Professional Documents
Culture Documents
Decimal Places: 2
a. 5
b. 4
c. 3
d. 2
Question 2- Active Configuration
Unit System: MMGS (millimeter, gram, second)
Decimal Places: 2
-Activate configuration “C”
______________
Question 3- New Configuration “Z”
Unit System: MMGS (millimeter, gram, second)
Decimal Places: 2
-Create a new configuration based on configuration “A”
-Create a through hole as indicated in the image below that will be suppressed in all other configurations except for “D”
and “Z”. (This feature will only be unsuppressed in configurations “D” and “Z”)
a. 413.58
b. 550.64
c. 154.80
d. 399.97
Question 4- Switch Configuration
Unit System: MMGS (millimeter, gram, second)
Decimal Places: 2
-Activate Configuration “D”
_____________
Question 5- Design Table
Unit System: MMGS (millimeter, gram, second)
Decimal Places: 2
Material: Nickel
-Create a new configuration “E” by copying the row for configuration “B” and pasting a new row.
-Within the design table, assign the following dimensions to configuration “E”:
D3@sketch1=126
D4@sketch1=29
D5@sketch1=25
D2@sketch4=5
OuterDia@sketch1=42
____________
Segment 2B- Part Modifications
Question 6 – Change Feature Depth
Unit System: MMGS (millimeter, gram, second)
Decimal Places: 2
-Make the proper change to the part as indicated below. (change from 1 to 2)
________
Question 7 – Change Shell Thickness
Unit System: MMGS (millimeter, gram, second)
Decimal Places: 2
-Make the proper change to the part as indicated below. (change from 1 to 2)
____________
Question 8 – Feature History
Unit System: MMGS (millimeter, gram, second)
Decimal Places: 2
-Make the proper change to the part as indicated below. (change from 1 to 2)
_________________
Question 9 – Further Modification
Unit System: MMGS (millimeter, gram, second)
Decimal Places: 2
-Make the proper change to the part as indicated below. (change from 1 to 2)
Hint: the initial sketch needs to be modified; assume symmetry unless otherwise noted
__________