Professional Documents
Culture Documents
com
QQ 376315150 892498299
ORDER NO.
RRV4043
VSX-820-K
VSX-820-K
TEL
TEL
13942296513
13942296513
VSX-520-K
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
QQ
QQ
Model Type Power Requirement Remarks
TEL 13942296513
VSX-820-K CUXCNSM AC 120 V
QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
VSX-520-K CUXCNSM AC 120 V
.
PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2010
K-IZK MAR. 2010 Printed in Japan
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
SAFETY INFORMATION
QQ 376315150 892498299
This service manual is intended for qualified service technicians ; it is not meant for the casual do-it-
yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained
to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
WARNING
B This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive
harm.
Health & Safety Code Section 25249.6 - Proposition 65
TEL
TEL
NOTICE
(FOR CANADIAN MODEL ONLY)
Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement parts must
13942296513
13942296513
be of identical designation.
REMARQUE
(POUR MODÈLE CANADIEN SEULEMENT)
Les symboles de fusible (fusible de type rapide) et/ou (fusible de type lent) sur CCI indiquent que les pièces
de remplacement doivent avoir la même désignation.
C
QQ
OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL
376315150 892498299
RETURNING THE APPLIANCE TO THE CUSTOMER.
technician.
LEAKAGE CURRENT CHECK
Measure leakage current to a known earth ground 2. PRODUCT SAFETY NOTICE
(water pipe, conduit, etc.) by connecting a leakage Many electrical and mechanical parts in the appliance
D current tester such as Simpson Model 229-2 or have special safety related characteristics. These are
equivalent between the earth ground and all exposed often not evident from visual inspection nor the protection
metal parts of the appliance (input/output terminals, afforded by them necessarily can be obtained by using
screwheads, metal overlays, control shaft, etc.). Plug replacement components rated for voltage, wattage, etc.
the AC line cord of the appliance directly into a 120V Replacement parts which have these special safety
AC 60 Hz outlet and turn the AC power switch on. Any characteristics are identified in this Service Manual.
current measured must not exceed 0.5 mA. Electrical components having such features are
identified by marking with a > on the schematics and on
the parts list in this Service Manual.
Reading should The use of a substitute replacement component which
Leakage not be above does not have the same safety characteristics as the
Device current 0.5 mA
E PIONEER recommended replacement one, shown in the
under tester
test parts list in this Service Manual, may create shock, fire,
Test all or other hazards.
exposed metal
surfaces Product Safety is continuously under review and new
instructions are issued from time to time. For the latest
information, always consult the current PIONEER Service
Also test with Manual. A subscription to, or additional copies of,
AC Leakage Test
F
.
2 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
[Important Check Points for Good Servicing]
In this manual, procedures that must be performed during repairs are marked with the below symbol.
Please be sure to confirm and follow these procedures.
1. Product safety
A
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by
following the safety instructions described in this manual.
TEL
3 Make sure the soldering of repaired locations is properly performed.
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
13942296513
13942296513
4 Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
C
6 Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc.
QQ
QQ
7 Make sure screws and soldering scraps do not remain inside the product.
376315150 892498299
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
Use grease and adhesives that are equal to the specified substance.
Make sure the proper amount is applied.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
x iao y u163. co m
cleaning should be performed to restore their performances.
.
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be
installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
F
VSX-820-K 3
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
CONTENTS
QQ 376315150 892498299
SAFETY INFORMATION ..........................................................................................................................................................2
1. SERVICE PRECAUTIONS ....................................................................................................................................................5
A 1.1 NOTES ON SOLDERING ...............................................................................................................................................5
1.2 CAUTION ........................................................................................................................................................................5
2. SPECIFICATIONS .................................................................................................................................................................6
2.1 SPECIFICATIONS...........................................................................................................................................................6
2.2 PANEL FACILITIES .........................................................................................................................................................8
3. BASIC ITEMS FOR SERVICE.............................................................................................................................................16
3.1 CHECK POINTS AFTER SERVICING..........................................................................................................................16
3.2 PCB LOCATIONS .........................................................................................................................................................17
3.3 JIGS LIST......................................................................................................................................................................19
4. BLOCK DIAGRAM...............................................................................................................................................................20
4.1 OVERALL WIRING DIAGRAM......................................................................................................................................20
4.2 OVERALL BLOCK DIAGRAM .......................................................................................................................................22
B 4.3 POWER SUPPLY and MAIN UCOM BLOCK DIAGRAM ..............................................................................................24
5. DIAGNOSIS.........................................................................................................................................................................26
5.1 DIAGNOSIS FLOWCHART...........................................................................................................................................26
TEL
TEL
5.2 ADAPTER ERROR MESSAGE.....................................................................................................................................42
5.3 DETECTION CIRCUIT..................................................................................................................................................43
6. SERVICE MODE .................................................................................................................................................................46
13942296513
13942296513
6.1 SERVICE MODE...........................................................................................................................................................46
7. DISASSEMBLY....................................................................................................................................................................49
8. EACH SETTING AND ADJUSTMENT ................................................................................................................................59
8.1 HOW TO UPDATE FIRMWARE ....................................................................................................................................59
8.2 IDLE CURRENT ADJUSTMENT ..................................................................................................................................62
9. EXPLODED VIEWS AND PARTS LIST ...............................................................................................................................64
C
9.1 PACKING SECTION......................................................................................................................................................64
9.2 EXTERIOR SECTION (VSX-820-K) .............................................................................................................................66
9.3 EXTERIOR SECTION (VSX-520-K) .............................................................................................................................70
10. SCHEMATIC DIAGRAM ....................................................................................................................................................74
QQ
QQ
QQ 3763 1515 0 89 2498 299
10.1 INPUT ASSY...............................................................................................................................................................74
TEL 13942296513
10.2 AMP ASSY..................................................................................................................................................................76
376315150 892498299
376315150 892498299
10.3 SPEAKER, HEADPHONE and MIC ASSYS...............................................................................................................78
10.4 PORTABLE, PT, HP_GUIDE, CNT1, CNT2, GUIDE_L and GUIDE_R ASSYS..........................................................79
10.5 VIDEO ASSY ..............................................................................................................................................................80
10.6 F-VIDEO, FRONT and FUNCTION ASSYS................................................................................................................82
10.7 MAIN and REG ASSYS ..............................................................................................................................................84
D
10.8 HDMI ASSY ................................................................................................................................................................86
10.9 DSP ASSY (1/2)..........................................................................................................................................................88
10.10 DSP ASSY (2/2)........................................................................................................................................................90
10.11 USB ASSY (VSX-820-K ONLY).................................................................................................................................92
10.12 BT ASSY ...................................................................................................................................................................94
11. PCB CONNECTION DIAGRAM ........................................................................................................................................95
11.1 INPUT ASSY...............................................................................................................................................................96
11.2 AMP ASSY..................................................................................................................................................................98
11.3 SPEAKER, HEADPHONE, MIC and PORTABLE ASSYS ........................................................................................100
11.4 PT, HP_GUIDE, CNT1, CNT2, GUIDE_L and GUIDE_R ASSYS ............................................................................102
11.5 VIDEO ASSY ............................................................................................................................................................104
11.6 F-VIDEO, FRONT and FNCTION ASSYS ................................................................................................................106
E 11.7 MAIN and REG ASSYS ............................................................................................................................................110
11.8 HDMI ASSY ..............................................................................................................................................................114
11.9 DSP ASSY ................................................................................................................................................................116
11.10 USB ASSY (VSX-820-K ONLY)...............................................................................................................................118
11.11 BT ASSY .................................................................................................................................................................120
12. PCB PARTS LIST ............................................................................................................................................................121
F
www . x iao y u163. co m
4 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
1. SERVICE PRECAUTIONS
QQ 376315150 892498299
1.1 NOTES ON SOLDERING
• For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. A
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
• Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 ºC.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 ºC in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden). B
TEL
• Parts numbers of lead-free solder:
GYP1006 1.0 in dia.
GYP1007 0.6 in dia.
13942296513
13942296513
GYP1008 0.3 in dia.
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
1.2 CAUTION
D
• Discharging
For more detail, please refer to “7. DISASSEMBLY - 1. Discharging”.
VSX-820-K 5
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
2. SPECIFICATIONS
QQ 376315150 892498299
2.1 SPECIFICATIONS
2.1.1 VSX-820-K
A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
E
Accessories
F
www . x iao y u163. co m
Microphone (for Auto MCACC setup)
(M040000300200-IL)
iPod cable
(L308102013010-IL)
Dry cell batteries
(AAA size IEC R03) x2
Remote control
(8300758300010-IL)
6 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
2.1.2 VSX-520-K
QQ 376315150 892498299 A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
E
Accessories
VSX-820-K 7
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
2.2.1 VSX-820-K
A
Front panel
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
F
www . x iao y u163. co m
8 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Display A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 9
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Remote control
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
F
www . x iao y u163. co m
10 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299 A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 11
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
2.2.2 VSX-520-K
QQ 376315150 892498299
Front panel
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
F
www . x iao y u163. co m
12 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Display A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 13
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Remote control
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
F
www . x iao y u163. co m
14 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299 A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 15
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
3.1 CHECK POINTS AFTER SERVICING
A
TEL
Check surround playback. Each channel audio and operations must be normal.
4 (Select Surround mode and check the multichannel operations
via the DSP circuit.)
13942296513
13942296513
Check the video outputs. Video and operations must be normal.
5 (Connect with a DVD player.)
Check the tuner (AM and FM) operations. Audio and operations must be normal.
6
C Check the sound from headphone output. Sound must be normal, without noise.
7
Check the appearance of the product. No scratches or dirt on its appearance after receiving it for
8 service.
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
See the table below for the items to be checked regarding video and audio.
Item to be checked regarding video Item to be checked regarding audio
Block noise Distortion
Horizontal noise Noise
Flicker Volume too low
Disturbed image (video jumpiness) Volume too high
Too dark Volume fluctuating
Too bright Sound interrupted
E Mottled color
F
www . x iao y u163. co m
16 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
3.2.1 VSX-820-K
A
SPEAKER ASSY C V BT ASSY J CNT2 ASSY
S HDMI ASSY
VIDEO ASSY M
T DSP ASSY
I CNT1 ASSY
A INPUT ASSY
MAIN ASSY Q G PT ASSY B
TEL
B AMP ASSY
GUIDE_L ASSY K L GUIDE_R ASSY
13942296513
13942296513
HEADPHONE ASSY D N F-VIDEO ASSY
E MIC ASSY
FUNCTION ASSY P C
QQ
QQ
TEL 13942296513 FRONT ASSY QQ 3763 1515 0 89 2498 299
O U USB ASSY
376315150 892498299
376315150 892498299
D
NOTES: - Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.
- The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Mark No. Description Part No. Mark No. Description Part No.
LIST OF ASSEMBLIES
NSP 1..MAIN ASSY 7025HK0916010-IL NSP 1..INPUT ASSY 7025HK0916012-IL
2..MAIN ASSY 7028069111010-IL 2..INPUT ASSY 7028069131010-IL
2..PT ASSY 7028069112010-IL
2..CNT2 ASSY 7028069113010-IL NSP 1..SPEAKER ASSY 7025HK0916014-IL
2..HEADPHONE ASSY 7028069114010-IL 2..SPEAKER ASSY 7028069151010-IL E
.
2..FRONT ASSY 7028069121010-IL 2..BT ASSY 7028069181010-IL
F
2..FUNCTION ASSY 7028069122010-IL
2..F-VIDEO ASSY 7028069123010-IL NSP 1..AMP ASSY 7025HK0916019-IL
2..AMP ASSY 7028067523010-IL
VSX-820-K 17
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
3.2.2 VSX-520-K
S HDMI ASSY
VIDEO ASSY M
T DSP ASSY
I CNT1 ASSY
A INPUT ASSY
B MAIN ASSY Q G PT ASSY
TEL
B AMP ASSY
GUIDE_L ASSY K L GUIDE_R ASSY
13942296513
13942296513
HEADPHONE ASSY D
F PORTABLE ASSY
C FUNCTION ASSY P
QQ
QQ
TEL 13942296513 O QQ 3763 1515 0 89 2498 299
FRONT ASSY
376315150 892498299
376315150 892498299
D
NOTES: - Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.
- The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Mark No. Description Part No. Mark No. Description Part No.
LIST OF ASSEMBLIES
NSP 1..MAIN ASSY 7025HK0915010-IL NSP 1..INPUT ASSY 7025HK0915012-IL
2..MAIN ASSY 7028069111060-IL 2..INPUT ASSY 7028069131020-IL
E 2..PT ASSY 7028069112010-IL
2..CNT2 ASSY 7028069113010-IL NSP 1..SPEAKER ASSY 7025HK0915014-IL
2..HEADPHONE ASSY 7028069114010-IL 2..SPEAKER ASSY 7028069151030-IL
.
F
NSP 1..FRONT ASSY 7025HK0915011-IL
2..FRONT ASSY 7028069121020-IL NSP 1..AMP ASSY 7025HK0916019-IL
2..FUNCTION ASSY 7028069122010-IL 2..AMP ASSY 7028067523010-IL
18 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Jigs List
Jig Name
10P extension jig cable
Part No.
GGD1628
Remarks
Diagnosis (AMP Assy ↔ INPUT Assy)
A
B
TEL
TEL
Lubricants and Glues List
13942296513
13942296513
Name Part No. Remarks
Silicon grease GEM1057 Refer to “9.2 EXTERIOR SECTION (VSX-820-K)”
and “9.3 EXTERIOR SECTION (VSX-520-K)”.
Silicon adhesive GYA1011 (KE40RTV-W) Refer to “9.2 EXTERIOR SECTION (VSX-820-K)”
and “9.3 EXTERIOR SECTION (VSX-520-K)”. C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 19
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
4. BLOCK DIAGRAM
QQ 376315150 892498299
4.1 OVERALL WIRING DIAGRAM
A
VSX-820-K ONLY
M
N VIDEO ASSY
F-VIDEO ASSY (7028069141010-IL: VSX-820-K)
(7028069123010-IL) (7028069141040-IL: VSX-520-K)
1,2,3 PIN CN1001 CP122
CN701 4,5 PIN
CN1002 CP123
CP110
Q
TEL
TEL
CP804 VS
MAIN ASSY
CN807 CP117
(7028069111010-IL: VSX-820-K)
13942296513
13942296513
(7028069111060-IL: VSX-520-K)
CN803 CP118
C
CN806 CP120
CNT1 ASSY
QQ
QQ
(7028069119010-IL)
TEL
A 13942296513 QQ 3763G1515 0 89 2498 299
CN121B
CN121A
I
376315150 892498299
376315150 892498299
CP805 CP121
INPUT ASSY
(7028069131010-IL: PT ASSY C
VSX-820-K) (7028069112010-IL)
D (7028069131020-IL: BT ASSY CN201 CN202
VSX-520-K) (7028069181010-IL)
CP502
CP501
CN502
V CN501 CP125 CP126 F
CN601
CP128 VSX-820-K
CP801
H CP107
ONLY
CN106 CN104 CN103 CP301 CP109
E
CP802
HP_GUIDE ASSY
(7028069115010-IL) AC CORD
OR INLET
VSX-820-K
CN707 ONLY CN202 CP405 CP403 CP402
CN201
x ao y u163. co m
CP203 CN401 CP404
E MIC ASSY
www
(7028069116010-IL) B C
VSX-520-K ONLY
AMP ASSY SPEAKER ASSY H
F.PORTABLE
i ASSY
F
(7028067523010-IL) (7028069151010-IL: VSX-820-K) (
CN703 (7028069151030-IL: VSX-520-K)
(702806911A010-IL)
20 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
- When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST".
- The > mark found on some component parts indicates the importance of the safety factor of the part.
-
Therefore, when replacing, be sure to use parts of identical designation.
: The power supply is shown with the marked box.
A
J K
CP111 CN702
S CNT2 ASSY GUIDE_L ASSY
HDMI ASSY (7028069113010-IL) (7028069117010-IL)
(7028069191010-IL:
B
CP112 CN701
VSX-820-K) CP703 CN703A
(7028069191020-IL:
TEL
TEL
VSX-520-K)
VSX-820-K
ONLY L
X-820-K)
13942296513
13942296513
CP200 CN200
T T 1/2, T 2/2 GUIDE_R ASSY
X-520-K) (7028069118010-IL)
CP114 CN202
DSP ASSY
CN205 UPGRADE
(7028069161010-IL:
VSX-820-K) C
CP115 CN203
(7028069161020-IL: VSX-820-K ONLY
VSX-520-K) CP105
CP116 CN204
QQ
QQ
TEL 13942296513CP105
QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
CN207B CN207A
R
REG ASSY CN807 CN805
(7028069162010-IL) U D
USB ASSY
CP704
O CN802 (7028069171010-IL)
FPC101 CP802
FRONT ASSY
(7028069121010-IL: VSX-820-K)
CP303 CP703
(7028069121020-IL: VSX-520-K)
CP702 CN706
CP101
VSX-820-K 21
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
BD
(VSX-820-K ONLY)
S HDMI ASSY U USB
ASSY
MAIN ASSY
DVD(VSX-820-K)
BD(VSX-520-K)
TV/SAT(VSX-820-K)
DVD(VSX-520-K)
DVR/VCR(VSX-820-K)
TV/SAT(VSX-520-K)
73
HDMI OUT
76
67
71
69
B 65
59
63
VSX-820-K 61
ONLY 79
F_AUX L
86
84
TEL
TEL
82
72
75
66
70
VSX-820-K 68
13942296513
13942296513
ONLY 64
58
62
VSX-820-K 60
ONLY 78
F_AUX R
85
83
81
Q MAIN ASSY
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K
E MIC ASSY ONLY
V
INPUT ASSY
BT ASSY
F PORTABLE ASSY
F
.
INPUT ASSY
VSX-520-K ONLY
INPUT ASSY
22 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
VSX-820-K
ONLY O
FRONT ASSY
A
MAIN ASSY
VSX-520-K
ONLY B AMP ASSY
A INPUT ASSY
MAIN ASSY
B
TEL
TEL
VSX-820-K
ONLY
13942296513
13942296513
C
C
SPEAKER
ASSY
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
G
PT ASSY
VSX-820-K E
ONLY
VIDEO INPUT
ASSY ASSY
SPEAKER
ASSY
www . co m
N F-VIDEO ASSY D HEADPHONE ASSY
x iao y u163
VSX-820-K ONLY
.
The > mark found on some component parts
indicates the importance of the safety factor of the part. F
Therefore, when replacing, be sure to use parts
of identical designation.
M VIDEO ASSY
VSX-820-K 23
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Q MAIN ASSY
S1(AMP B+/B-)
B
S2(+12V,-12V)
TEL
TEL
13942296513
13942296513
MAIN TRANS
C
S3(DSP, HDMI)
QQ
QQ
R
TEL 13942296513 QQ 3763 1515 0 89 2498REG
299
376315150 892498299
376315150 892498299
ASSY
AC CORD S4(DIR/CODEC, HDMI, USB)
VSX-820-K
ONLY
S4(FLT)
SUB TRANS
F
www . x iao y u163. co m
24 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
INPUT ASSY
B
TEL
TEL
13942296513
13942296513
VSX-820-K ONLY
C
QQ
QQ
R
TEREG
L 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
ASSY
www . x iao y u163. co m The > mark found on some component parts
indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts
of identical designation.
F
VSX-820-K 25
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
5. DIAGNOSIS
QQ 376315150 892498299
5.1 DIAGNOSIS FLOWCHART
A
[1] DSP TROUBLESHOOTING
TEL
Is the
voltage of 1.2 V No
Replace REG101 and REG102.
output?
Step 1: BtoB connector, wire
13942296513
13942296513
CN200,CN202,CN203, BtoB connector, wire Yes
CN204,CP105
To Step 4 *The DSP IC CORE power of DSP Assy
QQ
To Step 2
in case of DSP JIG B'D use.
376315150 892498299
a 24.576 MHz
output? Replace XTAL101.
Yes
Step 2: Regulator IC IC102 (Pin 17) XMCK
Yes To Step 5
Is the No
voltage of 3.3 V Replace REG103.
E output?
ZD200 cathode
x iao y u163. co m
voltage of 2.5 V
www
output? and IC106.
Yes
.
F To Step 3 *The IC106 power of DSP Assy
26 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Step 5: DIR
Check that the S/PDIF signal is output.
Check that changes by pulling out and inserting the digital input lines.
A
Can Switch
TEL
TEL
observe the No Check the path to pins 4, 6 of
digital signal IC110 or replace IC110.
? IC106 (Pin 4) DAI_MCK (Master clock)
(0 V ⇔ 3.3 V)
Yes
13942296513
13942296513
IC109 (Pin 67) COAX Is there No
a master clock
output?
(0 V ⇔ 2.5 V)
Can
observe the No Check the path to pins 10-13 Yes
digital signal of IC110 or replace IC110.
? IC106 (Pin 7) DAI_LRCK (LR clock) C
(0 V ⇔ 3.3 V)
Yes
VSX-820-K ONLY
Is there No
Check that it changes in the Playback and Pause modes of a LR clock
QQ
QQ
the USB (iPod). output?
(0 V ⇔ 2.5 V)
TEL 13942296513
IC109 (Pin 71) From USB Assy
QQ 3763 1515 0 89 2498 299
Yes
376315150 892498299
376315150 892498299
IC106 (Pin 9) DAI_BCK (Bit clock)
Can
observe the No
Check the path to CP105 connector. Is there
digital signal No
? No a bit clock
(0 V ⇔ 3.3 V) output?
Yes Check the USB Assy. (0 V ⇔ 2.5 V) D
Yes
Check that the data and clock signals are output.
IC109 (Pin 16) DIR_LRCK (LR clock) Replace IC106. *IC106 Pin 1
E
0 V : DIR
3.3 V : HDMI
Is there No To Step 6
a LR clock Replace IC109.
output?
(0 V ⇔ 3.3 V)
Yes
IC109 (Pin 14) DIR_SDTO (Data)
.
(0 V ⇔ 3.3 V)
Yes F
VSX-820-K 27
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Step 6: DSP output (digital)
Digital output of each CH when inputting the digital signal with audio.
Is there No
a bit clock
input?
(0 V ⇔ 3.3 V)
Yes
IC109 (Pin 19) DSP_LRCK (LR clock)
B
Is there No
a LR clock
TEL
TEL
output?
(0 V ⇔ 3.3 V)
Yes
13942296513
13942296513
IC109 (Pin 28) Front L/R data
Is there No
a data input?
(0 V ⇔ 3.3 V)
C Yes
IC109 (Pin 27) Surround L/R data
QQ
QQ
Is there No
376315150 892498299
Yes
IC109 (Pin 26) Center/LFE data
Is there No
D a data input?
(0 V ⇔ 3.3 V)
Yes
IC109 (Pin 25) Surround back L/R data
Is there No
a data input?
(0 V ⇔ 3.3 V)
Yes
Check the path between IC102
and data & address lines.
E SDRAM (IC100), FLASH ROM
(IC101)
To Step 7
F
www . x iao y u163. co m
28 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Step 7: Codec output (analog)
Analog output of each CH when inputting the digital signal with audio.
A
TEL
a audio signal Replace IC109.
output?
13942296513
IC109 (Pin 45) Surround R out
Yes
Is there No IC109 (Pin 45) Surround R out
a audio signal Replace IC109.
output?
No C
Yes Is the output Replace IC109.
2.5 V fixing?
IC109 (Pin 43) Surround L out
Yes
QQ
QQ
QQ 3763 1515 0 89 2498 299
Is there No IC109 (Pin 43) Surround L out
TEL 13942296513
a audio signal Replace IC109.
output?
376315150 892498299
376315150 892498299
Yes Is the output No
Replace IC109.
2.5 V fixing?
IC109 (Pin 41) Center out
Yes
Is there No IC109 (Pin 41) Center out
Replace IC109. D
a audio signal
output?
VSX-820-K 29
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
[2] HDMI TROUBLESHOOTING
1. Causes for noncompletion of HDMI authentication between the source equipment and this unit
(the HDMI indicator is unlit or flashes)
NG
TEL
TEL
Connect the source equipment OK
(player) to the Sink equipment Repare the Receiver.
13942296513
13942296513
(monitor) directly.
NG
OK
Replace the Player. Repare the Player.
C
NG
OK
QQ
QQ
Replace the Monitor. Repare the Monitor.
376315150 892498299
D
HDMI Troubleshooting
Step 0: Preliminary confirmation Step 1: Connect the HDMI equipment
Confirm the following items before checking Source equipment:
Connect a DVD player to BD or DVD or TV or DVR.
Do
screws of COAX No
Tighten screws securely. Sink equipment:
jack securely
tighten? Connect a TV to HDMI OUT.
Yes
POWER ON
E To Step 1
.
HDMI 3: TV/SAT HDMI 3: TV/SAT
F
HDMI 4: DVR/VCR
To Step 2
30 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Step 2: Power supply
CN701 (Pin 1) SUB_ON
Is the voltage No
Diagnose the MAIN Assy.
0 to 3.3 V?
No Check the parts and patterns in
Yes Is the voltage
3.3 V? the path.
TEL
Is the voltage No Is IC704 No Replace
Yes abnormally IC704.
1.8 V? hot?
CN701 (Pin 12) HDMI_5V
13942296513
13942296513
Yes Yes
Yes
IC701 (Pin 3) HDMI 3.3V C
CN701 (Pins 13, 14) HDMI_3.3V
QQ
No 3.3 V? the path.
Is the voltage
TEL 13942296513
3.3 V?
Yes
376315150 892498299
376315150 892498299
Yes
IC701 (Pin 2) HDMI 1.2V
Q711 (collector) SUB MICOM 3.3V
Is Q714 No E
collector voltage Replace Q714.
0 V? (base is 3.3 V)
Yes
VSX-820-K 31
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Step 3: Diagnosis
Each data lines confirmation checks it after standby OFF/ON.
Is the voltage No
Diagnose the MAIN Assy.
0 to 3.3 V? No
Is the voltage Check the parts and patterns in
0 to 3.3 V? the path of pin 87 of IC706.
Yes
Yes
B CN701 (Pin 4) SUB_PDN
TEL
Is the voltage No
Diagnose the MAIN Assy.
0 to 3.3 V?
Is there a data No Check the parts and patterns in
0 to 3.3 V? the path of pin 89 of IC706.
Yes
13942296513
13942296513
CN701 (Pin 3) MAIN_IRQ Yes
To Step 4
Is there No
a data input? Diagnose the MAIN Assy.
(0 to 3.3 V)
C
Yes
QQ
QQ 3763 1515 0 89 2498 299
IC706 (Pin 15)
TEL 13942296513
Is there
a data output?
No Check the parts and patterns in
376315150 892498299
376315150 892498299
(0 to 3.3 V) the path of IC706.
Is there No
a 12 MHz Replace IC706 or X702.
Yes output?
D
Is there IC706 (Pin 13)
No
a data input? Diagnose the MAIN Assy.
(0 to 3.3 V)
Is there No Check the path to pin13 of IC706.
Yes a 12 MHz
output? Replace IC706.
Yes
F
. To Step 5
32 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Step 5: IN/OUTPUT Diagnosis (VSX-820-K)
Yes Yes
* When connected the equipment to IN2(DVD); * When connected the equipment to IN2(DVD);
JACK703 (Pin 18) +5V_R2 JACK704 (Pin 18) +5V_R2
B
TEL
5 V? is failure, replace JACK703. 5 V? is failure, replace JACK704.
Yes Yes
* When connected the equipment to IN3(TV/SAT); * When connected the equipment to IN3(TV/SAT);
13942296513
13942296513
JACK704 (Pin 18) +5V_R1 JACK705 (Pin 18) +5V_R1
C
Yes Yes
* When connected the equipment to IN4(DVR/VCR);
JACK705 (Pin 18) +5V_R0 To Step 6
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
No Check the JACK705. If JACK705
Is the voltage
5 V? is failure, replace JACK705.
376315150 892498299
376315150 892498299
Yes
To Step 6
VSX-820-K 33
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Step 6: Hot plug detect (VSX-820-K)
JACK702 (Pin 19) HPD_SINK
Step 6: Hot plug detect (VSX-520-K)
JACK702 (Pin 19) HPD_SINK
Is the voltage No Check the JACK702. If JACK702 Is the voltage No Check the JACK702. If JACK702
5 V? is failure, replace JACK702. 5 V? is failure, replace JACK702.
Yes Yes
* When connected the equipment to IN1 (BD); * When connected the equipment to IN1 (BD);
JACK701 (Pin 19) HPD3 JACK703 (Pin 19) HPD2
B
Is the Check the JACK701 and IC703. Is the
voltage 5 V No No Check the JACK703 and IC703.
If JACK701 or IC703 is failure, voltage 5 V If JACK703 or IC703 is failure,
when selecting when selecting
replace JACK701 or IC703.
TEL
TEL
IN1? IN1? replace JACK703 or IC703.
Yes Yes
* When connected the equipment to IN2 (DVD); * When connected the equipment to IN2 (DVD);
13942296513
13942296513
JACK703 (Pin 19) HPD2 JACK704 (Pin 19) HPD1
Is the Check the JACK703 and IC703. Is the Check the JACK704 and IC703.
voltage 5 V No voltage 5 V No
If JACK703 or IC703 is failure, If JACK704 or IC703 is failure,
when selecting when selecting
IN2? replace JACK703 or IC703. IN2? replace JACK704 or IC703.
C
Yes Yes
* When connected the equipment to IN3 (TV/SAT); * When connected the equipment to IN3 (TV/SAT);
JACK704 (Pin 19) HPD1 JACK705 (Pin 19) HPD0
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
Is the Check the JACK704 and IC703. Is the Check the JACK705 and IC703.
voltage 5 V No voltage 5 V No
If JACK704 or IC703 is failure, If JACK705 or IC703 is failure,
376315150 892498299
376315150 892498299
when selecting when selecting
IN3? replace JACK704 or IC703. IN3? replace JACK705 or IC703.
Yes Yes
* When connected the equipment to IN4 (DVR/VCR);
To Step 7
JACK705 (Pin 19) HPD0
D
Is the Check the JACK705 and IC703.
voltage 5 V No
If JACK705 or IC703 is failure,
when selecting
IN4? replace JACK705 or IC703.
Yes
To Step 7
F
www . x iao y u163. co m
34 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Step 7: SDA /SCL (VSX-820-K)
TEL
constant period
(0 to 5 V) replace JACK702 or IC702. Is
?
Yes
there a same No Check the IC702 and JACK704.
signal as IC702-pin 49 If IC702 or JACK704 is failure,
13942296513
13942296513
when selecting replace IC702 or JACK704.
IC702 (Pin 49) SDA_SINK IN3?
(0 to 5 V)
Yes
Is
there a same Check the IC702 and IC703. IC703 (Pin 35) SCL1 (HDMI IN3 (TV/SAT))
No
signal as IC703-pin 24 If IC702 or IC703 is failure,
(0 to 3.3V) replace IC702 or IC703.
? Is C
Yes there a same No Check the IC702 and JACK704.
signal as IC702-pin 48 If IC702 or JACK704 is failure,
when selecting replace IC702 or JACK704.
IC702 (Pin 48) SCL_SINK IN3?
(0 to 5 V)
QQ
QQ
Yes
376315150 892498299
IC703 (Pin 32) SDA0 (HDMI IN4 (DVR/VCR))
(0 to 3.3V) replace IC702 or IC703.
?
Yes Is
* When connected the equipment to IN1(BD); there a same No Check the IC702 and JACK705.
signal as IC702-pin 49 If IC702 or JACK705 is failure,
IC703 (Pin 44) SDA3 (HDMI IN1(BD)) when selecting replace IC702 or JACK705.
IN4? D
(0 to 5 V)
Yes
Is
there a same No Check the IC702 and JACK701.
signal as IC702-pin 49 IC703 (Pin 31) SCL0 (HDMI IN4 (DVR/VCR))
If IC702 or JACK701 is failure,
when selecting replace IC702 or JACK701.
IN1?
(0 to 5 V) Is
Yes there a same No Check the IC702 and JACK705.
signal as IC702-pin 48 If IC702 or JACK705 is failure,
IC703 (Pin 43) SCL3 (HDMI IN1(BD)) when selecting replace IC702 or JACK705.
IN4?
(0 to 5 V)
Yes
Is
there a same No Check the IC702 and JACK701.
signal as IC702-pin 48 If IC702 or JACK701 is failure,
when selecting To Step 8 E
replace IC702 or JACK701.
IN1?
(0 to 5 V)
Yes
* When connected the equipment to IN2 (DVD):
IC703 (Pin 40) SDA2 (HDMI IN2 (DVD))
Is
x iao y u163. co m
No Check the IC702 and JACK703.
www
there a same
signal as IC702-pin 49 If IC702 or JACK703 is failure,
when selecting replace IC702 or JACK703.
IN2?
Yes
. F
VSX-820-K 35
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Step 7: SDA /SCL (VSX-520-K)
TEL
constant period
(0 to 5 V) replace JACK702 or IC702.
? Is
Yes there a same No Check the IC702 and JACK705.
signal as IC702-pin 49 If IC702 or JACK705 is failure,
13942296513
13942296513
when selecting replace IC702 or JACK705.
IC702 (Pin 49) SDA_SINK IN3?
(0 to 5 V)
Yes
Is
there a same Check the IC702 and IC703. IC703 (Pin 31) SCL0 (HDMI IN3 (TV/SAT))
No
signal as IC703-pin 24 If IC702 or IC703 is failure,
(0 to 3.3V) replace IC702 or IC703.
C ? Is
Yes there a same No Check the IC702 and JACK705.
signal as IC702-pin 48 If IC702 or JACK705 is failure,
IC702 (Pin 48) SCL_SINK when selecting replace IC702 or JACK705.
IN3?
(0 to 5 V)
QQ
QQ
Yes
376315150 892498299
(0 to 3.3V) replace IC702 or IC703. To Step 8
?
Yes
* When connected the equipment to IN1 (BD):
IC703 (Pin 40) SDA2 (HDMI IN1 (BD))
D
Is
there a same No Check the IC702 and JACK703.
signal as IC702-pin 49 If IC702 or JACK703 is failure, Step 8: TMDS
when selecting replace IC702 or JACK703.
IN1?
IC702 (Pins 30,31,33,34,36,37,39,40) TMDS OUTPUT
Yes
IC703 (Pin 39) SCL2 (HDMI IN1 (BD)) Check the IC702 or IC703.
Are there
signals(approx. 0.5 No
If IC702 or IC703 is failure,
Vp-p) in all replace IC702 or IC703.
Is lines?
there a same No Check the IC702 and JACK703.
signal as IC702-pin 48 If IC702 or JACK703 is failure, Yes
E when selecting replace IC702 or JACK703.
IN1? End
(0 to 5 V)
Yes
* When connected the equipment to IN2 (DVD):
IC703 (Pin 36) SDA1 (HDMI IN2 (DVD))
Is
No Check the IC702 and JACK704.
x iao y u163. co m
there a same
www
signal as IC702-pin 49 If IC702 or JACK704 is failure,
when selecting replace IC702 or JACK704.
IN2?
(0 to 5 V)
Yes
F
.
36 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
[3] USB iPod TROUBLESHOOTING (VSX-820-K ONLY)
iPod Error Message
When the abnormality occurred, the error messages are indicated.
A
[Procedure]
Disconnect a connector once, then connect a I / U ERR1
connector surely again after the main menu of the
iPod was displayed. B
Nevertheless, reset the iPod when the iPod does
not operate normally.
TEL
TEL
Error 2
Generation Error (in the Type 1 operation only) i P o d
When the non-support model for the iPod Mode
i Po d / U SB E r r o r 2
Type 1 was connected.
13942296513
13942296513
When the non-support function will be executed.
When a version of the iPod software is old. I / U ERR2
[Procedure]
Change the iPod Mode to Type2.
Update the iPod software to the newest version.
C
Error 3
i P o d
Loading Error
When there is no response from the iPod.
QQ
QQ
i Po d / U SB E r r o r 3
TEL 13942296513
I / U ERR3
The power is shut off once, then the unit back on.
Reset the iPod.
376315150 892498299
376315150 892498299
Update the iPod software to the newest version.
Error 4
OverHeat Error i P o d
D
i Po d / U SB E r r o r 4
I / U ERR4
No Track i P o d
VSX-820-K 37
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
iPod Troubleshooting
TEL
The output and GND may be
short-circuited. Check the path
between them.
13942296513
13942296513
Step 1: Power supply
IC805 (pin 5) 5 V input
CN807 (pins 1, 3) 5 V input
Is
the voltage No Is pin 4 No
C Is there any (EN) of IC805
Is No No 5 V input?
the voltage loose connection Low?
5V? CP105 of MAIN
Assy? Yes
Yes Is pin 3 No
QQ
QQ
Yes Yes Check the MAIN (OC) of IC805
376315150 892498299
To STEP 1
Replace IC805.
REG2 (pin 3) (to chassis)
Is No
the voltage of Check the patterns in Check the parts and
D the path. patterns in the path
5 V input?
(JACK801).
Yes
F
Yes .
38 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Step 2: Operation of USB Media control IC
Is Check
Is there No CP802 pins 1, 2 No No Check the path to
a 12 MHz CP105, CN802 of
(RESET, RDY) FRONT and MAIN MAIN Assy.
output? high? Assy.
Yes Yes
Yes
TEL
Do
No
13942296513
13942296513
USB_RX and USB_TX USB_RX and USB_TX should
communication with be high during operation.
main micom? Check the pattern in the path of
the FRONT and MAIN Assys.
Yes
QQ
waveform during normal Fig. D+ Fig. D-
376315150 892498299
IC801, etc.
Are Yes
there the waveforms Operation of IC801 is OK.
like figure? To STEP 3
D
IC801 (pin 44) -> IC803 (pin 38) Initial communication [SDCLK]
After
turning the power DATA and ADDRESS lines
on and several seconds No between SDRAM (IC803),
later, does SDCLK change FLASH ROM (IC802) and IC801
12 MHz to 80 MHz? are may not be connected.
Yes
E
Operation of IC801 is OK.
To STEP 3
VSX-820-K 39
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Step 3: Operation of iPod (Authentication process)
IC804 (pins 12, 13) SCL, SDA (I2C between IC801 and IC804)
TEL
Operation of IC804 is OK.
To STEP 4
13942296513
13942296513
Step 4 Audio Out check
C
CN805 (pin 1) S/PDIF output
QQ
QQ
Is there Check the
TEL 13942296513
a S/PDIF signal path between IC801 Replace IC801.
? (pin 105)
376315150 892498299
376315150 892498299
Yes Yes
Check the parts and pattern
of CN805 and IC801.
D
Refer to the [1] DSP
TROUBLESHOOTING.
F
www . x iao y u163. co m
40 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
[4] BT (BlueTooth) TROUBLESHOOTING
Step 0: Preliminary confirmation
Confirm the following items before checking. CN500 (pin 17) 5 V input
A
Yes Yes
To STEP 1 B
To STEP 3
TEL
Step 1: BT_DET
TEL
CP501 (pin 2) BT_DET Step 3: BT_DET
13942296513
13942296513
CP501 (pin 2) BT_DET
Is the voltage No Check the patterns in
0 V? the path and MAIN Assy. Is
the voltage No Check the patterns in
0.7 V to 12 V the path and MAIN Assy.
Yes ?
C
To STEP 2 Yes
QQ
CP501 (pin 4) 5 V input
376315150 892498299
Is No Is there any No
the voltage loose connection Step 4: Communicaion
5V? CN501 of MAIN
Assy? CP501 (pins 6,7) BT_RXD, BT_TXD
Check the patterns
Yes Yes inthe path and
MAIN Assy. Do
BT_RXD and No BT_RXD and BT_TXD should D
To STEP 2 BT_TXD commu- be high during operation.
nicate with the main
IC500 (pin 1) (to chassis) UCOM? Check the patterns in the path
and MAIN Assy.
Yes
Is No
the voltage of Check the patterns in
To STEP 5
5 V input? the path.
Yes
x iao y u163. co m
(BT_ON/OFF/CE) Check the INPUT Assy.
www
0 V?
Check the patterns
0V in the path and
replace Q500.
VSX-820-K 41
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Functional Name
Adapter port overcurrent detection
Outline
When the BT adapter is inserted in Adapter port, turn off the power of the Adapter port forcibly when it detects an
overcurrent. And display ERROR state in FL.
Basic Operation
Front Key Sequence Icon Display LED Display
Change Character Display Time (sec.) (FL)
B
1 2 3 4 5 6 7 8 1 2
When the overcurrent is The display continues
ADP ERR
TEL
TEL
detected until the power is
*1 turned off.
13942296513
off then back on again, and it becomes
the normal operation if normal.
*1 Return the "ADP ERR" display to the normal display if you change it into other FUNCTION only in the
APAPTER PORT FUNCTION.
Also display "ADP ERR" if the APAPTER PORT FUNCTION is ERROR state.
C
QQ
• Confirm a detection port at intervals of 20 msec to 50 msec (*2), and judge it as an overcurrent when you detected an
TEL 13942296513
error consecutively three times.
QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
*2 It is assumed that it is fixed value of the 20 msec to 50 msec degree.
F
www . x iao y u163. co m
42 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
[1] DC Protection Circuit Diagram A
MAIN ASSY
B
Q
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
GPT ASSY
D
SPEAKER ASSY
C
. F
B
VSX-820-K 43
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
[2] Overload Protection Circuit Diagram
B
MAIN ASSY
TEL
TEL
Q
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
PT ASSY
G
E
AMP ASSY
F
.
44 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
[3] Power DC Protection Circuit Diagram A
MAIN ASSY
B
Q
TEL
TEL
13942296513
13942296513
C
PT ASSY
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
G
VSX-820-K ONLY
D
R237
+5V
-5V
C232 C113
KIA7805API
KIA7905PI
IC114
IC102
KTC107S
R218
22k
Q203
C231 C110
47k
R219
22k
E
C222
R220
KIA78R33API
C225
IC111
Q106 KTB778
C211
R105
VSX-820-K 45
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
6. SERVICE MODE
QQ 376315150 892498299
6.1 SERVICE MODE
A
[1] Display mode for numbers of protection detections
[Purpose]
The numbers of detections for various protection processes are displayed.
[How to enter/exit]
During Standby mode, simultaneously press and hold the [PRESET –] and [STANDBY/ON] keys for 2 seconds to
enter this mode.
The display will return to the normal indication when no key operation is performed for 5 seconds.
B [Basic operations]
TEL
TEL
Key Operation FL Display Time (sec.) Description of Indications
13942296513
13942296513
(STANDBY state)
[PRESET –] +
[STANDBY/ON]
*2 5 (-> normal) *1 Number of DC error detections
(Initial display)
Counter
[ENTER key]
C
*2 5 (-> normal) *1 Number of OVERLOAD error detections
[ENTER key] Counter
QQ
QQ
*2 5 (-> normal) *1 Number of abnormal-temperature
376315150 892498299
(Initial display)
*1 “5 (-> normal)” denotes that the display will return to the normal indication when no key operation is
performed for 5 seconds.
*2 Variable range: 0-255
D
F
www . x iao y u163. co m
46 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
[2] Reset mode for numbers of protection detections
[Purpose]
For clearing all the counts of protection detections.
A
[How to enter/exit]
During Standby mode, simultaneously press and hold the [STANDARD SURROUND] and [STANDBY/ON] keys
for 10 seconds to enter this mode.
The display will return to the normal indication when no key operation is performed for 5 seconds.
B
[Basic operations]
TEL
TEL
Key Operation FL Display Time (sec.) Description of Indications
(STANDBY state)
13942296513
13942296513
[STANDARD SURROUND]
+ [STANDBY/ON]
5 (-> normal) *1
(press and hold the keys
for 10 seconds.)
[ENTER key]
C
QQ
QQ 3763 1515 0 89 2498 299
(Normal display) usually
TEL 13942296513 *2
376315150 892498299
376315150 892498299
*1 “5 (-> normal)” denotes that the display will return to the normal indication when no key operation is
performed for 5 seconds.
*2 Indication when the BD
D
function is selected
[Detailed explanations]
1. When the procedures for Reset mode for numbers of protection detections are completed, all the counters
will be reset to “000.”
2. Prohibitions:
The protection detection counts cannot be cleared (reset to 000) with the MEMORY CLEAR process.
They can only be cleared when the procedures of Reset mode are completed.
VSX-820-K 47
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
[3] The unit’s operation when a error is detected
[Purpose]
• The unit’s operation when a DC/OVER/TEMP error is detected is described here.
• How to cancel the status after detection of a DC error is described here, because no key input will be
accepted after a DC error detection.
[Basic operations]
3.1 DC (AMP is abnormality) error detection
Key Operation FL Display Time (sec.) Description of Indications
B
(Normal display) usually Normal display
TEL
TEL
(DC detection)
(Auto)
(RECEIVER POWER OFF)
13942296513
13942296513
*1, *2
(OVERLOAD detection)
(Auto)
QQ
QQ
(RECEIVER POWER OFF)
376315150 892498299
3.3 TEMP (AMP overheat) error detection
Key Operation FL Display Time (sec.) Description of Indications
(STANDBY state)
[ADVANCED SURROUND]
+ [STANDBY/ON]
(press and hold the keys
x iao y u163. co m
for 2 seconds.)
www
(Normal display) usually Normal display
F
.
[Detailed explanations] Simultaneously holding the [ADVANCD SURROUND] and [STANDBY/ON] keys on the
front panel pressed for 2 seconds will cancel Key Input Inhibition mode after a DC error
detection and turn the unit ON.
48 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
7. DISASSEMBLY
QQ 376315150 892498299
Note:
(1) Even if the unit shown in the photos and illustrations in this manual may differ from your product, the
procedures described here are common.
(2) For performing the diagnosis shown below, the following jigs for service is required:
A
1. Discharging B
[1] MAIN Assy Capacitor (C179, C180)
[Procedures]
TEL
TEL
(1) Unplug the power cord.
(2) Disconnect the 8P CONNECTOR that connects the CN202 of the AMP Assy and CP107 of the MAIN Assy from the CP107.
(3) Connect CP107 B+ (pins 5 and 6) and B- (pins 7 and 8, respectively) terminals, using resistor leads with 47 - 100 ohms
13942296513
13942296513
(2 W or higher), for discharging.
∗ Discharging time: 30 - 60 seconds, depending on the level of resistance.
(4) Check that the voltage between the B+ and GND terminals, as well as that between the B- and GND terminals, is less
than 1 V, using a tester.
∗ Be sure to connect the GND terminal of the tester to the chassis.
∗ If the voltage is still 1 V or higher, repeat Step (3). C
QQ
QQ
C180 C179
376315150 892498299
B+ 47 - 100 ohms
B– (2 W or higher)
CP107
47 - 100 ohms
(2 W or higher)
. F
VSX-820-K 49
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
2. Notes on Ground Points Connection
[Note]
During repair, before checking the MAIN Assy, etc., with the rear chassis removed, be sure to connect the
GND terminal of the main capacitor to the chassis back (TUNER PACK chassis), as shown below, then connect the
power cord.
TEL
TUNER PACK chassis
Chassis back
13942296513
13942296513
GND wire
(Be sure to disconnect the GND wire
before reassembly.)
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
MAIN Assy (SIDE B)
F
www . x iao y u163. co m
50 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
3. Disassembly
1 1 1 1 1 1 B
• Bottom view
TEL
TEL
13942296513
13942296513
(2) Remove the four screws. (BBZ30P080FTC) (VSX-820-K) (VSX-520-K)
C
2 2
2 2
2 2
GUIDE_L Assy GUIDE_R Assy GUIDE_R Assy
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
(VSX-820-K) (VSX-520-K)
(3) Remove the two screws. (BBZ30P080FTC)
(4) Unhook the two hooks.
D
3 3 3
4 4 4
(5) Arrange the front panel section as shown Front panel section E
in the photo below.
5
VSX-820-K 51
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
CABLE DRESSING (VSX-820-K ONLY)
(1) Secure the wires from the USB Assy. (4) Style the 4P wire (F-VIDEO) so that it goes below the
corresponding cables marked with circles in the figure
Wire (USB <-> DSP) below.
B 4P wire
TEL
TEL
GUIDE_R Assy Wire (USB <-> MAIN)
13942296513
13942296513
(2) Secure the card cable with the clamps. (5) Style the remaining two wires above wire A, which
C
Clamp connects the AMP and INPUT Assys.
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
Card cable
Style the wires so that they
are placed above wire A.
(3) Wrap the remaining wires with CU tape foil then secure
them with a cable tie.
Wires
E
Wire A
CU tape foil
F
www Cable tie
. x iao y u163. co m
52 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
(6) Secure the cables bound with CU tape foil to the chassis,
using a cable tie for grounding.
A
B
TEL
TEL
Chassis CU tape foil Cable tie
13942296513
13942296513
• The wires bound with CU tape foil (part No.: 1220-21087-900-0S) are shown below.
Front side Rear side
Directly mounted wire
USB Assy DSP Assy
C
Directly mounted wire
F-VIDEO Assy MAIN Assy
QQ
MIC Assy INPUT Assy
376315150 892498299
it is necessary to peel off CU tape foil to unbind the wires in order to disconnect them.
After repair, wrap the wires again, using new CU tape foil.
When repairing an assy on the rear side, as the wires are disconnected/connected
with connectors, you don't have to peel off CU tape foil.
D
After disconnecting the wires, style them again, following the procedures shown above.
VSX-820-K 53
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
[2] Heatsink Section
Caution: Heatsink section in work becomes hot,
and be careful with it.
Remove the cabinet by removing the 10 screws.
(VSX-820-K) (VSX-520-K)
(1) Remove the seven screws. (BBZ30P080FTC)
B 1 1 1
1 1 1
TEL
TEL
1 1 1
13942296513
13942296513
C
• Bottom view
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
(2) Remove the four screws. (BBZ30P080FTC) (VSX-820-K) (VSX-520-K)
D
2 2
2 2
2 2
GUIDE_L Assy GUIDE_R Assy GUIDE_R Assy
3
CP801
F
. CP107
54 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
(4) Connect the two extension jig cables.
(5) Rotate the heatsink section in the direction of
the arrow.
4
10P extension jig cable
(GGD1628)
4
8P extension jig cable
(GGD1629)
A
CP107
CP801
TEL
TEL
13942296513
13942296513
Heatsink section + AMP Assy
Note:
The power transistor on the AMP Assy and
heatsink on the MAIN Assy come closer.
QQ
QQ
Make sure that they will not come into contact. AMP Assy
376315150 892498299
Heatsink
VSX-820-K 55
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
[3] MAIN Assy
Remove the cabinet by removing the 10 screws.
1 1
B 1 1 1 1 1
• Rear view (VSX-520-K)
TEL
TEL
1 1
13942296513
13942296513
1 1 1 1 1
C
QQ
TEL 13942296513 QQ 3763 151530 89 24928 299
376315150 892498299
376315150 892498299
3
3
3 2
D 3
3
2
F
www . x iao y u163. co m MAIN Assy
56 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
[4] DSP Assy (for VSX-820-K)
Remove the cabinet by removing the 10 screws.
(1)
(2)
Remove the five screws. (B020930083B10-IL)
Remove the one screw. (BMZ30P100FTB) 1 ×5 3 ×24
Chassis back
A
4 4
4 2 4 B
4 4 4
5
TEL
TEL
• Rear view
13942296513
13942296513
(6) Remove the DSP Assy. DSP Assy BT Assy
(7) Remove the two connectors and remove the
BT Assy.
7
QQ
QQ
6
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
(8) Connect the board to board extension jig cable. Chassis back
(9) Reassembling the chassis back. 9
Secure the HDMI, INPUT, and VIDEO Assys,
using at least one screw each, and the chassis 10
back and chassis, using at least two screws.
(10) Remove the one connector and remove the CNT2 Assy
CNT2 Assy. E
Notes:
The soldered portions of the extension jigs may
have become in poor connection, depending on
usage environment, etc. Be sure to confirm
soldered portions before use and enhance
.
During failure diagnosis using the extension jig,
8 F
the cable connecting CP200 on the MAIN Assy Board to board extension
and CN200 on the DSP Assy can be disconnected. jig cable (GGD1673) DSP Assy
VSX-820-K 57
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
[4] DSP Assy (for VSX-520-K)
Remove the cabinet by removing the 10 screws.
3 3
B 3 3
3 3 3
TEL
TEL
4
• Rear view
13942296513
13942296513
(5) Remove the DSP Assy. DSP Assy BT Assy
(6) Remove the two connectors and remove the
BT Assy.
C
6
QQ
QQ
TEL 13942296513 QQ 37563 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
(7) Connect the board to board extension jig cable. Chassis back
(8) Reassembling the chassis back. 8
Secure the HDMI, INPUT, and VIDEO Assy,
using at least one screw each, and the chassis 9
back and chassis, using at least two screws.
(9) Remove the one connector and remove the CNT2 Assy
E
CNT2 Assy.
Notes:
The soldered portions of the extension jigs may
have become in poor connection, depending on
usage environment, etc. Be sure to confirm
58 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
8.1 HOW TO UPDATE FIRMWARE
A
[1] MAIN, SUB, USB and DSP microcomputers
[Purpose]
Refer to this section when updating the firmware of each microcomputer is required by the service information, etc.
[Necessary Tools]
• PC with a serial port • Firmware ("mot" extension)
• RS-232C cable (9-pin to 9-pin, straight cable) • Firmware for updating USB (VSX_USB.rom)(VSX-820-K ONLY)
• RS-232C UPDATE jig : GGF1642 (Do not use FFC of GGF1642. Remove it and
• 10P to 8P FFC : GGD1676 insert GGD1676 on 10 pin connector of board.)
B
[Connections]
TEL
TEL
Connect as shown in the figure below.
10P to 8P FFC Rear side (VSX-820-K)
Insert the FFC with its contact surface UPDATE jig GGD1676
facing the " mark. GGF1642
13942296513
13942296513
(SUB microcomputer) 8P
RS-232C
Straight cable
PC
10P
(MAIN microcomputer)
8P
QQ
QQ
1) MAIN and SUB microcomputers
TEL 13942296513
[Procedures]
QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
1 Start up the application on the PC before plugging in the 4 Select the update file and enter ID.
power cord of the main unit.
2 Enter ID.
Enter "ff" in all field.
3 Press the OK button. Select "***.mot" file to update the MCU. Press the OK button.
2 Enter ID.
.3 F
VSX-820-K 59
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
5 Set speed update and update the MCU.
TEL
Set Baud rate to 38400.
Press the E.P.R button.
13942296513
13942296513
Press OK button.
C
6 Finished.
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
7 Press the EXIT button to terminate the updating program.
Unplug the AC cord of the unit then disconnect the FFC of the updating jig.
E
If the following messages are displayed, shut the update program down, and start the update again from step 1.
F
www . x iao y u163. co m
60 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
2) How to Update the USB Microcomputer (VSX-820-K ONLY)
[Procedures]
1. Copy the “VSX_USB.rom” file to the root directory of a USB memory device.
A
2. Press the iPod USB key on the remote control unit to select iPod/USB function then connect the USB memory device.
3. After accessing the USB memory device, “UPG? NO” is displayed on the FL display and “UPDATE? NO” is displayed
as an On-Screen display.
4. Press the iPod USB key on the remote control unit.
5. Send either iPod/USB Cursor Left or iPod/USB Cursor Right code.
6. “UPG? YES” is displayed on the FL display and “UPDATE? YES” is displayed as an On-Screen display.
7. After sending the iPod/USB Enter code, updating starts. (“UPDATE” is displayed on the FL display.)
8. When “UPG? NO” is displayed on the FL display and “UPDATE? NO” is displayed as the On-Screen display,
B
updating is completed.
9. Disconnect the USB memory device then turn the unit off.
TEL
TEL
[How to Confirm the Version of the USB Microcomputer]
1. Select the iPod/USB function then turn the unit off.
13942296513
13942296513
2. While holding the ENTER key on the front panel pressed, press the STNADBY/ON key.
3. When the receiver is turned on, press the ENTER key on the main unit three times.
(Each time the ENTER key is pressed, the indications on the FL display change as follows:
Main -> Sub -> DSP -> USB -> All segments lit.)
4. The version is displayed on the FL display, as “USB:***.”
C
Notes on updating
• If you perform updating of the same software twice, it may fail.
• If the indication “UPDATE” on the FL display does not change, let it sit for a few minutes.
QQ
QQ
If the indication on the FL display changes to one other than “UPDATE,” the unit becomes operable.
376315150 892498299
3) How to update the DSP Microcomputer
[Procedures]
1. Select an Input Function that allows reception via Optical input 1 or 2 then set the unit to STBY_Off mode. D
2. Press the SPEAKERS and STANDBY/ON keys simultaneously to enter DSP UpDate mode.
(“DSP UP” is displayed.)
3. When “PLAY” is displayed, playback of the .wav file starts. (Play the file only once. NEVER repeat playback.)
(“PLAY” is displayed.)
4. After playback is finished and “ENTER” is displayed, press the ENTER key on the front panel.
(“ENTER” is displayed.)
5. “WRITING” is automatically displayed.
6. After writing is completed, “COMPLETE” is displayed.
7. Turn the unit off then confirm that the version has been updated.
Reference
[ Display of each UCOM (microcomputer) version]
Make sure that the main unit is in Standby mode.
x iao y u163. co m
Press and hold the [ENTER] and [STANDBY/ON] keys, then press the [ENTER] key to display each UCOM version.
www
(Each time the ENTER key is pressed, the indications on the FL display change as follows:)
Pressing the [ENTER] key returns
[ENTER] [ENTER] [ENTER] [ENTER] the display to that for the version
MAIN SUB DSP USB
.
All segments lit. of the MAIN UCOM.
UCOM UCOM UCOM UCOM F
* The version of the USB microcomputer is displayed VSX-820-K
only when USB/IPOD FUNCTION is selected. ONLY
VSX-820-K 61
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
1. Idle Current Adjustment
TEL
TP201SL 3PIN : TEST POINT(+) (Condition : No signal and no load)
TP201SL 1PIN : TEST POINT(-) VR201SL
13942296513
13942296513
TP201SR 3PIN : TEST POINT(+)
TP201SR 1PIN : TEST POINT(-) VR201SR
QQ
TEL 13942296513 TP201SR 1PIN TP201C 1PIN
QQ 3763 1515 0 89 2498 299
TP201SL 1PIN TP201FL 1PIN
376315150 892498299
376315150 892498299
TEST POINT(-) TEST POINT(-) TEST POINT(-) TEST POINT(-)
Idle current Idle current Idle current Idle current Idle current
VR: VR201FR VR: VR201SR VR: VR201C VR: VR201SL VR: VR201FL
TP201FR 3PIN TP201SR 3PIN TP201C 3PIN TP201SL 3PIN TP201FL 3PIN
TP201FR 1PIN
TEST POINT(-)
F
. [Fig 1.]
62 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299 A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 63
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
NOTES: - Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.
A
- The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
- Screws adjacent to b mark on product are used for disassembly.
- For the applying amount of lubricants or glue, follow the instructions in this manual.
B
TEL
TEL
Cord AC
VSX-820-K/CUXCNSM
13942296513
13942296513
Only
VSX-820-K/CUXCNSM
Only
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
1/2
2/2
F
www . x iao y u163. co m
64 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
Mark No. Description Part No.
1 Remote Control See Contrast table (2)
NSP 2 Dry Cell Batteries G670001R50210-IL A
B
8 Poly Bag 6330210059000-IL
NSP 9 Poly Bag 6337040062010-IL
TEL
TEL
10 Box, Gift See Contrast table (2)
11 Cushion, Snow 6230212824000-IL
12 PE, Sheet 6327040059000-IL
13942296513
13942296513
13 Sheet 5227000001050-IL
NSP 14 Label VRW1629
15 • • • • •
NSP 16 Label Getter See Contrast table (2)
C
QQ
QQ
TEL 13942296513
(2) CONTRAST TABLE
QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
VSX-820-K/CUXCNSM and VSX-520-K/CUXCNSM are constructed the same except for the following:
VSX-820-K VSX-520-K
Mark No. Symbol and Description
/CUXCNSM /CUXCNSM
1 Remote Control 8300758300010-IL 8300758600010-IL
5 Setup Microphone (for Auto MCACC setup) M040000300200-IL Not used
D
6 iPod Cable L308102013010-IL Not used
7 Operating Instructions (En, Frca, Es) 5707000003160-IL 5707000003110-IL
10 Box, Gift 6007211700060-IL 6007211700000-IL
VSX-820-K 65
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
B
TEL
TEL
13942296513
13942296513
×6
×2
K
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
×2
376315150 892498299
376315150 892498299
×5
D
P ×3
×14
O
D O
×5
E 2/2
Nut
1/2
×5
F
. Nut
×6
N
E
66 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299 A
×4
×4 B
TEL
TEL
13942296513
13942296513
×34
×6
×7
C
×5
V
QQ
QQ
C
376315150 892498299
A
T
S
D
×2 ×6
L Silicon adhesive
(GYA1011)
×14
H
×2 ×3
×4 Q R
×4 I
A
×4
G ×5 E
1/2 ×15 A
B ×10
×5 ×5
×5
CONTACT SIDE
Silicon grease
(GEM1057)
×2
N
E . F
SIDE
VSX-820-K 67
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Mark No. Description Part No. Mark No. Description Part No.
B 56 • • • • •
11 GUIDE_R Assy 7028069118010-IL
12 VIDEO Assy 7028069141010-IL 57 • • • • •
58 • • • • •
TEL
TEL
13 F-VIDEO Assy 7028069123010-IL
14 FRONT Assy 7028069121010-IL 59 Screw 1500001456010-IL
15 FUNCTION Assy 7028069122010-IL 60 Screw BBT30P100FTB
13942296513
13942296513
16 MAIN Assy 7028069111010-IL 61 Screw BBT40P080FTB
17 REG Assy 7028069162010-IL 62 Screw BBZ30P080FTB
18 HDMI Assy 7028069191010-IL 63 Screw BBZ30P080FTC
19 DSP Assy 7028069161010-IL 64 Screw BBZ30P180FTC
20 USB Assy 7028069171010-IL 65 Screw BMZ30P100FTB
C
QQ
> 23 Transistor (Q2071-Q2075) J5011560Y0000-IL 68 Screw B028940101B11-IL
>
TEL 13942296513
24 Semi, Tr/Ge NPN 2SC
(Q2051-Q2055)
J502396400010-IL
QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
> 25 Transistor (Q2011-Q2015) J5032390Y0000-IL
31 Plate 4470211956000-IL
32 Sheet 1217211152000-IL
NSP 33 Heatsink 2120211378000-IL
34 Cabinet 3007211276200-IL
35 Panel Front 3067214861000-IL
36 Shield 3070210626000-IL
E NSP 37 Chassis 3200212676000-IL
38 Chassis Back 3207213456000-IL
39 Foot 4007210391000-IL
40 Bracket 4010056906010-IL
41 Cushion 4050211365000-IL
42 Cushion 4050211385000-IL
F
.
68 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299 A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 69
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
B
TEL
TEL
13942296513
13942296513
×6
×2
K
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
×2
376315150 892498299
376315150 892498299
×5
D
P ×3
×14
O
D O
×5
E
2/2
Nut
1/2 F
F
www . x iao y u163. co m Nut
×6
70 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299 A
×4
×4 B
TEL
TEL
×34
13942296513
13942296513
×6
×7 C
C ×4
V
QQ
QQ
QQ 3763 1515 0 89 2498 299
M
TEL 13942296513
376315150 892498299
376315150 892498299
A
T
S
D
×6
×2
L Silicon adhesive
(GYA1011)
×14
H
×2 ×3
×4 Q R
×4 I
A
×4
×2 G ×5 E
A
1/2 F ×15
B ×10
×5
×5
CONTACT SIDE
Silicon grease
(GEM1057)
. F
SIDE
VSX-820-K 71
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
Mark No. Description Part No. Mark No. Description Part No.
B 56 • • • • •
11 GUIDE_R Assy 7028069118010-IL
12 VIDEO Assy 7028069141040-IL 57 • • • • •
58 • • • • •
TEL
TEL
13 • • • • •
14 FRONT Assy 7028069121020-IL 59 Screw 1500001456010-IL
15 FUNCTION Assy 7028069122010-IL 60 Screw BBT30P100FTB
13942296513
13942296513
16 MAIN Assy 7028069111060-IL 61 Screw BBT40P080FTB
17 REG Assy 7028069162010-IL 62 Screw BBZ30P080FTB
18 HDMI Assy 7028069191020-IL 63 Screw BBZ30P080FTC
19 DSP Assy 7028069161020-IL 64 Screw BBZ30P180FTC
20 • • • • • 65 • • • • •
C
QQ
> 23 Transistor (Q2071-Q2075) J5011560Y0000-IL 68 Screw B028940101B11-IL
>
TEL 13942296513
24 Semi, Tr/Ge NPN 2SC
(Q2051-Q2055)
J502396400010-IL
QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
> 25 Transistor (Q2011-Q2015) J5032390Y0000-IL
31 • • • • •
32 • • • • •
NSP 33 Heatsink 2120211378000-IL
34 Cabinet 3007211276200-IL
35 Panel Front 3067214851000-IL
36 • • • • •
E NSP 37 Chassis 3200212676000-IL
38 Chassis Back 3207213446000-IL
39 Foot (PLS) 4000210391000-IL
40 Bracket 4010056906010-IL
41 Cushion 4050211365000-IL
42 Cushion 4050211385000-IL
F
.
72 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299 A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 73
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
10.1 INPUT ASSY
A
(SW) (SW)
B
(SW)
V CP502
TEL
TEL
13942296513
13942296513
(SW)
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K ONLY
(SW)
E
(SW)
www x ao y u163. co m
VSX-820-K ONLY
F
.Q CP117i
Q CP118
A
74 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
(SW) (SW)
(FL)
B
(FL)
TEL
TEL
(C)
(C)
(SL)
B CN201
13942296513
13942296513
(SL)
(SW) C
(SW)
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
-K ONLY
VSX-820-K ONLY
N CN701
CP802(VSX-520-K)
VSX-520-K ONLY
VSX-520-K ONLY E
F CN703
E CN707
VSX-820-K ONLY
CP802(VSX-820-K)
.
(SW)
: Audio Signal Route (Subwoofer ch) F
Q CP120
I CN121B A
VSX-820-K 75
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
B AMP ASSY (7028067523010-IL)
IDLE
CURRENT
B
TEL
TEL
13942296513
13942296513
(FL) (FL) (FL)
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
CP801
376315150 892498299
376315150 892498299
IDLE
A
(SL)
(FL)
: Audio Signal Route (Front L ch)
F
.
B
76 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
The > mark found on some component parts
indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts A
of identical designation.
IDLE
CURRENT B
TEL
TEL
13942296513
13942296513
CP107
Q
(FL)
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
CN401
IDLE
CURRENT
376315150 892498299
376315150 892498299
(FL) (FL)
(SL)
C
(C)
(SL)
IDLE
(C) CURRENT (C) (C)
B
VSX-820-K 77
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
C SPEAKER ASSY (7028069151010-IL: VSX-820-K) (7028069151030-IL: VSX-520-K)
CN106
VSX-820-K
ONLY
(FL)
Q
(FL)
CP203
(FL)
(FL)
(SL)
(C)
(SL)
B
B
CN104
(SL)
TEL
TEL
Q
(SL)
13942296513
13942296513
CN103
C
Q
(C) (C)
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
1. SET OPTION TABLE
NO. Ref. NO. VSX-820 VSX-520
1 CP405 5267-02A NM
2. VSX-820/520 DESTINATION OPTION TABLE
NO. Ref. NO. 820CUXCNSM OTHER
1 J416 JUMPER NM
2 J417 NM JUMPER
3 JACK401 SCREW 8P SCREW 4P
4 JACK402 NM PUSH 4P
D 5 JACK403 SCREW 2P PUSH 2P
VSX-820-K ONLY
D HEADPHONE ASSY
(7028069114010-IL)
CP802
F
www . x iao y u163. co m (FL)
(SL)
(C)
: Audio Signal Route (Front L ch)
: Audio Signal Route (Surround L ch)
: Audio Signal Route (Center ch)
78 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
10.4 PORTABLE, PT, HP_GUIDE, CNT1, CNT2, GUIDE_L and GUIDE_R ASSYS
QQ 376315150 892498299
CP802
A
VSX-520-K
ONLY A
F PORTABLE ASSY
(702806911A010-IL)
G PT ASSY (7028069112010-IL) B
H HP_GUIDE ASSY
(7028069115010-IL)
TEL
TEL
CP128
13942296513
13942296513
Q
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
Q Q CP125 CP126
J CNT2 ASSY
CNT1 ASSY (7028069113010-IL)
I (7028069119010-IL) D
CP121
CP805
Q
E
S CP703
K GUIDE_L ASSY
(7028069117010-IL) L GUIDE_R ASSY
(7028069118010-IL)
F G H I J K L
VSX-820-K 79
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
VSX-820-K
A
M VIDEO ASSY ONLY
(7028069141010-IL: VSX-820-K)
MONITO
CONTRO
INPUT
330(VSX-820-K)
0(VSX-520-K)
CVB
(BU4
IN
INH
L
B
L
L
TEL
TEL
L
13942296513
13942296513
(Y)
(Cb)
QQ
QQ
QQ 3763 1515 0 89 2498 299
(Cr)
TEL 13942296513
376315150 892498299
376315150 892498299
VSX-820-K
ONLY
VSX-520-K
(Y) ONLY
D
(Cb)
(Y)
(Cb)
(Cr)
(Cr)
COMPONENT
NJM2586M
SW1 SW2
E FUNC
OSD L L/H
IN1 H L
IN2 H H
-5V
COMP_SW1
CVBS_C
COMP_SW2
+5V
COMP_MUTE
CVBS_MUTE
F
.
M Q CP122
80 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
VSX-820-K
ONLY
MONITOR DVR-REC A
CONTROL-A CONTROL-C
OSD L OUT L
INPUT H MUTE H
R1058
30(VSX-820-K)
(VSX-520-K)
CVBS INPUT SW
(BU4051BCF)
INPUT
OUTPUT FUNCTION
INH A B C
H X X X X X
L L L L Y0 VIDEO
L H L L Y1 DVD
L L H L Y2 TV/SAT
L H H L Y3 BD
DVR/VCR
B
L L L H Y4
REC MUTE
L H L H Y5 -
L L H H
TEL
TEL
Y6 -
L H H H Y7 -
13942296513
No. (NTSC) (PAL) (NTSC / PAL SELECT)
REF. No.
* VSX-820 AREA OPTION 1 XTAL1001 14M318(18P) NM 14M318(18P) NM
2 J1001 0-1608 NM NM NM
3 XTAL1002 NM 17M734(18P) 17M734(18P) NM
4 J1005 NM 0-1608 NM NM
Q1007
5 NM NM RT1N430C NM
Q1008
6 Q1006 NM NM RT1P141C NM
7 J1028 NM NM 0-3216 NM
8 R1057(AXIAL) 330 330 330 NM
9 R1058(AXIAL) 330 330 330 JUMPER
10 R1028 330-1608 330-1608 330-1608 NM
11 C1041 NM NM NM 1/50 C
12 R1041 NM NM NM 10K-1608
13 R1025(AXIAL) 330 330 330 NM
14 C1046 100/10 100/10 100/10 NM
15 J1021(AXIAL) JUMPER JUMPER JUMPER NM
16 R1039(AXIAL) JUMPER JUMPER JUMPER NM
17 L1001(AXIAL) 33uH 33uH 33uH NM
QQ
QQ
18 IC1002 LC74781 LC74781 LC74781 NM
19 R1040 0-1608 0-1608 0-1608 NM
376315150 892498299
23 R1024 200 200 200 NM
24 C1011 15P-1608 15P-1608 15P-1608 NM
25 C1015 18P-1608 18P-1608 18P-1608 NM
26 C1013,C1022 10N-1608 10N-1608 10N-1608 NM
C1023
27 Q1011 ISA1530AC1 ISA1530AC1 ISA1530AC1 NM
28 J1016,J1017 0-1608 0-1608 0-1608 NM
J1014,J1042
29 R1015,R1017 470-1608 470-1608 470-1608 NM
R1019
30 R1013 1M-1608 1M-1608 1M-1608 NM
31 J1024,J1033 JUMPER JUMPER JUMPER NM
32 C1020 270P-J 270P-J 270P-J NM D
33 C1017,C1019 24P-1608 24P-1608 24P-1608 NM
34 C1012 100/10 100/10 100/10 NM
35 J1059 0-3216 0-3216 0-3216 NM
J1062,J1015
36 C1024,C1030 100P-J 100P-J 100P-J NM
37 R1026 2K2 2K2 2K2 NM
38 C1042 10P-D 10P-D 10P-D NM
39 R1027 10 10 10 NM
40 Q1005 2SC3052 2SC3052 2SC3052 NM
41 R1029 560 560 560 NM
ZD1001
5.6V
OSD_DATA
OSD_CE
OSD_CLK
Q CP123 M
VSX-820-K 81
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
VSX-820-K ONLY
O
FRONT ASSY
(7028069121010-IL:
N F-VIDEO ASSY (7028069123010-IL) VSX-820-K)
(7028069121020-IL:
VSX-520-K)
B
A CP804
Q CP110
TEL
TEL
13942296513
13942296513
C
QQ
QQ 3763 1515 0 89 2498 299
The > mark found on some component parts
TEL 13942296513
indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts
376315150 892498299
376315150 892498299
of identical designation.
P FUNCTION ASSY
(7028069122010-IL)
F
www . x iao y u163. co m
N O P Q FPC10
82 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
10-IL:
A
20-IL:
B
TEL
TEL
13942296513
13942296513
VSX-820-K
ONLY
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K
ONLY
. F
Q FPC101
23P: VSX-820-K
19P: VSX-520-K O
VSX-820-K 83
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
M CN1001
KDS4148U
C
TEL
TEL
CP402
M CN1002
C
13942296513
13942296513
CP405
I
CN121A
VSX-820-K
ONLY
C N
CN701
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
B CN202
R REG ASSY
(7028069162010-IL)
G CN201
D
IN
GND
OUT
G
CN202
F
www
• NOTE FOR FUSE REPLACEMENT
. x iao y u163. co m
CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE,
REPLACE WITH SAME TYPE AND RATINGS OF FUSE.
H CN601
Q R
84 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
CN807
A
VSX-820-K ONLY
T 1/2 CN203
CN702
B
CN803
S
TEL
TEL
A
13942296513
13942296513
CN701
CP501
S
C
V
T 2/2 CN204
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299 R145
47k: VSX-820-K
OPEN: VSX-520-K
R146
OPEN: VSX-820-K
47k: VSX-520-K
CN806
376315150 892498299
376315150 892498299
A
VSX-820-K
ONLY
FROM HEATSINK
REG ASSY E
KIA7805API
VSX-820-K
ONLY
Q
VSX-820-K 85
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
B
TEL
TEL
13942296513
13942296513
HDMI Receiver IC
VSX-820-K
QQ
QQ
ONLY
376315150 892498299
D
VSX-820-K
ONLY
F
www . x iao y u163. co m Q CP111
S
86 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
B
TEL
TEL
HDMI Transmitter
13942296513
13942296513
C
K
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
CN703A
J
E
Q CP112
S
VSX-820-K 87
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
T 1/2 DSP ASSY
(7028069161010-IL: VSX-820-K)
(7028069161020-IL: VSX-520-K)
The > mark found on some component parts
indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts
of identical designation.
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
(FL)
: Audio Signal Route (Front L ch)
(SBL)
(SL)
(SW)
(SL)
(FL)
(C)
: Audio Signal Route (Center ch)
(SW)
E : Audio Signal Route (Subwoofer ch)
(SBL)
: Audio Signal Route (Surround Back L ch)
T 1/2
www . x iao y u163. co m Q CP114
88 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299 A
VSX-820-K
ONLY
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
T 2/2
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
(SBL)
(SW)
(C)
4
www . x iao y u163. co m
Q CP115
T 1/2
F
VSX-820-K 89
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
T 2/2 DSP ASSY
(7028069161010-IL: VSX-820-K)
(7028069161020-IL: VSX-520-K)
VSX-820-K
ONLY
B
Q CP200
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
T 1/2
T 2/2
www . x iao y u163. co m Q CP116
90 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
CN805
A
U
VSX-820-K
ONLY
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
x iao y u163. co m
of identical designation.
www .
T 2/2
F
VSX-820-K 91
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
U USB ASSY (7028069171010-IL)
T 2/2 CP105
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
F
www . x iao y u163. co m
U
92 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
O CN802 Q CP105 A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
U
VSX-820-K 93
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
10.12 BT ASSY
QQ 376315150 892498299
V BT ASSY (7028069181010-IL)
B
TEL
TEL
13942296513
13942296513
A
C
CN502
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
Q
CN501
F
www . x iao y u163. co m
V
94 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
NOTE FOR PCB DIAGRAMS :
1. The parts mounted on this PCB include all
necessary parts for several destinations.
2. View point of PCB diagrams.
Connector Capacitor
A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
VSX-820-K 95
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A SIDE A
A
A INPUT ASSY
VSX-820-K
Only
CN701
CP804
B
N
TEL
TEL
CP117
CN807
13942296513
13942296513
Q
CP502
CN502
V
CP118
C
CN803
Q
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
CN121B
CP805
D
ICP120
CN806
Q
CP801 CP802
A
96 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE B SIDE B
A
A INPUT ASSY
B
TEL
TEL
CN807
13942296513
13942296513
CP804
C
CN502
CN803
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
CP805
D
CN806
CP802 CP801
.
Q812 Q814 Q806 Q808 Q805 Q801 Q803 Q811
F
A
VSX-820-K 97
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A
A
Q VR
CN201 CN202 CP203
Q202C
Q203FR Q204FR
Q206C
Q204C
Q204SR
Q203SL
Q204SL
Q204FL Q206SR
Q203FL
B Q203SR Q202SL
Q202SR Q206FR
Q206SL
Q202FL
Q206FL
TEL
TEL
Q202FR
VR201FL
VR201FR
13942296513
13942296513
VR201SR
VR201SL
VR201C
C
Q205FR
Q205SR
Q205C
Q201SL
Q201SR Q201FL
Q201C Q201FR
Q207FR
QQ
QQ
Q207FL Q207SL
Q207FL Q207SL
TEL 13942296513
376315150 892498299
376315150 892498299
SIDE B
B AMP ASSY
D
F
www . x iao y u163. co m
CN201 CN202 CP203
B
98 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE A
A
C CN401
CP203
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
SIDE B
www
CP203
. x iao y u163. co m F
B
VSX-820-K 99
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A SIDE A
A
C SPEAKER ASSY
VSX-820-K
B
Only
TEL
TEL
CN106
CP405
13942296513
13942296513
QCP203
CN401
B
C
CP404
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
CP403 CP402
Q CN104 Q CN103
D VSX-820-K Only
E MIC ASSY
CN702
CN707
E
A CP802
VSX-520-K Only
F PORTABLE ASSY
D HEADPHONE ASSY
F
www . x iao y u163. co m CN703
C D E F A CP802
100 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE B SIDE B
A
C SPEAKER ASSY
B
TEL
TEL
CP405
13942296513
13942296513
CN401
CP404
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
CP402 CP403
VSX-820-K Only D
E MIC ASSY
CN702
CN707 IC703
VSX-520-K Only
www .
CN703 x iao y u163. co m F
C D E F
VSX-820-K 101
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A SIDE A
A
Q126
B Q134 Q135
Q136
TEL
TEL
13942296513
13942296513
CN201 CN202
Q CP125 Q CP126
CN601
C Q CP128
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
CP805
CP121
CN121B
CN121A
376315150 892498299
376315150 892498299
A
Q
CN703A
D
S CP703
F
www . x iao y u163. co m
G H I J K L
102 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE B SIDE B
A
B
TEL
TEL
13942296513
13942296513
CN202 CN201
CN601
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
CN121B
CN121A
376315150 892498299
376315150 892498299
CN703A
D
G H I J K L
VSX-820-K 103
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A SIDE A
A
M VIDEO ASSY
B
TEL
TEL
13942296513
13942296513
CP122
CN1001
C
Q
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
CP123
CN1002
D
Q
F
www . x iao y u163. co m
IC1002
M
104 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE B SIDE B
A
M VIDEO ASSY
B
TEL
TEL
13942296513
13942296513
CN1001
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
CN1002
D
M
VSX-820-K 105
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A
A
CP702
CN706
B
TEL
TEL
13942296513
13942296513
CN705_A CN802
C
U CP802 VSX-820-K
Only
CN705_B
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
P FUNCTION ASSY
D
O FRONT ASSY (2/2)
CP703
F
www . x iao y u163. co m
O P
106 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE A
A
Q702
FPC101
CP704
B
Q
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
VSX-820-K Only
D
Q CP110 A CP804
CN701
N F-VIDEO ASSY
N O
VSX-820-K 107
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE B
A
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D VSX-820-K Only O
CN701
N F-VIDEO ASSY
F
www . x iao y u163. co m
N O
108 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE B
A
IC701
CP702
CN706
B
TEL
TEL
13942296513
13942296513
CN802 CN705_A
CN705_B
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
P FUNCTION ASSY
CP703
O P
VSX-820-K 109
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A C CP402
CN103
VSX-820-K Only
C CP405
C CP403
CN104
M CN1001 M CN1
CP122 CP12
B
TEL
TEL
13942296513
13942296513
C
CP301
AC CORD
or INLET
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
CP303
376315150 892498299
376315150 892498299
POWER TRANSFORMER
CP101
D
CP102
CP109
H B G
x iao y u163. co m
CN601 CN202 CN202
www
CN207A
F
. IC103 IC104 Q106 IC111 Q107 IC114 Q123
RR
Q124 IC102
IC112 Q108 IC115
Q
110 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
N1001
122
M CN1002
CP123
I CN121A
CP121
VSX-820-K
Only
N CN701
CP110
A CN807
CP117
A CN803
CP118
T CN202
CP114
SIDE A
A
B
TEL
TEL
CN702
CP111
13942296513
13942296513
S
CN701
CP112
C
S
CN203
QQ
QQ
CP115
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
T
D
CP704
FPC101
O
E
x iao y u163. co m
CP501 A CN806 T CN204
www
G CN201
CN207A
T CN200
.
R REG ASSY VSX-820-K Only F
QQ 376315150 892498299
SIDE B
Q MAIN ASSY
CP111
CP114
CP115
CP117
CP118 CP122
CP112 CP116 CP120 CP110 CP121 CP123
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
FPC101
CP126
CP200 CP125
CN20
CN501
F
. IC120 IC110 IC109 IC106
REG ASSY
Q202 Q201 Q137 Q20
IC101 Q112
Q R
112 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
CP122 CN106
SIDE B
A
B
TEL
TEL
13942296513
13942296513
C
CP301
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
CP303
376315150 892498299
376315150 892498299
CP101
D
CP102
CP109
EG ASSY
202 Q201 Q137 Q203
. Q111 Q301 Q101 Q300 Q138
F
IC301 Q302
Q
VSX-820-K 113
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A SIDE A
A
S HDMI ASSY J CN703A
CP703
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
Q CP112 Q CP111
F
IC706
IC705 Q712
.
Q709 Q710 Q708
Q716
IC704
Q714
Q717-Q720
IC701 Q711
IC703
IC702 IC8311
S
114 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE B SIDE B
S HDMI ASSY A
CP703
B
TEL
TEL
13942296513
13942296513
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
Q713 Q715
Q706 Q707
Q703 Q704
.
Q701 Q702 F
S
VSX-820-K 115
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A SIDE A
A
T DSP ASSY
IC110
TEL
TEL
13942296513
13942296513
CP114
CN202
IC109
Q
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
IC106
CP115
CN203
Q
IC102
IC100
CP116
CN204
E IC101
Q
CN805
CP105
VSX-820-K
.
Q
Only
T
116 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE B SIDE B
A
T DSP ASSY
B
TEL
TEL
13942296513
13942296513
CN202
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
CN203
D
CN204
E
CP105
. F
T
VSX-820-K 117
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
QQ 376315150 892498299
SIDE A O CN802 SIDE A
A U USB ASSY CP802
B IC803
TEL
TEL
13942296513
13942296513
Q3
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
IC801
376315150 892498299
376315150 892498299
D
E IC805
F
www . x iao y u163. co m
U T CP105 CN805 CN807 Q CP105
118 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
SIDE B SIDE B
U USB ASSY CP802 A
B
IC802
TEL
TEL
13942296513
13942296513
IC804
C
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 2498 299
376315150 892498299
376315150 892498299
D
Q2
CN807 CN805
U
VSX-820-K 119
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
11.11 BT ASSY
QQ 376315150 892498299
SIDE A SIDE A
A
V BT ASSY
CN502
TEL
TEL
CP502
A
13942296513
13942296513
CP501
Q500 IC500
C
Q CN501
QQ
QQ
TEL 13942296513 QQ 3763 1515 0 89 24SIDE
98B299
376315150 892498299
376315150 892498299
SIDE B
D
V BT ASSY
CP501
CP502
F
www . x iao y u163. co m
V
120 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
QQ 376315150 892498299
NOTES: -
-
Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
- When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47 k ohm (tolerance is shown by J = 5%,
and K = 10%).
A
- Meaning of the figures and others in the parentheses in the parts list.
B
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board.
IC 301 (A, 91, 111) IC NJM2068V
TEL
TEL
- PCB PARTS LIST - SCHEMATIC DIAGRAM and PCB CONNECTION DIAGRAM
JA*** JACK***, JK***
RY*** RLY***
T*** PT***
13942296513
13942296513
X*** XTAL***, RES*** (CERAMIC)
FU*** F***
V*** FLT***
S*** SW***, VEC*** (ENCODER)
L*** FB***
CN*** CP***, PN***
Q*** Q***FL, Q***FR, Q***C, Q***SL, Q***SR
D*** ZD*** C
Mark No. Description Part No. Mark No. Description Part No.
LIST OF ASSEMBLIES NSP 1..DSP ASSY (VSX-820-K) 7025HK0916015-IL
QQ
QQ
NSP 1..MAIN ASSY (VSX-820-K) 7025HK0916010-IL
TEL 13942296513
NSP 1..MAIN ASSY (VSX-520-K) 7025HK0915010-IL
2..DSP ASSY (VSX-820-K) 7028069161010-IL
2..MAIN ASSY (VSX-820-K) 7028069111010-IL
2..DSP ASSY (VSX-520-K) 7028069161020-IL
376315150 892498299
376315150 892498299
2..MAIN ASSY (VSX-520-K) 7028069111060-IL 2..REG ASSY 7028069162010-IL
2..PT ASSY 7028069112010-IL
NSP 1..HDMI ASSY (VSX-820-K) 7025HK0916018-IL
2..CNT2 ASSY 7028069113010-IL NSP 1..HDMI ASSY (VSX-520-K) 7025HK0915016-IL
2..HEADPHONE ASSY 7028069114010-IL
2..HDMI ASSY (VSX-820-K) 7028069191010-IL
2..HP_GUIDE ASSY 7028069115010-IL
2..HDMI ASSY (VSX-520-K) 7028069191020-IL D
2..MIC ASSY (VSX-820-K ONLY) 7028069116010-IL
2..GUIDE_L ASSY 7028069117010-IL
NSP 1..USB ASSY (VSX-820-K ONLY) 7025HK0916016-IL
2..USB ASSY (VSX-820-K ONLY) 7028069171010-IL
2..GUIDE_R ASSY 7028069118010-IL
2..CNT1 ASSY 7028069119010-IL
NSP 1..BT ASSY 7025HK0916017-IL
2..PORTABLE ASSY (VSX-520-K ONLY) 702806911A010-IL
2..BT ASSY 7028069181010-IL
NSP 1..VIDEO ASSY (VSX-820-K) 7025HK0916013-IL
NSP 1..AMP ASSY 7025HK0916019-IL
NSP 1..VIDEO ASSY (VSX-520-K) 7025HK0915013-IL
2..AMP ASSY 7028067523010-IL
2..VIDEO ASSY (VSX-820-K) 7028069141010-IL
2..VIDEO ASSY (VSX-520-K) 7028069141040-IL
7028069123010-IL
A INPUT ASSY (VSX-820-K)
SEMICONDUCTORS
IC 801 J084152180010-IL
NSP 1..INPUT ASSY (VSX-820-K) 7025HK0916012-IL
x iao y u163. co m
IC 802-804 J121458000020-IL
www
NSP 1..INPUT ASSY (VSX-520-K) 7025HK0915012-IL Q 801,803,805,806 J522020011210-IL
2..INPUT ASSY (VSX-820-K) 7028069131010-IL Q 802,804,807,809 J520101411210-IL
2..INPUT ASSY (VSX-520-K) 7028069131020-IL Q 808,812,814,821 J522020011210-IL
.
NSP 1..SPEAKER ASSY (VSX-820-K) 7025HK0916014-IL Q 813,817,838,839 J520101411210-IL F
NSP 1..SPEAKER ASSY (VSX-520-K) 7025HK0915014-IL Q 815,816 J5441170Y0050-IL
2..SPEAKER ASSY (VSX-820-K) 7028069151010-IL Q 818 J522104411210-IL
2..SPEAKER ASSY (VSX-520-K) 7028069151030-IL Q 822,826,828,830 J522020011210-IL
VSX-820-K 121
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
Mark No. Description Part No. Mark No. Description Part No.
QQ 376315150 892498299
Q 832,834,836 J522020011210-IL R 209,210,215,216 N113136647820-IL
R 211 C00002216P520-IL
D 801-810,813,814 K005041480030-IL R 212,218 C00003336P520-IL
A D 9801,9802 (ZD801,802) K06006R844520-IL
R 213 C00003026P520-IL
MISCELLANEOUS R 214 C060010065520-IL
JA 801 TER,RCA 9PIN G607902AA131Y-IL R 219 C00003346P520-IL
JA 802,803 TER,RCA 6PIN G603610A02000-IL R 220 C00005616P520-IL
CN 502 CN,WIRE 2MM L002900042620-IL R 221,225 C00001226P520-IL
502 CN,WIRE 2MM L002900042620-IL
R 222 C00004736P520-IL
RESISTORS R 224 C060047063050-IL
R 874,875 C060010165060-IL R 226 C00004716P520-IL
R 227,229 C060010065050-IL
CAPACITORS R 228 N113135610020-IL
B C 821,861 D040221083090-IL
CAPACITORS
C 201,211 D00410107D051-IL
TEL
C 203 D00022106D051-IL
SEMICONDUCTORS C 204 D00033006D051-IL
IC 801 J084152180010-IL C 206,208 D040100087070-IL
13942296513
13942296513
IC 802-804 J121458000020-IL
Q 801,803,805,806 J522020011210-IL C 207 D040101082090-IL
Q 802,804,807,809 J520101411210-IL C 209 D004471277051-IL
Q 808,821,822,826 J522020011210-IL C 210 D004102277051-IL
C 212,213 D040101088050-IL
Q 815,816 J5441170Y0050-IL C 214,2131 D02010406C060-IL
C Q 817,838,839 J520101411210-IL
Q 818 J522104411210-IL C 215 D0422R208C050-IL
Q 828,830,832,834 J522020011210-IL
Q 836 J522020011210-IL
QQ
QQ 3763 1515 0 89 2498 299
D 801-810,813,814 K005041480030-IL
TEL 13942296513
D 9801,9802 (ZD801,802) K06006R844520-IL SEMICONDUCTORS
Q 401-404 J522102371210-IL
376315150 892498299
376315150 892498299
MISCELLANEOUS D 401-408 K005041480030-IL
JA 801 TER,RCA 9PIN G607902AA131Y-IL
JA 802,803 TER,RCA 6PIN G603610A02000-IL MISCELLANEOUS
CN 502 CN,WIRE 2MM L002900042620-IL JA 401 TER,BOARD SCREW 8P G614108V1010M-IL
502 CN,WIRE 2MM L002900042620-IL JA 403 TER,BOARD SCREW 2P G611201A0200Y-IL
D RY 401-403 RELAY G680120503020-IL
RESISTORS RY 404 RELAY G680240202030-IL
R 874,875 C060010165060-IL
RESISTORS
CAPACITORS R 401 C060033166520-IL
C 821,861 D040221083090-IL
CAPACITORS
C 401 D02015306C060-IL
B AMP ASSY
C 402 D02010406C060-IL
SEMICONDUCTORS
E
Q 202,206
Q 203,204
D 201
J5023200B0050-IL
J5000992F0050-IL
K000013300520-IL
C SPEAKER ASSY (VSX-520-K)
SEMICONDUCTORS
Q 401-404 J522102371210-IL
MISCELLANEOUS D 401-408 K005041480030-IL
L 201 COIL,FILTER-INDUCTOR D330900001330-IL
VR 201 VR,SEMI CARBON MOLD C541102315000-IL MISCELLANEOUS
TP 201 CN.WAFER 2.0MM L101200100320-IL JA 401 TER,BOARD SCREW 4P G612405E0200Y-IL
JA 402 TER,BOARD PUSH 4P G594408SA030Y-IL
RESISTORS JA 403 TER,BOARD PUSH 2P G592212A0300Y-IL
.
F R 205,223 C0604R7063050-IL R 401 C060033166520-IL
122 VSX-820-K
1 2 3 4
http://www.xiaoyu163.com
5
http://www.xiaoyu163.com
6 7 8
Mark No. Description Part No. Mark No. Description Part No.
QQD376315150 892498299
C 402 D02010406C060-IL
K GUIDE_L ASSY
MISCELLANEOUS A
HEADPHONE ASSY 0 JHMX9800 (ON) HAITI) 4330000120000-IL
SEMICONDUCTORS
D 705,706 K005041480030-IL
MISCELLANEOUS
JA 701 JACK,D6.5 G402PJ612AG0Y-IL
L GUIDE_R ASSY
MISCELLANEOUS
901,902,905 JHMX9800 (ON) HAITI) 4330000120000-IL
TEL
MISCELLANEOUS IC 1004 J040744053500-IL
JA 702 JACK,D3.5 G401PJ354H40Y-IL IC 1005 J040742440190-IL
13942296513
13942296513
IC 1006 J127762800010-IL
G PT ASSY
QQ
QQ
CN 1002 CN.WAFER 2.0MM L101100030510-IL
TEL 13942296513
SEMICONDUCTORS
QQ 3763 1515 0 89 2498 299
CAPACITORS
376315150 892498299
376315150 892498299
Q 126,128,131,134 J5001268B0050-IL C 1025 D040471081070-IL
Q 127,129,130,132 J5023198Y0000-IL
Q 133,135,136 J5023198Y0000-IL
D
D
112,113
9110
K005041480030-IL
K06603R34P400-IL M VIDEO ASSY (VSX-520-K)
SEMICONDUCTORS
IC 1001 J040744051500-IL D
MISCELLANEOUS
CN 0 CN.WAFER 2.0MM L101100030510-IL IC 1003 J171258600010-IL
CN 202 CONNECTOR (4P) L101100030410-IL IC 1004 J040744053500-IL
201 BRACKET 4010210196000-IL IC 1005 J040742440190-IL
IC 1006 J127762800010-IL
CAPACITORS
C 193,195 D040221082090-IL D 9001 K06605R64P400-IL
MISCELLANEOUS
H
JA 1001 TER,RCA 6PIN G603610D0400Y-IL
HP_GUIDE ASSY JA 1002 TER,RCA 9PIN G607902AD016Y-IL
MISCELLANEOUS CN 1001 CN.WAFER 2.0MM L101100030910-IL
CN 601 CONNECTOR (4P) L101100030410-IL CN 1002 CN.WAFER 2.0MM L101100030510-IL
E
601 BRACKET 4010210196000-IL
J CNT2 ASSY
MISCELLANEOUS
.
CN 7032 (CN703B) CN.FPC 1.0MM L130100150820-IL
FRONT ASSY (VSX-820-K) F
700 BRACKET 4010210196100-IL SEMICONDUCTORS
IC 701 J127163150010-IL
Q 701 J522102371210-IL
VSX-820-K 123
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
Mark No. Description Part No. Mark No. Description Part No.
QQ 376315150 892498299
Q 702 J5000933S0050-IL Q 106,107 J501778000010-IL
Q 703 J522101441210-IL Q 108 J5011049Y0010-IL
D 707,709 K005041480030-IL
A Q 111,112 J522102371210-IL
D 8701 (LED701) K500052009011-IL Q 121,123,124 J5001268B0050-IL
D 9701 (ZD701) K06007R544520-IL Q 122 J5023198Y0000-IL
Q 125 J5000916Y0050-IL
MISCELLANEOUS Q 137 J520015301210-IL
L 701 COIL D330101001020-IL
L 702 COIL,FILTER-INDUCTOR D330100700520-IL Q 201-203 J522101411210-IL
V 701 DISPLAY,FLT K530126300010-IL Q 302 J522101441210-IL
S 701-714,716 SWITCH G180501000010-IL D 101,102,104,114 K005041480030-IL
S 9701 (VEC701) SW,ENCODER G121123040011-IL D 106 K000013300520-IL
D 110,111,131-134 K000400700010-IL
CN 9702 (CP702) CONNECTOR (3P) L102526803010-IL
CN 9704 (CP704) CN.FPC 1.25MM L131125022320-IL D 125,127,128,135 K005041480030-IL
B
0 HOLDER 432004078301A-IL D 136,301-304,315 K005041480030-IL
U 701 MODULE,REMOCON E940349003810-IL D 137-140,305-308 K000400700010-IL
D 7101-7103 (BD101-103) K047604000020-IL
TEL
TEL
D 9101 (ZD101) K06603R34P400-IL
13942296513
SEMICONDUCTORS D 9105,9108 (ZD105,108) K06606R24P400-IL
IC 701 J127163150010-IL D 9107 (ZD107) K06003R344520-IL
Q 702 J5000933S0050-IL D 9301 (ZD301) K06605R14P400-IL
Q 703 J522101441210-IL D 9302 (ZD302) K06615R04P400-IL
D 707,709 K005041480030-IL
D 9701 (ZD701) K06007R544520-IL MISCELLANEOUS
C L 101,102 BEAD,COIL 7610010030000-IL
MISCELLANEOUS JA 101 JACK,DIN G403515397000-IL
L 701 COIL D330101001020-IL JA 102 TER,BOARD PUSH 4P G594408SA030Y-IL
L 702 COIL,FILTER-INDUCTOR D330100700520-IL JA 9101 (TUNER101) TUNER E903004100020-IL
V 701 DISPLAY,FLT K530126300010-IL RY 101 RELAY G680120503020-IL
QQ
QQ
QQ 3763 1515 0 89 2498 299
S 701-714,716 SWITCH G180501000010-IL
TEL 13942296513
S 9701 (VEC701) SW,ENCODER G121123040011-IL RY 302 RELAY
T 301 POWER TRANS
G680060102020-IL
8200280150620-IL
376315150 892498299
376315150 892498299
CN 9702 (CP702) CONNECTOR (3P) L102526803010-IL X 101 RESONATOR,CERAMIC E830160000060-IL
CN 9704 (CP704) CN.FPC 1.25MM L131125021920-IL CN 9101 (CP101) CN.FPC 1.25MM L131125022310-IL
0 HOLDER 432004078301A-IL CN 9111,9120 (CP111,120) CONNECTOR (14P) L101100041410-IL
U 701 MODULE,REMOCON E940349003810-IL
CN 9112 (CP112) CN.WAFER 2.0MM L101100041110-IL
D CN 9115 (CP115) CN.WAFER 2.0MM L101100040810-IL
CN 9116,9118 (CP116,118) CONNECTOR (19P) L101100041910-IL
P FUNCTION ASSY
CN 9117,9123,9125 (CP117,123,125) L101100040510-IL
CN.WAFER 2.0MM
SEMICONDUCTORS CN 9119 (CN119B) CN.FPC 1.0MM L130100150820-IL
D 711,712 K005041480030-IL
CN 9121 (CP121) CN.WAFER 2.0MM L101100040710-IL
MISCELLANEOUS CN 9122 (CP122) CN.WAFER 2.0MM L101100040910-IL
S 715 SWITCH G180501000010-IL CN 9126,9128 (CP126,128) CONNECTOR (4P) L101100040410-IL
S 9702 (VEC702) SW,ENCODER G121123050021-IL 0 SCREW B020030081B10-IL
101 HEAT SINK 2120210958050-IL
x iao y u163. co m
R 178,179 C141R10069010-IL
www
IC 109 J040740800230-IL
IC 110 J040740800240-IL
R 184 C0604R7065050-IL
IC 111 J12678R330010-IL
R 186 C060022065050-IL
IC 112 J126111733050-IL
R 304 C060010063050-IL
.
IC 114,115 J126780500110-IL
F
Mark No. Description Part No. Mark No. Description Part No.
QQ 376315150 892498299
C 179,180 D040682088010-IL CN 9121 (CP121) CN.WAFER 2.0MM L101100040710-IL
C 182-186 D02010407H080-IL CN 9122 (CP122) CN.WAFER 2.0MM L101100040910-IL
C 189 D040331088230-IL CN 9126,9128 (CP126,128) CONNECTOR (4P) L101100040410-IL
A
C 200 D040682083000-IL 0 SCREW B020030081B10-IL
C 201-203,208-210 D02047306C060-IL 101 HEAT SINK 2120210958050-IL
C 206 D040472084020-IL 104,114 HEAT SINK 2120000818020-IL
C 207 D040102084060-IL 904 JHMX9800 (ON) HAITI) 4330000120000-IL
C 229 D040221082090-IL FU 301 FUSE GLASS TUBE 20MM N751506301160-IL
TEL
IC 101 8952520000011-IL R 304 C060010063050-IL
IC 102 J126790500070-IL
IC 103 J126781200040-IL CAPACITORS
13942296513
13942296513
IC 104 J126791200060-IL C 101 D02010306C060-IL
IC 106 J000241600020-IL C 167,222,224 D040471082060-IL
C 179,180 D040682088010-IL
IC 111 J12678R330010-IL C 182-186 D02010407H080-IL
IC 112 J126111733050-IL C 189 D040331088230-IL
IC 114 J126780500110-IL
IC 120 J040742570030-IL C 200 D040682083000-IL C
IC 301 J126111700041-IL C 201-203,208-210 D02047306C060-IL
C 206 D040472084020-IL
Q 101,138,300,301 J522305200050-IL C 207 D040102084060-IL
Q 106,107 J501778000010-IL C 229 D040221082090-IL
QQ
QQ
Q 112 J522102371210-IL
TEL 13942296513
Q
Q
121,123,124
122 QQ 3763 1515 0 89 2498 299
J5001268B0050-IL
J5023198Y0000-IL
C
C
236
237-239
D040103083000-IL
D02047306C060-IL
376315150 892498299
376315150 892498299
C 301 D040222083010-IL
Q 125 J5000916Y0050-IL C 304 D00847208H010-IL
Q 137 J520015301210-IL
Q 201,203 J522101411210-IL
Q
D
302
104,114,125,127
J522101441210-IL
K005041480030-IL R REG ASSY
SEMICONDUCTORS
D
x iao y u163. co m
CN 9101 (CP101) CN.FPC 1.25MM L131125021910-IL
www
JA 701-705 CN.WAFER L109100190050-IL
CN 9111,9120 (CP111,120) CONNECTOR (14P) L101100041410-IL X 701 CRYSTAL CHIP (27 MHz) E80527R000050-IL
CN 9112 (CP112) CN.WAFER 2.0MM L101100041110-IL X 702 CRYSTAL CHIP (16 MHz) E80516R000050-IL
CN 9115 (CP115) CN.WAFER 2.0MM L101100040810-IL CN 701 CN.WAFER 2.0MM L101100031110-IL
CN 9116,9118 (CP116,118) CONNECTOR (19P) L101100041910-IL
.
CN 702 CONNECTOR (14P) L101100031410-IL
F
CN 9117,9123,9125 (CP117,123,125) L101100040510-IL CN 9703 (CP703) CN.WAFER 2.0MM L101200100820-IL
CN.WAFER 2.0MM
CN 9119 (CN119B) CN.FPC 1.0MM L130100150820-IL
VSX-820-K 125
5 6 7 8
http://www.xiaoyu163.com
1 2
http://www.xiaoyu163.com
3 4
Mark No. Description Part No. Mark No. Description Part No.
QQ 376315150 892498299
D 9200 (ZD200) K06002R444520-IL
A
S HDMI ASSY (VSX-520-K)
SEMICONDUCTORS
MISCELLANEOUS
JA 102 TER,RCA 1PIN
JA 105,106 OPTICAL RECEIVER
G600107A0000Y-IL
E100116500040-IL
IC 701 J126111712040-IL X 101 CRYSTAL CHIP (24.576 MHz) E80524R576050-IL
IC 702 SII9134CTU CN 202 CN.WAFER 2.0MM L101100032010-IL
IC 703 SII9233ACTU CN 203 CONNECTOR (8P) L101100030810-IL
IC 704 J126111710011-IL
IC 706 8952520000021-IL CN 204 CONNECTOR (19P) L101100031910-IL
MISCELLANEOUS
JA 702-705 CN.WAFER L109100190050-IL U USB ASSY (VSX-820-K ONLY)
TEL
TEL
X 701 CRYSTAL CHIP (27 MHz) E80527R000050-IL SEMICONDUCTORS
X 702 CRYSTAL CHIP(16 MHz) E80516R000050-IL IC 801 J085860000010-IL
CN 701 CN.WAFER 2.0MM L101100031110-IL IC 802 8952820000040-IL
13942296513
13942296513
CN 702 CONNECTOR (14P) L101100031410-IL IC 803 J001638165610-IL
IC 804 341S2164
CN 9703 (CP703) CN.WAFER 2.0MM L101200100820-IL IC 805 J046205100010-IL
QQ
JA 801 CN,PLUG CONTACT G480040101410-IL
TEL 13942296513
IC 109 J080458800010-IL D1 1 D,ESD CHIP K067012020020-IL
376315150 892498299
376315150 892498299
D2 2 D,ESD CHIP K067012020020-IL
IC 110 J040740400270-IL
IC 9101 (REG101) J126111712070-IL
IC
D
D
9103 (REG103)
101
9200 (ZD200)
J126111700041-IL
K005041480030-IL
K06002R444520-IL
V BT ASSY
SEMICONDUCTORS
D IC 500 J046255100010-IL
MISCELLANEOUS Q 500 J522101411210-IL
JA 102 TER,RCA 1PIN G600107A0000Y-IL
JA 105,106 OPTICAL RECEIVER E100116500040-IL MISCELLANEOUS
X 101 CRYSTAL CHIP (24.576 MHz) E80524R576050-IL CN 500 CONNECTOR CKS5712
CN 202 CN.WAFER 2.0MM L101100032010-IL CN 9501 (CP501) CN.WAFER 2.0MM L101200100820-IL
CN 203 CONNECTOR (8P) L101100030810-IL CN 9502 (CP502) CN.WAFER 2.0MM L101200100410-IL
701,702 BRACKET 4010210196100-IL
CN 204 CONNECTOR (19P) L101100031910-IL
CN 9105 (CP105) CONNECTOR (3P) L102526803010-IL
CAPACITORS
C 100 D040102081050-IL
E C 116,157,228 D040221082090-IL
C 146 D040222083010-IL