surface is taken into account if the extent of survey is more than (a) 100 km2 (b)160 km2 (c) 500 km2 (d)260 km2 Q2. The survey in which the curvature of the earth is taken into account is called: (a) Geodetic survey (b)Plane survey (c) Hydrographical survey (d)Topographical survey Q3. Which of the following scale is the smallest one? (a) 4:200000 (b)1 cm=5000 m (c) 1 cm=50 m (d)RF=1/50000 Q4. When 1 cm on a map represents 10 m on the ground, the representative fraction of the scale is: (a) (b) (c) (d) Q5. Which of the following statement is respect of a map A having scale 1:1000 and another map B having scale 1:5000 is true? (a) Map A is a large scale map compared to map B. (b)Map B is a large scale map compared to map A. (c) Map B is a more detailed map compared to map A. (d)None of the above Q6. A scale representing either three units or only one unit and its fractions up to second place of decimal point is- (a) Diagonal scale (b)Comparative scale (c) Vernier scale (d)Shrunk scale Q7. Difference in length of an arc and its subtended chord on earth’s surface for a distance of 18.2 km is- (a) 10 mm (b)15 mm (c) 22 mm (d)100 mm Q8. Which one of the upper limit of survey area (Square kilometer) for use of plane survey ? (a) 250 (b)300 (c) 350 (d)450 Q9. Determine the number of divisions required on the Vernier scale, if it is combined with the main scale of least count 0.5 mm. The least count of the combination required is 0.05 mm for the direct Vernier. (a) 0.025 (b)0.1 (c) 1 (d)10 Q10. The Vernier scale in which 10 divisions of the Vernier scale is equal to 9 divisions of the main scale is called____. (a) Direct Vernier (b)Double Vernier (c) Extended Vernier (d)Retrograde Vernier Q11. An area of a field is 250 square centimeters from a shrunk map having shrunk factor of a 0.9. Calculate the original area (square meters) on the field, if the original scale of the map is 1 cm=50 cm. (a) 309 (b)625000 (c) 694444 (d)771450 Q12. Calculate the length of one division of the Vernier scale, if least count of the combination of main and Vernier scale is 0.02 mm. The least count of the main scale is 1 mm. (a) 1 (b)0.98 (c) 1.02 (d)1.03 Q13.In geodetic surveying, sum of all the internal angles (degree) of a spherical triangle should be____. (a) Equal to 180 (b)Equal to 360 (c) Greater than 180 (d)Less than 180 Q14. The correction for sag is: (a) Always additive (b)Always subtractive (c) Always zero (d)Sometimes additive and sometimes subtractive Q15. Cross-staff used for: (a) Setting out right angle (b)Measuring horizontal angle (c) Both (a) and (b) (d)None of these Q16. In a metric chain, number of links per meter run can be: (a) 2 (b)5 (c) 8 (d)0 Q17. The correction for slope in chaining is proportional to:
(a) (b) h (c) h2 (d)h3 Q18. The correction to be applied to each 30 m chain for a line measurement along a slope of is (a) 30(1-cos ) (b)30(1-sin ) (c) 30(1-tan ) (d)30(1-cot )