Professional Documents
Culture Documents
In addition:
• Mount track so that the back edge of the
track is flush to the back edge of drywall.
To minimize and
standardize this gap
from top to bottom of
door, adjust the angle
of these brackets.
When satisfied that the gap is
Loosen the side screw to allow even, tighten side screw and
bracket to pivot, which lowers install final (bottom) screw.
that side of the door.
In addition:
Door header,
drywall wrapped
Construct the same casing
piece as with bypass
doors, mounting flush to
2x2 outside of drywall.
Casing lumber
Install a rectangle of ¾”OSB to the back of the drywall lid for rigidity and weight.
Install a ¼” wide adhesive insulation
strip to the top of the ledger.
• This will compress under lid and
prevent air/energy leakage.
• To augment the adhesive and
ensure the strip stays, use a few
fascia nails to tack it down.
Attic Accesses
Install hook and eyes centered on lid.
• These prevent uplift of the lid during
great pressure differences to protect
energy efficiency.
• Ensure these attach to the ¾” OSB,
not just drywall.