Professional Documents
Culture Documents
Contents
▶Introduction
▶Point
- Approach of prevent level by equipment
▶About company
▶Test Reports
▶Certifications
In 2012, after the Coronavirus has been discovered in Saudi Arabia, It has
intensively broken out in middle east area. This is similar to SARS(Severe
Acute Respiratory Syndrome), caused nearly 800 deaths, was spread all over
the world from Asia in 2003.
The incubation period is about one week, and it is transmitted through the
medium of air by coughs and sneezes. Also the virus cause severe respiratory
symptoms in common with SARS, like a high fever, cough, and difficulty
breathing, etc. but, It features accompanying the acute kidney injury unlike
SARS and according to the research, it has six times higher fatality rate than
SARS. The Coronavirus shows a fatal aspect far more than SARS.
So, the study about vaccine for the Coronavirus is ongoing, and it is expected
to be developed by the end of the year. Therefore, taking the medicine called
Echinaforce is the best way for the present, and the Echinaforce Protect Tab,
which is the same medicine, is produced by HanWha Pharma Co., Ltd. in
Korea.
Also to prevent the virus, Disinfectant Generator, which can remove the
various pathogenic bacteria, is used. It is the way to generate disinfectant
water through electrolyzing a little amount of diluted salt and HOCl. The
solution generated from the device has a strong and widespread sterilizing
power, and these systems are being used to prevent from various infectious
disease by sterilizing hands before and after eating at school, university, and
government branch over 6,000.
Approach of prevent level by equipment
Through sterilizing hands which are the main route of Features of NaOCl / HOCl
various disease, the viral germs are removed by 99.9%. -A colorless and transparent liquid with a weak odor
Especially, it is the most important that before and after of chlorine like tap water.
eating, after using a toilet, and management of go in and
out. It also be used effectively at the places where there are -Doesn’t make any harm even if it enters your eyes or
lots of children or many people are moving. Only sterilizing mouth, because it is a safe ingredient.
hands is possible to prevent about 90% of various -Minimizing the environmental pollution, because it
infectious disease and 70% of food poisoning. resolves itself into external environment.
-Maintenance cost is saved, because it doesn’t need
Sort NaOCl HOCl any chemical and soap, etc.
Main Sodium Hypochlorous acid -With a widespread disinfectant power, it is already
ingredient hypochlorite (20~30ppm) recognized as a safe disinfecting water in the world.
(100/200ppm)
Active pH 7.0~7.5 pH 5.0~6.5
chlorine Neutral Weak acidic
concentration electrolyzed water electrolyzed water
Additive Salt (≤88%) Dilute hydrochloric
acid (2~6%)
99.99% 99.99%
99.99% 99.99%
▶Vibrio Parahaemolyticus
99.99%
Through hand washing before meals, it can prevent various microbism and
manage safety in the food service facilities at school. It also solves the problem
with using of existing chemicals.
(It is possible to reduce budget as much as $4,700 compared with when using
10~20 general chemical spray sterilizer.)
sec.
Before After
As shown in the above table, Hypochlorous acid was confirmed to inactivate virus in 15 seconds to
detection limit valve (<1.5).
TEST RESULT Source: Korea Health Industry Development Institute
For the highly effective prevention of various pathogenic microorganism and virus by air-borne infection, The
experiment which the removal effect to air-borne microorganism by spraying Hypochlorous acid solution on air
has been performed.
Experiment test result : The air-borne microorganism has been decreased to 99.96% after 30 minutes by Spraying
Hypochlorous acid solution on air with humidifier it was the most reduction ratio result, 99.98% after 60 minutes, and after
90 minutes almost the air-borne microorganism was removed to 99.99%.
According to the result it is highly effective to air-borne microorganism by spraying the Hypochlorous acid solution on air
with such as humidifier.
30 1.20±0.14 99.96
60 0.73±0.20 99.98
90 0.10±0.17 99.99
The test result for infectivity reduction effect against Virus by Hypochlorous acid, reduction effect for
allergen matter
TEST REPORTS Source: Graduate School of Health Sciences and Nursing, Faculty of Medicine, University of Tokyo
Cleansing effectiveness of Electrolyzed Water Depending on the Nursing Procedure and Degree of Hand
Title
Contamination
Author Yasuko Takahashi, Akemi Takeshita, Miyoko Endo, and Minako Sasaki
Journal
Biocontrol Science
name
Vol.7, 2002, No.3, page: 173-179
We examined the antibacterial effectiveness of hand washing with electrolyzed water (EW) depending on the
type of nursing procedure and differences in the degree of bacterial contamination on hands after the
procedure. With respect to the bacteria on the hands after diapering (relatively heavy contamination),
changing positions (relatively light contamination), and endotracheal aspiration (light contamination), hand
washing for 10s and 30s with EW lowered the hand bacterial counts after hand washing to the same level as
Abstract or lower than that before the procedures. Washing with EW was as effective as washing with medicated liquid
Summary soap and 7.5% (w/v) povidone-iodine liquid.
Based on these results, we considered that and washing for 10s with EW could be applied to any of the
procedures that require direct contact with the patient's skin (diapering) or clothing (changing positions), as
well as the procedures involving no direct contact with the patient (endotracheal aspiration).
Furthermore, effective washing could be expected in a short period of time, with no rising of resident bacteria
to the surface of the hand.
TEST REPORTS Source: Journal of the Japanese Food Microbiology
On investigation about the effect of hand washing using an electrolyzed water, by using an electrolyzed water
with soap, it is possible to remove pollutants and It has developed that it can maintain a state of having little
germs after hand washing.
Abstract The virus is discharged in quantity during defecating from the inapparent infectors who are infected with the
Summary Noro virus but haven’t had any symptoms. So, It is better to wash hands enough after using a public toilet.
As disinfecting water which is expected effect of hand washing in a short time, it is useful before meals, once
go in and out, and after using a toilet. The electrolyzed water has high safety, and also it is expected to have
enough sterilizing effect.
RESEARCH METERIAL
Country Link
Japan http://www.solmind.com/hclo/sonota/z_hotta.pdf
http://panasonic.net/sanyo/news/2010/12/17-1.pdf
http://www.hks-air.com/pdf/bisanseidenkaisui.pdf
http://jf-foods.jp/bisansei.pdf
http://ir.lib.miyazaki-u.ac.jp/dspace/bitstream/10458/3743/1/Vol.58_pp.1-10.pdf
http://e-doto.com/hdms/pdf/functional.pdf
http://www.atpress.ne.jp/releases/23610/1_5.pdf
http://www.taisei.co.jp/giken/report/2010_43/paper/A043_055.pdf
http://www.bisansei.jp/product/document/spec.pdf
http://www.mizushori.co.jp/oruplus.pdf
http://tokai-planet.co.jp/%E5%8F%A3%E8%B9%84%E7%96%AB%E6%8F%90%E6%A1%8897.pdf
http://www.pref.okayama.jp/sangyo/kougi/riyo/report/pdf/2005/H18-7-32-14-17.pdf
http://www.kawanishi-dental.com/pict/epios_test.pdf
USA http://www.endoexperience.com/documents/steriloxendo.pdf
http://lwicker.myweb.uga.edu/electrolyzedwater.htm
http://www.toucan-
eco.eu/pagina/x_downloads/Toucan_eco_CTS001%20The%20Disinfecting%20Effect%20of%20Electrolyzed%20Water.pdf
http://rovingreen.com/wp-content/uploads/2012/04/Electrolyzed-Water-White-Paper.pdf
http://www.cres.gr/kape/publications/papers/dimosieyseis/ydrogen/A%20REVIEW%20ON%20WATER%20ELECTROLYSIS.pdf
http://www.newteck-ionizers.com/uploads/1/1/1/7/11172429/antioxidant_effect_of_electrolyzed_water.pdf
http://www.aquaox.net/uploads/EAW_as_disinfectant_for_fresh-cut_vegetables.pdf
http://kangenionizers.com/uploads/4/1/6/8/4168867/electrolyzed_water_effective_as_chemical_cleaner_study_finds.pdf
http://fapc.okstate.edu/files/flash/electrolyzedwater.pdf
http://uwmdinc.com/files/64840714.pdf
Product Line Hand Washing System
#1. DES-H200
#2. DES-WS850
#3. Others
Product Line Installation : Schools / Kindergartens / Governments
#1. DES-H200 List: Sejong City Premier's offices & Government offices, Daegu Government offices, Masan Government offices,
the National Scientific Investigation Laboratory, Fair Trade Commission, Local Government Officials
#2. DES-WS850 Development Institute, National Defense Navy at the Second Fleet, Office of Education in Seoul City, and more
#3. Others than 6,000 School feeding facilities.
Product Line Washing Stand for Sterilizing & Deodorizing
#1. DES-H200
#2. DES-WS850
#3. Others
Product Line Installation : Food waste disposal plant in Residental facilities, etc.
#1. DES-H200 List: Waste disposal place in the apartment complex, The funeral hall in the Incheon Mary’s Hospital, Daejeon
Wellness hospital, etc.
#2. DES-WS850
#3. Others
Product Line Livestock
#1. DES-H200 - It can be used for hygienic management of farms and disinfection of livestock to prevent an infectious
problems from the diverse livestock.
#2. DES-WS850 - It can help to sterilize and deodorize by spraying the disinfecting water in the breeding farms, workspaces
#Others and more.
- By spraying directly onto livestock using a sprayer, it prevents a disease and maintains cleanliness of the
livestock.
- Prevention of the variety of viral diseases such as avian, pig influenza.
Example of install : Anseong livestock, Aerang Ranch, Soshinburl farm, Beomsan Ranch, Sky Ranch and more.
Applicable References
Agricultures
-Prevent microorganism such as bacteria and germs through sterilizing action.
-Keep your health by minimizing harmful materials such as agricultural pesticide.
-Help to increase a trust of consumer by harvesting environment-friendly agricultural products.
(producing good fruit through using Electrolyzed water)
W500 X D500 X H850 W650 X D610 X H1300 W480 X D300 X H490 W520 X D585 X H970
Saline tank: 20L Saline tank: 100L Salt tank: 5kg max. pressure: 130bar
(Use) Waste disposal place, (Use) Washing and sterilizing food materials, utensils, etc. (Use) High-pressure washer in
School health room, etc. Factories, Feeding facilities, etc.
Products For
washing
hand
1. Company Profile
Having researched for 30 years in electrolyzed water, D&D Electronics made the first disinfecting water
generator in 1996, which produces automatically disinfecting water using only a salt, water and an electricity.
Our generator has been serving in many places for health care and hygiene including public schools,
restaurants, farms, food processing plants about 6,000 places.
As a result, many schools in Korea are using our system and we rank No.1 in terms of market share in the
disinfecting generator. In addition, for home use product is becoming standard equipment in most Korea’s
apartments. Korea Food and Drug Administration approved our generator for safety and effectiveness.
By participating in several international exhibitions, NaOClean has been proven the excellence and it has
more powerful than ozone sterilizer while having a superior cost-competitive.
We are trying to protect the environment from pollution and help prevent a wide range of illness such as food
poisoning and infections. We are trying to be reliable and trustworthy to help improve your health and to
become beloved company. Meet the company that improves the quality of your life.
2. History
Date History
1980. Beginning of research into Electrolyzed Neutral water
1994.06 Founded as D&D Electronics
1998.10 Selected as one of the leading venture by the Small Business Administration
1999.03 Selected as one of the promising venture by Gyeonggi-do
2000.04 Obtained ISO 9001
2002.07 Selected as 100 great product Electro-analyzed sanitizing solution
2005.01 Designated as “Industry family company”
2005.02 Approved as a good products NaOClean by Public Procurement Service
2005.08 Recognized as a great performance machine by the Small Business Administration
2005.11 Developed new technologies by the Minister of Industry Ministry recognition
2006.01 Approved as NEP good products by Industry Ministry
2006.02 Recognized as a sterilized disinfectant machine by Korea Food Research Institute
2006.03 Recognized as a food additives “Electro-analyzed sanitizing solution, NaOClean by Korea Food Research Institute
2006.05 Recognized as the “Patent of Korea” in 41th invention day
2006.07 Launched NaOClean plus the first domestic invention
2006.08 Launched NaOClean-S the first domestic invention
2008.08 Received Inno-Biz certification by the Small Business Administration
2009.04 Launched NaOClean for family use
2011.04 Recognized as a developing innovative technology by the Ministry of Education, Science and Technology
2012.06 Selected as one of the promising export venture by the Small Business Administration
3. Test reports (Certificated by KFDA)
3. Test reports (Certificated by KFDA)
3. Test reports
3. Test reports
3. Test reports
3. Test reports (Materials)
3. Test reports (Materials)
4. Certifications
4. Certifications