Professional Documents
Culture Documents
1107 | P a g e
K Y Patil, D S Chavan / International Journal of Engineering Research and Applications
(IJERA) ISSN: 2248-9622 www.ijera.com
Vol. 2, Issue4, July-August 2012, pp.1107-1110
IV. SLIP RING INDUCTION GENERATOR Model using D.C. shunt motor coupled with
The induction generator is nothing more Slip ring Induction Generator for wind energy
than an induction motor driven using external prime generation at different wind speed conditions.
mover above its synchronous speed by an amount Circuit diagram for the model is as shown in Fig. 2
not exceeding the full load slip the unit would have To obtain variable speed conditions potential divider
as a motor. method of speed control of D.C. shunt motor is used.
The induction generator requires one With change in the speed, there is change in voltage
additional item before it can produce power it generated from slip induction generator. Different
requires a source of leading VAR’s for excitation. readings were taken at different excitation voltages
The VAR’s may be supplied by using capacitors or to rotor of slip ring induction generator. As
from the utility grid. excitation voltage is changed there is change in
The schematic diagram for slip ring speed of rotation and change in output voltage
induction generator is shown in fig.1 generated from generator.
1108 | P a g e
K Y Patil, D S Chavan / International Journal of Engineering Research and Applications
(IJERA) ISSN: 2248-9622 www.ijera.com
Vol. 2, Issue4, July-August 2012, pp.1107-1110
1109 | P a g e
K Y Patil, D S Chavan / International Journal of Engineering Research and Applications
(IJERA) ISSN: 2248-9622 www.ijera.com
Vol. 2, Issue4, July-August 2012, pp.1107-1110
1110 | P a g e