9 / 35
TR TF
100%
90%
Optical
response
10%
0%
time
Photo-detector (BM-5A)
Field=2 o
50cm
LCD panel
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 10 / 35
10 mm 10 mm
256 512 768
10 mm
192
384
576
10 mm
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 11 / 35
L (n) – LB (n)
CT(n) = x 100% , n = 1 ~ 4
L (n)
1 1
1 - V L(1) 1 - V LB(1)
-
4 V 8 -
4 V 8
L(4) LB(4)
V V
L(3) LB(3)
1 1
-
2 V1 -
2
V
1
4 V - V 1
- 1 -
L(2) 4
8 V V
-
8 LB(2)
1 1 1 1
-H -H -H -H
8 8 8 8
1 1 1 1
-H -H -H -H
4 4 4 4
1 1
-H -H
2 2
H H
Pattern A Pattern B
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 12 / 35
X-Y FPC
(LCM Internal connector) Interface Interface
Connector Connector
(J2) (J1) X-PCB
1 40 1
Voltage Common
40
X-Y Reference Voltage
Connector DC-DC
Circuit Circuit
Source
Drivers
Gate
Drivers LCD Panel
768 lines x 1024 pixels
Y-PCB
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 13 / 35
1st Pixel 2nd Pixel 3rd Pixel 4th Pixel 5th Pixel 6th Pixel 1024th Pixel
768 Lines
LCD Display Area
1 Pixel = R G B
1024 Pixels
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 14 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 15 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 16 / 35
CN3
CN4
CN3, 4: CCFL Power Source (BHR-03VS-1/Japan Solderless Terminal MFG Co., LTD)
Mating connector: SM02 (8.0)B-BHS-1/ Japan Solderless Terminal MFG Co., LTD
Terminal No. Symbol Function
1 VL CCFL power supply (high voltage)
2 NC1) No connection
3 GL CCFL power supply (low voltage)
Note 1) Please connects NC pin to nothing. Don’t connect it to ground nor to other signal
Input. (NC pin should be open.)
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 17 / 35
Value
Item Symbol Condition Unit
Min. Typ. Max.
Input Voltage VDD +3.0 +3.3 +3.6 V(DC)
Input VDD = +3.3V
Irush 1.5(*) A
Rush Current Each Iout = max.
The backlight system is an edge-lighting type with 2-CCFL (Cold Cathode Fluorescent
Lamp).The characteristics of four lamps are shown in the following tables.
3.3V
t=400us ~ 10ms
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 18 / 35
Note: (1) Lamp current is measured with current meter for high frequency as shown below.
Specified values are for a lamp.
1
2 INVERTER
3 A (HIU-757)
LCD MODULE
1
2 INVERTER
3 A (HIU-757)
(2) Lamp frequency may produce interference with horizontal synchronous frequency
and this may cause line flow on the display. Therefore lamp frequency shall be
detached from the horizontal synchronous frequency and its harmonics as far as
possible in order to avoid interference.
(3) Life time (Hr) can be defined as the time in which it continues to operate under the
condition: Temp. =25±3ºC, IL=6.0mA(rms.) and fL=50 KHz until one of the following
event occurs:
1.When the brightness becomes 50%.
2.When the startup voltage (Vs) at 0ºC becomes higher than the maximal value of Vs
specified above.
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 19 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 20 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 21 / 35
T1 F1=1/T1
Reference Signal 70% 70%
(Pixel Clock) 30% 30%
T2
70% 70%
Input Clock 30% 30%
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 22 / 35
T7 T8 T6
DENB
(For Reference)
STV1
STV2
OE
CPV
LOAD
STH
T3 T4 T5
DENB 70% 70%
(For Reference) 30% 30%
T11 T12 T15
T9
90% 90%
50%
STV1 10% 10%
T11 T12
T10
90% 70%
STV2 10% 30%
T16A T17A T18A
90% 90%
OE 50% 50%
10% 10%
T13 T14 T16B T17B T18B
90% 70%
CPV 50% 50% 50% 50%
10% 30%
T32 T16C T17C T18C
70% 70%
LOAD 50% 50% 50%
30% 30%
STH
T23
T21 T22
70% Frame N
POL
30% Frame N+1
T24
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 23 / 35
70%
CPH1 30%
50% 50%
70%
70%
CPH2 30%
50% 50%
30%
T19 T20 T2
70% 70%
STH
T16D
T29 T30
st rd th th th th th
1 3 5 7 9 11 1023
Odd R,G,B Data INVALID
Pixel Pixel Pixel Pixel Pixel Pixel Pixel
nd th th th th th th
2 4 6 8 10 12 1024
Even R,G,B Data INVALID
Pixel Pixel Pixel Pixel Pixel Pixel Pixel
INVALID
REV
70%
CPH1 30%
50% 50%
70%
CPH2 30%
50% 50%
T2
70%
LOAD 50% 50%
T16C
T31
70%
STH 50%
30%
T17D T18D
T25 T26
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 24 / 35
3.3V
100ms
Data
(R,G,B, other control signals)
35 ~ 100ms
Control
(OE)
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 25 / 35
Power Supply
0.9VDD 0.9VDD
TP2 TP3
Signal
0.6VDD 0.6VDD TP4
0V
TP5
Backlight
TP6
(Recommended) 50% 50%
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 26 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 27 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 28 / 35
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
HSD150SX84
Rev:
Lot mark
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 29 / 35
Packing pair
One packing
Packing plate
Packing pair
Packing plate
Tape
Bag
Carton
Carton
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 30 / 35
Band
Packing case Band clip
Tape
948±5 mm
Pallet
1150±5 mm 970±5 mm
1 Pallet = 12 cartons
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 31 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 32 / 35
10.10 Disposal
When disposing LCD module, obey the local environmental regulations.
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 33 / 35
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 34 / 35
Type 1
Type 2 Type 3
Type 1
Type 2 Type 3
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.
H a n n St a r D i s p l a y C o r p .
Document Title HSD150SX84 Formal Specification Page No. 35 / 35
Type 1
﹤15mm
NG
﹤15mm
NG
The information contained in this document is the exclusive property of HannStar Display Corporation. It shall not be
disclosed, distributed or reproduced in whole or in part without written permission of HannStar Display Corporation.