ay
Ni
UNIVERSITI
TEKNOLOGI
PETRONAS
TEST 2
Sais we Sas
COURSE : CEB 1043 - PRINCIPLES OF CHEMICAL
ENGINEERING
DATE ‘ 7 NOVEMBER 2019 (THURSDAY)
TIME : 5.00 PM — 6.30 PM (1 HOUR 30 MINUTES)
VENUE : TEST ROOM 1, BLOCK N
INSTRUCTIONS TO CANDIDATES
‘Answer ALL questions in the Answer Booklet.
Begin EACH answer on a new page
Indicate clearly answers that are cancelled, if any.
RON
Where applicable, show clearly steps taken in arriving at the solutions
and indicate all assumptions.
5. Do not open this Question Booklet until instructed.
Note: There are TEN (10) pages in this Question Booklet including the cover
page and the Appendices.CEB 1043
Define the following:
Limiting reactant.
[2 marks]
xe Excess reactant,
[2 marks]
In a reactor, 100 mol/s of methane was combusted with 50%
excess air in a complete combustion. Given that the fractional
conversion is 100%.
1 List the stoichiometric equation involved and caloulate the
Molar flow rate of oxygen and nitrogen fed to the reactor.
[4 marks]
Determine the mole fraction of each product stream
component on wet and dry basis.
[8 marks]
ii, If the combustion is partial, where 80% of methane is
Combusted to form CO2 and 20% of methane is combusted
to form CO, predict the flow rate of methane in the product
stream. Provide justification for your prediction.
[4 marks]CEB 1043
Benzene is changed from an initial condition of liquid at -10°C
and 6 atm to a final_condition of vapour at 100°C and 3 at
Construct the hypothetical process path for the change from the
inital to the final concition and calculate the enthalpy change.
[14 marks]
800 ofr saturated steam|at 10 bar enters into a heater and exits
the heater as saturated water liquid 2t § bar. Draw a flowchart of
aed ena a fowetanic
the process by indicating all the input and output process
variables and determine the heat loss (ki/hr from the heater,
[6 marks]