Professional Documents
Culture Documents
Click Start->Control Panel->select and double click Network and internet connections-
>select and double click Network Connections.
Step 2
Double-click the Local Area Connection icon; highlight Internet Protocol (TCP/IP) tab in the
Local Area Connection Properties window that appears:
Step 3
Double click it or click Properties. The TCP/IP Properties window will display.
Step 4
Now you have two ways to configure the TCP/IP protocol below:
1. Assigned by DHCP Sever
Select Obtain an IP address automatically and Obtain DNS Server address automatically,
as shown in the figure below. These may be selected by default. Then click OK to save setting.
2.Assigned manually
1) Select Use the following IP address, as shown in the following figure.
If the router’s LAN IP address is 192.168.1.1, please type in IP address 192.168.1.x (x is from 2
to 253), subnet mask 255.255.255.0, and default gateway 192.168.1.1.
2) Select Use the following DNS server addresses, as shown in the following figure. And then
type the DNS server IP address, which should be provided by your ISP. Finally remember to
click OK to save settings.
Note: In most cases, type your local area DNS server IP addresses into it.
The Preferred DNS server is same to default gateway. For Secondary DNS server, you could
leave it blank or type in 8.8.8.8.
Step 5
Click OK to save and apply your settings.
Step 2
Type ncpa.cpl in the box, then press OK.
Step 3
Select the local area connection, right click it and select Properties.
Step 4
Select Internet Protocol Version 4(TCP/IPv4), double click it or click Properties.
Step 5
There are two ways to configure the TCP/IP Properties, Assigned by DHCP server
automatically or manually.
1. Assigned by DHCP server
Select Obtain an IP address automatically and Obtain DNS server address automatically. If
necessary, then click OK to save the settings.
2. Assigned manually
1) Select Use the following IP address, type IP address, subnet mask and default gateway IP
address into it.
If the router’s LAN IP address is 192.168.1.1, please type in IP address 192.168.1.x (x is from 2
to 253), subnet mask 255.255.255.0, and default gateway 192.168.1.1.
2) Select Use the following DNS server addresses, as shown in the following figure. And
then type the DNS server IP address, which should be provided by your ISP. If necessary, then
click OK to save the settings.
Note: In most cases, type your local area DNS server IP addresses into it.
The Preferred DNS server is same to default gateway. For Secondary DNS server, you could
leave it blank or type in 8.8.8.8.
Step 6
Click OK to save and apply your settings.
Step1
Click on the Windows Key on your Keyboard and Press X. On the menu that appears click
control panel.
+ ‘X’
Step 2
Step 7 Change ‘Dot’ to Use the following IP address and input your IP and DNS information.
Step 8:
Step 1
Right click the internet icon in the task tray, select Open Network and Sharing Center.
Step 2
Step 3
Step 4
To get fixed IP settings, select Use the following IP address and Use the following DNS
server addresses, then enter the IP address, subnet mask, default gateway and DNS server
manually.
For MAC OS:
Step 1
Click on Network
Step 3
Input your IP information (Router is the Default Gatway address) and click Apply
Note:
1.DNS server should be provided by your ISP. Please contact with your ISP to check them.
2.In most cases, you could type your local area DNS server IP addresses into it. The DNS server
is same to Router LAN IP address. In some cases, you could also leave it blank or type in
8.8.8.8.