An ammonia compressor is driven by
a 200kw motor. The compressor and
the motor RPM are 380 and 1750,
respectively. The small sheave has
a pitch diameter of 152.4 mm. If
the bolt to be used is standard C-
120 (L = 122.9 in). Determine the
center distance between sheaves.
Ans. 806 mmA safety valve spring having a 9
and 0.5 coils has the ends squared
and ground. The outside diameter of
the coil is 115 mm and the wire is
13 mm. It has a free length of the
wire to which this spring must be
initially compressed to hold a
boiler pressure of 1.38 Mpa on the
seat of 32 mm diameter. Modulus of
rigidity is taken as G=80 GN/m2.
Ans. 172An engine of a motor vehicle with a
wheel diameter of 712 mm develops
50 kw at 2000 rom combined
efficiency of the differential and
transmission is 75% with an over
all speed reduction to 1. Determine
the torque to be delivered by the
clutch N-m
Ans. 239 N-mA single threaded trapezoidal
metric thread has s a pitch of 4
mm, and a mean diameter of 18 mm.
Ans: 32.6 N=mThe large diameter and face of the
disk of a multiple disk clutch are
255mm and 25mm respectively.
Ans: 15 683Determine the diameter of the stud
bolt that are required to fasten
down the cylinder head of a 203mm x
304mm gas engine.
PN ims caA flange bolt coupling consist of
eight steel 20mm diameter steel
bolts spaced evenly around a bolt
circle 300mm in diameter.
Ans. 40054 KPaA single square thread power screw
is to raise a load of 70 KN.
Ans. 12.526%A flange coupling is to be
designed, using 25 mm diameter
bolts at a distance of 152 mm from
the center of the shaft.
Ans. 5Find the horsepower required to
drive a power screw lifting a load
of 4000 lbs.
Ans. 4.395 hpWarwick screw....
Ans. 140.8
Ans. 4.418A flywheel has a mean diameter of 4
ft and is required to handle 2200
ft-lb of kinetic energy.
Ans: 334 1bFind the rim thickness for a cast
iron flywheel with a width of
200mm, a mean diameter of 1.2 ina
normal operating speed of 300 rpm,
Pc ems res)If the weight of 6” diameter by 48”
long SAE 1030 shafting is 174.5 kg
then what will be the weight of
chromium SAE 51416 of same size?
Ans. 347.96A 50” diameter diamond saw blade is
mounted on a pulley driven steel
shaft
Ans. 687.55A steel shaft transmits 40 hp at
1400 rpm.
Ans. 0.246 degrees/ footA multiple disc clutch of 10 steel
disc and 9 bronze disc.
Ans. 39.566 hpAn engine of a motor vehicle with a
wheel diameter of 712 mm develops
50 kw at 2000 rpm, the combined
efficiency of the differential and
transmission is 75% with an overall
speed reduction of 25 is to l.
Determine the speed reduction of
travel of the vehicle in km/ hr
Ans. 10. 74A railroad track is laid at a
temperature of 10 degree F with
gaps of 0.01 feet between the ends
of the rails.
Ans. 10409 psiWhat load P which causes total
deformation of 0.036 inch of a
steel rack with has a cross section
area of 4 sq. inches and a length
of 5 ft.
Ans. 72, 000