Professional Documents
Culture Documents
Production Effective :
VIN Production Date
Listed in table in procedures* NA
HINT:
*: The VIN numbers are provided only as a reference.
CHANGES:
• Information about tester displays "LONG FT#1" and "LONG FT#2" have been added.
• Information to distinguish between CAMRY 2AZ-FE for California and CAMRY 2AZ-FE for the
remaining 49 states has been added.
• VIN number information for North America models has been added.
• Avalon 1MZ-FE (Destination: Other) has been corrected.
• Highlander 3MZ-FE and Kluger 3MZ-FE have been corrected.
• YARIS 1NZ-FE and 2NZ-FE (Destination) have been corrected.
• RAV4 1AZ-FE (Line-off: From May '00 and From August '03 to October '05) and '05 models have
been deleted as it is not related to this Service Bulletin.
ENGINE
MASS AIR FLOW METER
INSPECTION
NOTICE:
The MAF meter inspection procedure changes are for vehicles with DENSO made MAF meters.
Vehicles with HITACHI made MAF meters do not apply.
A112309
HINT:
The procedures above are the previous MAF meter inspection procedures. Please use the procedures
below, which are the new MAF meter inspection procedures.
1. CHECK MASS AIR FLOW METER (for Gasoline Engine)
NOTICE:
• Perform the MAF meter inspection according to the procedures below.
• Only replace the MAF meter when both the LONG FT#1 value and MAF value in the DATA
LIST (with the engine stopped) are not within the normal operating range.
A114321E01
(Vehicle Speed)
*1 *1 *1
Idling
Warming up
*1: 3 minutes or more
(b) Read value using intelligent tester II (LONG FT#1 and LONG FT#2).
HINT:
The "LONG FT#1" display is for in-line engines. For V-type engines, "LONG FT#1 (NO. 1
BANK)" and "LONG FT#2 (NO. 2 BANK)" are displayed.
(1) Enter the following menus: Powertrain / Engine and ECT / Data List / Long FT#1 and Long
FT#2
(2) Read the values displayed on the tester.
Standard value:
Within -15 to +15%
If the result is not within the standard value, perform inspection below.
HINT:
• "LONG FT#1" or "LONG FT#2" may change while idling and driving. Make a note of the
maximum (or minimum) value.
• For V-type engines, if the value for either "LONG FT#1" or "LONG FT#2" is not within
the standard value, perform the inspection below.
(c) Read value using intelligent tester II (MAF).
NOTICE:
• Turn off the engine.
• Perform the inspection with the vehicle indoors and on a level surface.
• Perform the inspection of the MAF meter while it is installed to the air cleaner case
(installed to the vehicle).
• During the test, do not use the exhaust air duct to perform suction on the exhaust
pipe.
(1) Turn the ignition switch to ACC.
(2) Turn the ignition switch ON (do not start the engine).
(3) Turn the intelligent tester II ON.
(4) Enter the following menus: Powertrain / Engine and ECT / Data List / MAF.
(5) Wait 30 seconds, and read the MAF values on the intelligent tester.
Standard condition:
Less than the value shown under "Specified Condition"
• If the result is not as specified below, replace the MAF meter.
• If the result is within the specified range, inspect the cause of the extremely rich or lean
air fuel ratio (Refer to the repair manual of the vehicle you are servicing).
TOYOTA
Line-off Specified
Destination: North America Destination: Destination:
Vehicle Model Engine Type (Start of Condition
VIN Number Europe Other
Production) (g/sec.)
From August '99 to
2JZ-GE - - { 0.47
December '03
CROWN
{
3GR-FE From February '05 - - 0.66
China
{
REIZ 3GR-FE From October '05 - - 0.44
China
Line-off Specified
Destination: North America Destination: Destination:
Vehicle Model Engine Type (Start of Condition
VIN Number Europe Other
Production) (g/sec.)
{
2AZ-FE *1 From August '01 - - 0.46
From JTDBE32KX20002772
{
2AZ-FE *2 From August '02 For California - - 0.45
From JTDBE32K030139009
2AZ-FE From August '01 - { {
{ 0.46
From August '01 to
2AZ-FE *1 From 4T1BE30K82U001028 - -
August '03
From 4T1BE30K52U500417
{
From '04 Model year
2AZ-FE *1 From August '03 - - 0.54
From 4T1BE30K74U260581
From 4T1BE32K44U788205
1AZ-FE, 2AZ- {
From February '02 - -
FE ASEAN
0.46
{
1AZ-FE From February '02 - -
Taiwan
{
1AZ-FE, 2AZ- From May '02 to
- - Australia, 0.47
FE December '05
G.C.C.
CAMRY
{
From JTDBF30K120001879
From August '01 to
1MZ-FE { - - 0.52
August '03
From 4T1BF30K62U001039
From 4T1BF30K32U500039
{
From '04 Model year
From JTDBF30K340151821
Line-off Specified
Destination: North America Destination: Destination:
Vehicle Model Engine Type (Start of Condition
VIN Number Europe Other
Production) (g/sec.)
{
MCL20L: From
SIENNA 3MZ-FE From January '04 5TDZA22C14S105222 - - 0.54
MCL25L: From
5TDBA22C94S012580
{
ACU20L: Until
2AZ-FE Until August '03 JTEGD21A630073654 - - 0.52
ACU25L: Until
JTEHD21A4230025427
{
ACU20L: From
2AZ-FE From August '03 JTEDD21A640073058 - - 0.49
ACU25L: From
JTEHD21A040025363
{
HIGHLANDER
MCU20L: Until
1MZ-FE Until August '03 JTEGF21A330121685 - - 0.52
MCU25L: Until
JTEHF21A430158393
{
MCU23L: From
3MZ-FE From March '03 JTEDP21A040001005 - -
MCU28L: From 0.56
JTEEP21A640001045
{
3MZ-FE From March '03 - -
Australia
{
MHU23L: From
KLUGER 3MZ-FE From March '05 JTEDW21A260001013 - - 0.54
MHU28L: From
JTEEW21A660001052
{
2AZ-FE Until January '03 - { Australia,
PREVIA / G.C.C.
0.39
TARAGO {
2AZ-FE From January '03 - { Australia,
G.C.C.
1ZZ-FE From May '00 - { - 0.46
{
ACA23L: From
From August '03 to
2AZ-FE JTEHD20V340001241 - -
RAV4 October '05
ACA28L: From 0.39
JTEGD20V040001399
From August '03 to {
2AZ-FE - -
October '05 Australia
{
ZZT230L: From
1ZZ-FE, 2ZZ-
From August '01 JTDDR32T920111794 - -
GE
CELICA ZZT231L: From 0.41
JTDDY38T620052295
1ZZ-FE, 2ZZ-
From August '01 - { {
GE
Line-off Specified
Destination: North America Destination: Destination:
Vehicle Model Engine Type (Start of Condition
VIN Number Europe Other
Production) (g/sec.)
{
1NZ-FXE Until August '03 - -
Until JT2BK12U030088781
1NZ-FXE Until August '03 - { -
PRIUS { 0.11
1NZ-FXE From August '03 - -
From JTDKB20U240001139
{
1NZ-FXE From August '03 - {
Australia
{
1ZZ-FE From January '00 ZZW30L: From - -
MR2 JTDFR3207Y0005206 0.42
Line-off Specified
Destination: North America Destination: Destination:
Vehicle Model Engine Type (Start of Condition
VIN Number Europe Other
Production) (g/sec.)
{
xA 1NZ-FE From July '05 NCP61L: From - -
JTKKT624650129380
0.27
{
xB 1NZ-FE From July '05 NCP31L: From - -
JTLKT324854028246
1NZ-FE, 2NZ-
YARIS / ECHO From January '99 { { { 0.25
FE
{
1NZ-FE, 2NZ-
From '00 NCP12L: From - - 0.25
FE
JTDBT1235Y0035819
1NZ-FE, 2NZ-
From January '05 - - {
FE
{ 0.28
YARIS 1NZ-FE, 2NZ-
From August '05 NCP91L: From - -
FE
JTDJT92336500886
From May '99 to
1SZ-FE - { -
August '04
0.12
1SZ-FE, 2SZ- {
From January '03 - -
FE TMMF made
{
Thailand,
1NZ-FE, 2NZ- From January '03
- - Malaysia,
FE to June '04
Philippines,
Indonesia
{
Thailand,
VIOS 1NZ-FE, 2NZ- 0.25
From June '04 - - Malaysia,
FE
Philippines,
Indonesia
1NZ-FE, 2NZ- From January '03 {
- -
FE to June '04 Taiwan
1NZ-FE, 2NZ- {
From June '04 - -
FE Taiwan
{
VCK30L: Until
5VZ-FE Until August '02 5TBRN34102S332719 - -
VCK40L: Until
5TBBN44152S332707
TUNDRA 0.38
{
VCK30L: From
5VZ-FE From August '02 5TBRN34123S332724 - -
VCK40L: From
5TBBN44193S332744
{
GRN255L: From
5TETU22N55Z025862
GRN245L: From
5TELU42N85Z025480
From December
TACOMA 1GR-FE GRN250L: From - - 0.72
'04
5TEMU52N95Z025496
GRN265L: From
5TETU62N25Z028886
GRN270L: From
5TEKU72N05Z029133
Line-off Specified
Destination: North America Destination: Destination:
Vehicle Model Engine Type (Start of Condition
VIN Number Europe Other
Production) (g/sec.)
{
5VZ-FE From August '02 - -
Australia
HILUX 0.51
{
5VZ-FE Until August '04 - -
Australia
LAND CRUISER
5VZ-FE Until August '02 - { { 0.38
PRADO
5VZ-FE From August '99 - { - 0.41
{
GRN210L: From
From November
1GR-FE JTEZU14R930001089 - - 0.72
4 RUNNER '02
GRN215L: From
JTEBU14R030001015
From November
1GR-FE - { { 0.70
'02
{
1TR-FE, 2TR-
From August '04 - { Thailand,
HILUX / TOYOTA FE
Indonesia
INNOVA /
KIJANG INNOVA {
1TR-FE, 2TR- 0.36
/ TOYOTA From January '05 - { India / South
FE
FORTUNER / America
HILUX SW4
1TR-FE, 2TR-
From April '05 - - {
FE
A114321E01
• During the test, do not use the exhaust air duct to perform suction on the exhaust
pipe.
(1) Turn the ignition switch ON (do not start the engine).
(2) Turn the intelligent tester II ON.
(3) Enter the following menus: Powertrain / Engine and ECT / Data List / MAF.
(4) Wait 30 seconds, and read the values on the intelligent tester.
Standard condition:
Less than the value shown under "Specified Condition"
If the result is not as specified below, replace the MAF meter.
TOYOTA
Line-off Specified
Destination: Destination: Destination:
Vehicle Model Engine Type (Start of Condition
North America Europe Other
Production) (g/sec.)
AVENSIS 2AD-FHV From April '05 - { - 0.55
From November
RAV4 2AD-FTV - - { 0.55
'05
COROLLA 1ND-TV From June '04 - { { 0.23
From September
1ND-TV '01 to December - { -
'02
YARIS From January '03 0.22
1ND-TV - { -
to October '05
{
1ND-TV From October '05 - -
TMMF made
{
2KD-FTV From August '01 - { 0.31
Thailand
From October '01 {
HILUX 2KD-FTV - - 0.59
to December '04 Thailand
From August '02 to {
1KD-FTV - - 0.56
August '04 Thailand
From August '00 to
1KD-FTV - { - 0.29
LAND CRUISER August '02
PRADO From August '00 to
1KD-FTV - { - 0.38
August '02
4 RUNNER 1KD-FTV From August '02 - { - 0.50
{
1KD-FTV From August '04 - - Thailand,
Indonesia
HILUX / TOYOTA
INNOVA / KIJANG {
1KD-FTV From April '05 - -
INNOVA / TOYOTA South Africa 0.35
FORTUNER / HILUX {
SW4 1KD-FTV From January '05 - -
South America
{
2KD-FTV From January '05 - {
Thailand
From '02 to August
HIACE 2KD-FTV - { - 0.37
'06